Matrix FWD L4-2.4L (2AZ-FE) (2009)
(a) Install the radiator reserve tank sub-assembly with the 3 bolts.
Torque: 7.0 Nm (71 kgf-cm, 62 in-lbf)
5. INSTALL FRONT BUMPER ASSEMBLY
HINT: Refer to the instructions for Installation of the front bumper assembly See: Body and Frame/Bumper/Front Bumper/Service and
Repair/Installation.
6. INSTALL GENERATOR ASSEMBLY (for 2ZR-FE)
HINT: Refer to the instructions for Installation of the generator assembly See: Starting and Charging/Charging System/Alternator/Service
and Repair/Removal and Replacement/Installation.
7. INSTALL GENERATOR ASSEMBLY (for 2AZ-FE)
HINT: Refer to the instructions for Installation of the generator assembly See: Starting and Charging/Charging System/Alternator/Service
and Repair/Removal and Replacement/Installation.
8. INSTALL FRONT WHEEL RH
Torque: 103 Nm (1050 kgf-cm, 76 ft-lbf)
9. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
10. REMOVE CENTER COWL TOP VENTILATOR LOUVER See: Brake Fluid/Service and Repair
11. FILL UP BRAKE FLUID RESERVOIR See: Brake Fluid/Service and Repair
12. BLEED BRAKE MASTER CYLINDER See: Brake Bleeding/Service and Repair
13. BLEED BRAKE LINE See: Brake Fluid/Service and Repair
14. BLEED BRAKE ACTUATOR See: Brake Bleeding/Service and Repair
15. INSPECT BRAKE FLUID LEVEL See: Brake Fluid/Testing and Inspection
16. INSPECT FOR BRAKE FLUID LEAK
17. INSTALL CENTER COWL TOP VENTILATOR LOUVER See: Brake Fluid/Service and Repair
18. INSPECT ACTUATOR USING TECHSTREAM See: Testing and Inspection/Brake Actuator (w/ VSC)
19. PERFORM YAW RATE AND ACCELERATION SENSOR ZERO POINT CALIBRATION See: Antilock Brakes / Traction Control
Systems/Testing and Inspection/Programming and Relearning
20. CHECK FOR SENSOR SIGNAL See: Antilock Brakes / Traction Control Systems/Testing and Inspection/Initial Inspection and Diagnostic
Overview/Vehicle Stability Control System/Test Mode Procedure
21. PREPARATION FOR FOG LIGHT AIMING (w/ Fog Light) See: Lighting and Horns/Fog/Driving Lamp/Adjustments
22. INSPECT FOG LIGHT AIMING (w/ Fog Light) See: Lighting and Horns/Fog/Driving Lamp/Adjustments
23. ADJUST FOG LIGHT AIMING (w/ Fog Light) See: Lighting and Horns/Fog/Driving Lamp/Adjustments