volkswagen Workshop Repair Guides

Volkswagen Workshop Service and Repair Manuals

ABOUT US
Rear window wiper system > < Removing and installing windscreen washer reservoir

Polo Mk5

Removing and installing windscreen and rear window washer pumpV59
Removing and installing windscreen and rear window washer pump -V59-
  Note
Depending on equipment, the fitting location of the windscreen and rear window washer pump -V59- may differ slightly from the illustration. Removal procedure is analogue.
Removing:
–  Switch off ignition and all electrical consumers and remove ignition key.
–  Remove front right wheel housing liner → General body repairs, exterior; Rep. gr.66
  Note
The connections at the pump and hoses are colour-coded to prevent incorrect connection of the washer fluid lines to the windscreen and rear window washer pump -V59-. The hose fittings must be connected to the correct colour-coded pump connections during installation.
–  Disconnect connector -5-.
   
–  To release, pull up hose locks -6- and -8- at hose connections and disconnect these from windscreen and rear window washer pump -V59--7-.
–  Drain any escaping fluid in a suitable container.
–  Pull windscreen and rear window washer pump -V59--7- upwards out of reservoir.
Installing:
Install in the reverse order of removal. When doing this, note the following:
–  On completion of installation work, bleed headlight washer system → Chapter.
  N92-10475

Rear window wiper system > < Removing and installing windscreen washer reservoir