G6 V6-3.6L (2007)
Warranty Information
The intent of this bulletin is to identify the appropriate issue/s and apply the appropriate correction(s) pertaining to the customer's comments. To
determine the final service labor operation time, use the initial base time and then apply the appropriate add times depending on the issue correction(s)
performed. Please note - only the items performed on the vehicle being serviced should be used as the final repair time and the Repair Order must
indicate the Bulletin Number and the Condition Number(s) used.
Disclaimer
Condition # 1
Condition #1
Some customers may comment on creak/snap/pop type noise from the sunroof module that occurs while driving over bumps.
Cause
This condition may be caused by the module mounting bolts/fasteners (roof interaction with the fasteners).
Correction
For vehicles built before January 1st, 2006, perform steps 1-8 below (Install mylar washers and lubricate all fasteners). For vehicles built after January
1st 2006, ensure mylar washers are present and not damaged (cut through). If they are present and NOT damaged, lubricate all fasteners (perform Steps
5-8 only). If the mylar washers are damaged, perform Steps 1-8 below.
Important
Use hand tools only, power tools will not allow the compensator to seat properly.