Sienna FWD V6-3.3L (3MZ-FE) (2006)
Sliding Door Latch: All Technical Service Bulletins
Body - Sliding Door(s) Rattle While Driving
T-SB-0094-10
March 16, 2010
Sliding Door Rattle While Driving
Service Category
Vehicle Exterior
Section
Door/Hatch
Market
USA
Applicability
TSB SUPERSESSION NOTICE
The information contained in this TSB supersedes TSB No. NV001-06.
^
Applicability has been updated to include 2007 - 2010 model year Sienna vehicles.
^
Repair Procedure 3 has been added for replacement of slide door male stoppers.
TSB No. NV001-06 is Obsolete and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before
proceeding.
Introduction
Some Sienna vehicles may exhibit a growling ticking clunking or rattling noise near or around the left and/or right-hand sliding door when driving on
rough road surfaces.
Noise generated by contact between the striker plate and lock assembly on 2004 - 2006 model year Sienna vehicles has been reduced by adding a resin
coating to the sliding door striker plate and sliding door lock assembly. The updated part applies to both manual and power sliding doors.
Noise generated by contact between the male and female slide door stoppers on 2004 - 2010 model year Sienna vehicles has been reduced by
redesigning the male stopper (foam type material was added to the male stopper). The updated part applies to both manual and power sliding doors.
Production Change Information Striker Plate:
Repair Procedure 1 applies to 2004 Sienna vehicles produced BEFORE the Production Change Effective VINs shown.
Lock Assembly: