SW1 L4-1.9L SOHC VIN 8 (1996)
Sunroof / Moonroof Motor: Technical Service Bulletins
Sunroof Motor - Revised Timing Procedure
BULLETIN NO.: 01-T-42
ISSUE DATE: September, 2001
CATEGORY TYPE: Body-08
CATEGORY: Sunroof
CORPORATION NO.: 01-08-67-005
SUBJECT:
Service Information to Provide New Procedure for "Sunroof Actuator (Motor) To Module Timing"
MODELS AFFECTED:
^
1996-2002 S-Series sedans equipped with power sunroofs (RPO CF5)
^
1997-2002 S-Series coupes equipped with power sunroofs (RPO CF5)
PURPOSE:
The purpose of this bulletin is to:
^
Provide a new "Sunroof Actuator (Motor) To Module Timing" procedure which will work with both the 1st design (P/N 21038460) and 2nd design
(P/N 21306076) actuators.
^
Update all 1996-1999 S-Series Body/Repair service manuals and all 2000/2002 S-Series Body/Electrical (Volume II) service manuals at your
location. The "Sunroof Actuator (Motor) To Module Timing" procedure currently in these service manuals can be used on the 1st design actuator
only and will not work with the 2nd design actuator. Please obtain all 2000/2002 S-Series Body/Electrical (Volume II) Service Manuals at your
location and make the necessary update to each manual as indicated below:
1.
Using a marker or pen, cross out the following procedures from the service manuals:
^
In the 2000/2002 S-Series Body/Electrical (Volume II) Service Manual, cross out the "Sunroof Actuator (Motor) To Module Timing"
procedure on page 1017.
^
In the 98-99 S-Series Body/Repair Service Manual, cross out the "Sunroof Actuator (Motor) To Module Timing" procedure on page 540.
^
In the 1997 S-Series Body/Repair Service Manual, cross out the "Sunroof Actuator (Motor) To Module Timing" procedure on page 486.
^
In the 96 S-Series Body/Repair Service Manual, cross out the "Sunroof Motor To Module Timing -- Sedan" procedure on page 484.
2.
Next to each procedure crossed out in step 1, write the following:
^
"Refer to Technical Bulletin 01-T-42"
