Cressida L6-3.0L DOHC (7M-GE) (1989)
/Page-971002.png)
5.
Re-check wheel alignment settings and correct if necessary.
6.
Replace the Bridgestone tires with Dunlop tires (P/N 00232-15195-11) .
Caution:
When replacing Bridgestone tires with Dunlop tires, all five tires must be replaced.
For best tire/wheel balance results, align the red dot on the tire bead with the blue dot on the wheel.
7.
Test drive vehicle to verify that it does not pull to the right.
Desired Wheel Alignment Settings:
Left
Right
Total
Front Caster
7.3 Deg.
7.3 Deg.
-
Front Toe
.04 in.
.04 in.
.08 in.
Note:
Refer to Warranty Bulletin # 89-17 for applicable warranty claim submission instructions.
Warranty Bulletin
Date:
05/30/89 No:___________ Ref:____________
CRESSIDA VEHICLE ALIGNMENT
When performing the subject repair within the basic warranty, refer to Technical Service Bulletin Vol. 10, Steering, 001 for repair procedures. When
submitting a warranty claim, procedures outlined below should be followed:
^
For a wheel alignment and replacement of all tires, the claim should be set up as follows:
^
Claim Type: Regular (RG)
^
Operation Code: 431091
^
Labor: 2.5 hours
^
Original Part Number: 48670-22080 (strut)
^
Condition/Cause/Remedy: Describe repair referencing TSB Vol. 10, Steering, 001.
^
Sublet: Claim cost of replacement tires using "XX" sublet type code.
NOTE:
All 5 tires must be replaced.
^
If during the wheel alignment it is necessary to add a spacer in addition to the tire replacement, the claim should be set up as follows:
^
Claim Type: Regular (RG)
^
Operation Code: 431092
^
Labor: 3.4 hours
^
Original Part Number: 48670-22080 (strut)
^
Condition/Cause/Remedy: Describe repair referencing TSB Vol. 10, Steering, 001.
^
Replacement Part: 48670-39017 (spacer)
^
Sublet: Claim cost of replacement tires using "XX" sublet type code.
NOTE:
As per Toyota warranty policy, tire replacements will be free for the first 12 months/12,500 miles, whichever occurs first, or until 25% of
the original tread depth is worn off, and prorated thereafter. For additional information refer to the 1989 Toyota Warranty Policy and
Procedures Manual, page 5-20.
