Removing and installing engine
Notes on installing
Installation is carried out in the reverse sequence, when doing this note the following:
-
‒ Check whether the dowel sleeves for centralising engine/gearbox are in the cylinder block, install if necessary.
-
‒ Install intermediate plate.
-
‒ Screw in all bolts on assembly mountings by hand approx. 5...6 turns.
-
‒ Align engine mountings stress-free by rocking.
Note:
Assembly mounting tightening torques
.
Vehicles with manual gearbox
-
‒ Lightly grease input shaft splines with G 000 100.
-
‒ Check clutch and clutch operating mechanism, then install.
=> 5-Speed manual gearbox 006; Repair group 30; Servicing clutch control
-
‒ Connect pipe/hose on slave cylinder and secure with clip:
=> 5-Speed manual gearbox 006; Repair group 30; Assembly overview; hydraulics and clutch release mechanism
-
‒ Attach operating cable to gearbox, adjust if necessary:
=> 5-Speed manual gearbox 006; Repair group 34; Servicing selector mechanism; Removing and installing operating cables
=> Running gear; Repair group 40; Servicing drive shafts; Removing and installing drive shafts
-
‒ Install pendulum support:
=> Running gear; Repair group 40; Servicing front wheel mounting; I - Assembly overview, assembly carrier, anti-roll bar, wishbone
Vehicles with air conditioner
-
‒ Installing air conditioner compressor:
=> Heating, Air conditioning; Repair group 87; removing and installing compressor bracket
Vehicles with automatic gearbox
-
‒ Install selector cable on gearbox, adjust if necessary:
=> Automatic gearbox 099; Repair group 37; Servicing selector mechanism
Continuation for all vehicles
-
‒ Install front exhaust pipe => Page , exhaust manifold, front exhaust pipe and catalyst with attachments.
-
‒ Fill with coolant => Page 19-12
-
‒ Adjusting throttle cable => Page 20-12
-
‒ Electrical connections and routing:
=> Current flow diagrams, Electrical fault finding and Fitting locations
-
‒ Match engine electronics control unit to immobilizer:
=> Repair group 24; Simos injection and ignition system; Matching engine electronics control unit to immobilizer.
-
‒ Interrogate fault memory:
=> Repair group 01; Self-diagnosis; Interrogating fault memory
|