940 SE L4-2320cc 2.3L SOHC Turbo VIN 87 B230FT (1991)
G1
Preparations
-
Clean evaporator according to Service Manual:
Section 8(87)
Climate control
700/900 1982-
Section V
-
Make note of radio code if anti-theft coded radio installed.
Remove:
-
Negative battery lead.
-
Sound insulation on passenger side.
-
Glove compartment
-
Ashtray.
-
Cigarette lighter.
-
Storage compartment.
-
Detach, pull out and turn central electronics module.
Refer to Service Manual:
Section 3(35-39) (see group 37) Lighting, instrumentation and other electrical equipment 700/900 1982-
Section 8(82-86, 88) Interior, exterior 700/900 1982-
Cable connections
G2
Installing new relay on cable harness
-
Take out cable harness (P/N 9447729) supplied with kit.
-
Install relay supplied in the 5-pin connector.
G3
Route cables to engine compartment
-
Route cables without housing receptacles to engine compartment through unused cutout in grommet below suspension strut brace.
-
Install round housing receptacles supplied with cable harness on the cables in the engine compartment.
-
Separate existing connectors on the cable between the A/C compressor and the receiver/drier.