Tacoma PreRunner Extra Cab 2WD V6-3.4L (5VZ-FE) (2000)
Required Materials
Warranty Information
Applicable Warranty*:
This repair is covered under the Toyota Basic Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the
vehicle's in-service date.
* Warranty application is limited to correction of a problem based upon a customer's specific complaint.
Repair Procedure
1.
Remove Wiper Arms, Plastic Cowl Cover and Wiper Motor (store wiper links up against bottom of windshield).
NOTE:
Mark wiper arm linkage attached to wiper motor and wiper motor splined shaft prior to removing the 12 mm retaining nut.
2.
Spray Acrysol(TM) under entire lip of 1/2" pinch weld and wipe dry with a clean paper towel.
FOLLOW DIRECTIONS ON SIDE OF CAN CAREFULLY.
Dry open seam with compressed air prior to applying sealer.
NOTE:
Do not use a red shop towel to wipe surfaces because shop towels are contaminated with silicone.
3.
Apply a small bead of Kent High Tech(TM) Clear Seam Sealer to underside front edge of the pinch weld from fender to fender as shown.