S60 2.5T AWD L5-2.5L Turbo VIN 59 B5254T2 (2004)
-
Fold back the carpet.
-
Remove the clips on the lower edge of the folding panel (on both the right-hand and left-hand sides) by pressing in the centre of the clip until an
audible snap is heard.
-
Remove the clips.
-
Unscrew the front clips.
-
Turn the knob (1) on the right-hand and left-hand sides 90°.
-
Fold the panels inwards. Lift the panels out.
-
Remove the two covers (2) and the underlying screws (3).
-
First, pull the boot lid sill trim panel (4) forwards until the two clips on the right-hand and left-hand sides release. Pull forcefully but carefully
since the panel is fitted tightly. Pull the panel straight up until the four clips in the lower edge release.
-
Remove the wiring (5) for cargo compartment lighting.
-
Lift out the sill trim panel.
-
Remove the drain hose (1) from the battery.
-
Remove the rubber seal (2). It will not be re-used.
-
Pull off the small, thin rubber strap on the new rubber seal.
-
Insert the old drain hose through the new rubber seal. Make sure the hose is not obstructed and that it is not folded.