S60 2.5T AWD L5-2.5L Turbo VIN 59 B5254T2 (2004)
-
Remove the soundproofing panel (2) by removing the two screws (3) and then prizing down the rear edge until the three clips release.
Note! On right-hand drive cars the fuse holder is located on the right-hand side. The positive cable is then routed the same way as the ground
lead, and up from below along the A-pillar to the fuse holder.
-
Remove the fuse holder cover.
-
Remove the fuse holder (1) by prizing up the catch at the top and pulling outwards.
-
Route the amplifier's positive cable from the radio cut-out behind the dashboard to the fuse holder.
-
Route the cable down to the cable harness under the steering column. Clamp the cable and the cable harness with a tie strap.
-
Route the cable to the left along the floor lighting cable and clamp these with a tie strap.
-
Route the cable up to the fuse holder.
Applies to cars up to and including model year -2004 (S60 CH -424999, V70 CH -458999, XC70 CH -172999, S80 CH -389999)
-
Connect the cable to position 17 on the rear of the fuse holder.
Applies to cars from model year 2005- (S60 CH 425000-, V70 CH 459000-, XC70 CH 173000-, S80 CH 390000-)
-
Connect the cable to position 11 on the rear of the fuse holder.
Applies to all models
-
Reinstall the fuse holder.
Applies to cars up to and including model year -2004 (S60 CH -424999, V70 CH -458999, XC70 CH -172999, S80 CH -389999)
-
Install a 30A fuse in position 17.
Applies to cars from model year 2005- (S60 CH 425000-, V70 CH 459000-, XC70 CH 173000-, S80 CH 390000-)
-
Install a 30A fuse at position 11.
Applies to all models
-
Refit the fuse holder cover.
Connection and finishing work S60/V70/XC70
Applies to cars up to and including model year -2004 (S60 CH -424999, V70 CH -458999, XC70 CH -172999)
-
Take the radio to the radio compartment and connect the grey connector from the amplifier to the grey connector which was detached from the