Leon Mk1
ABS Mark 70 -ABS/ASR- (until week 22.08) |
1 - | ABS control unit -J104- |
q | Assembly location: in the hydraulic control unit, in the engine compartment, to the right |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Do not separate connector before successfully completing self-diagnosis. Switch ignition off before separating connector. |
q | Removing and installing → Chapter |
2 - | Hydraulic units for the ABS. -N55- |
q | Fitting location: in engine compartment (right-side) |
The hydraulic unit consists of the following components: |
q | ABS hydraulic pump -V64- |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Valve block (contains inlet and outlet valves). |
q | The ABS hydraulic pump -V64- must not be separated from the valve block. |
q | Removing and installing → Chapter |
3 - | Brake system indicator -K118- |
q | Location: in dash panel insert. |
q | Brake malfunction, handbrake |
q | If flashing, check the brake fluid level |
q | Function: → Chapter |
4 - | ABS warning lamp -K47- |
q | Location: in dash panel insert. |
q | Function: → Chapter |
5 - | Traction control system warning lamp -K86- |
q | Location: in dash panel insert. |
q | Function: → Chapter |
6 - | Brake pad warning lamp -K32- |
q | Location: in dash panel insert. |
q | Function: → Chapter |
7 - | Brake light switch -F- and brake pedal switch -F47- |
q | In vehicles prior to week 45/05 |
q | Location: on brake pedal |
q | Removing and installing → Chapter |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
8 - | Brake pedal position sender -G100- |
q | In vehicles after week 45/05 |
q | Location: on brake pump |
q | Removing and installing → Chapter |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
9 - | TCS and ESP button -E256- |
q | Location: in centre console. |
10 - | Diagnostic connection |
q | Installation area: cover in footwell on the driver side |
11 - | Revolution sensor for the front right hand wheel -G45 -/Revolution sensor for the front left hand wheel -G47 - |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Removing and installing → Chapter |
12 - | Wheel bearing housing |
13 - | Wheel hub with wheel bearing |
q | The ABS sensor ring is fitted in the wheel bearing |
14 - | Rear right speed sensor -G44 -/rear left speed sensor -G46- |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Removal and assembly (front-wheel drive) → Chapter |
q | Removal and assembly (four-wheel drive) → Chapter |
15 - | Rear axle body with axle journal |
16 - | Wheel hub with wheel bearing |
q | The ABS sensor ring is fitted in the wheel bearing |