RAV4 2WD L4-2.5L (2AR-FE) (2009)
Air Bag Control Module: Service and Repair
Installation
SUPPLEMENTAL RESTRAINT SYSTEM: CENTER AIRBAG SENSOR ASSEMBLY: INSTALLATION
INSTALLATION
CAUTION: Be sure to read the precautionary notices concerning the SRS airbag system before servicing it See: Air Bag
Systems/Service Precautions.
1. INSTALL CENTER AIRBAG SENSOR ASSEMBLY
(a) Install the airbag sensor with the 3 bolts.
Torque: 17.5 Nm (179 kgf-cm, 13 ft-lbf)
NOTICE:
-
If the airbag sensor has been dropped, or there are any cracks, dents or other defects in the case, bracket or connector, replace it with a new
one.
-
When installing the airbag sensor, be careful that the SRS wiring does not interfere with other parts and that it is not pinched between other
parts.
(b) Connect the airbag sensor connectors.
2. INSTALL REAR CONSOLE BOX ASSEMBLY See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service and
Repair/Lower Instrument Panel/Installation
3. INSTALL NO. 1 INSTRUMENT PANEL BRACKET COVER INNER LH See: Body and Frame/Interior Moulding / Trim/Dashboard /
Instrument Panel/Service and Repair/Lower Instrument Panel/Installation
4. INSTALL NO. 1 INSTRUMENT PANEL BRACKET COVER INNER RH See: Body and Frame/Interior Moulding / Trim/Dashboard /
Instrument Panel/Service and Repair/Lower Instrument Panel/Installation
5. INSTALL CONSOLE REAR END PANEL See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service and
Repair/Lower Instrument Panel/Installation
6. INSTALL UPPER REAR CONSOLE PANEL SUB-ASSEMBLY See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument
Panel/Service and Repair/Lower Instrument Panel/Installation
7. INSTALL CONSOLE CUP HOLDER BOX See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service and
Repair/Lower Instrument Panel/Installation
8. INSTALL SWITCH BASE See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service and Repair/Lower Instrument
Panel/Installation
9. INSTALL UPPER CONSOLE PANEL SUB-ASSEMBLY See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service
and Repair/Lower Instrument Panel/Installation
10. INSTALL NO. 2 CONSOLE UPPER PANEL GARNISH See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service
and Repair/Lower Instrument Panel/Installation
11. INSTALL NO. 1 CONSOLE UPPER PANEL GARNISH See: Body and Frame/Interior Moulding / Trim/Dashboard / Instrument Panel/Service
and Repair/Lower Instrument Panel/Installation
12. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
13. CHECK SRS WARNING LIGHT
(a) Check the SRS warning light See: Air Bag Systems/Testing and Inspection/Symptom Related Diagnostic Procedures/Problem Symptoms
Table.