Field Remedy: 2013
Subject: |
Engine Y/Z13DT/H/J - Bad cold start
behavior at low ambient temperatures |
Models: |
Engines: |
Option: |
All 2004... |
Y13DT| Z13DT| Z13DTH| Z13DTJ |
|
Complaint: |
Bad cold start behavior at low ambient
temperatures. In some cases it takes up to 15 seconds to start the
engine / or several starting procedures. Sometimes a kind of
rattling noise is audible during start. |
Cause: |
Problem caused by too low starter
performance. Several investigations revealed that a starter is
needed which runs engine RPM much faster through the resonance band
of the dual mass flywheel. |
Production: |
As of the following VINs new part has been
introduced (for Z13DTH only) in production: - Eisenach:
W0L0SDL0876086701; - Zaragoza: W0L0SDL6874229466; - Ellesmere Port:
W0L0AHL4878073662; - Bochum: W0L0AHL4872134678; - Antwerp:
W0L0AHL0875125881. As of engineno.: 2428727 (12.12.2007) the new
starter has been introduced in produktion for Z13DT and Z13DTJ
. |
Remedy:
For Y13DTH and Z13DTH:
In case of customer complaint please refer to Customer Satisfaction
Programm 07-R-029 Corsa D, Astra H - Y/Z13DTH Starter.
For Y13DT, Z13DT and Z13DTJ:
In case of customer complaint advice customer to press clutch during
starting procedure in order to detach additional inertia weight. Make
sure that customer will follow the preheat phase and that always a
fully charged battery is installed. If starting behaviour cannot be
improved, install a modified starter (Part-No.: 93 192 995 /
Cat.-No.: 90 98 031).
FunctionalGroup: |
J - Engine |
Complaint Group: |
08 - Hard to operate |
Trouble Code: |
None |
|