RAV4 2WD L4-2.5L (2AR-FE) (2009)
Power Distribution Module: Service and Repair
Removal
OTHER SYSTEM: VOLTAGE INVERTER: REMOVAL
REMOVAL
1. REMOVE REAR DOOR SCUFF PLATE LH See: Body and Frame/Interior Moulding / Trim/Headliner/Service and Repair/Removal
2. REMOVE REAR DOOR OPENING TRIM WEATHERSTRIP LH
3. REMOVE REAR FLOOR NO. 1 BOARD (w/o Rear No. 2 Seat)
4. REMOVE DECK BOARD ASSEMBLY (w/o Rear No. 2 Seat)
5. REMOVE NO. 2 SEAT HINGE COVER LH (w/ Rear No. 2 Seat) See: Body and Frame/Seats/Service and Repair/Rear No. 2 Seat
Assembly/Removal
6. REMOVE NO. 2 SEAT HINGE COVER RH (w/ Rear No. 2 Seat)
HINT: Use the same procedures described for the LH side.
7. REMOVE NO. 2 SEAT LEG COVER LH (w/ Rear No. 2 Seat) See: Body and Frame/Seats/Service and Repair/Rear No. 2 Seat
Assembly/Removal
8. REMOVE NO. 2 SEAT LEG COVER RH (w/ Rear No. 2 Seat)
HINT: Use the same procedures described for the LH side.
9. REMOVE REAR NO. 2 SEAT ASSEMBLY LH (w/ Rear No. 2 Seat) See: Body and Frame/Seats/Service and Repair/Rear No. 2 Seat
Assembly/Removal
10. REMOVE REAR NO. 2 SEAT ASSEMBLY RH (w/ Rear No. 2 Seat)
HINT: Use the same procedures described for the LH side.
11. REMOVE REAR FLOOR NO. 3 BOARD
12. REMOVE REAR FLOOR NO. 2 BOARD
13. REMOVE REAR FLOOR NO. 1 MAT SUPPORT SIDE PLATE See: Body and Frame/Interior Moulding / Trim/Headliner/Service and
Repair/Removal
14. REMOVE REAR FLOOR FINISH PLATE See: Body and Frame/Interior Moulding / Trim/Headliner/Service and Repair/Removal
15. REMOVE TETHER ANCHOR BRACKET SUB-ASSEMBLY (w/o Rear No. 2 Seat) See: Body and Frame/Interior Moulding /
Trim/Headliner/Service and Repair/Removal
16. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH (w/o Rear No. 2 Seat) See: Body and Frame/Interior Moulding / Trim/Headliner/Service
and Repair/Removal
17. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH (w/ Rear No. 2 Seat) See: Body and Frame/Interior Moulding / Trim/Headliner/Service
and Repair/Removal
18. REMOVE INNER ROOF SIDE GARNISH ASSEMBLY LH (w/o Rear No. 2 Seat) See: Body and Frame/Interior Moulding /
Trim/Headliner/Service and Repair/Removal
19. REMOVE INNER ROOF SIDE GARNISH ASSEMBLY LH (w/ Rear No. 2 Seat) See: Body and Frame/Interior Moulding /
Trim/Headliner/Service and Repair/Removal
20. REMOVE VOLTAGE INVERTER ASSEMBLY
(a) Disconnect the connector.
(b) Remove the 2 bolts and voltage inverter assembly.