S80 T6 L6-2.9L Turbo VIN 91 B6294T (2002)
Fluid - A/T: Removal and Replacement
Transmission oil / oil filter, replacing
Special tools:
999 4090 EXTRACTOR See: Tools and Equipment/999 4090 Extractor
Warning! Avoid skin contact with the transmission fluid.
Note! Oil grade: Only ATF fluid Dexron III (with G-license). Transmission oil, Volvo P/N 116 1521-8 (1 liter container), 116 1621-6 (4 liter
container).
Conditions
Always replace the oil in the following instances:
Where diagnostic trouble codes (DTCs) TCM 0042 and TCM 0046 are stored, in which case the diagnostic function activates the warning lamp in the
following circumstances.
The transmission control module (TCM) receives data about the operating temperature of the transmission fluid while the car is being driven. TCM 0042
is stored after an accumulated amount of time.
Diagnostic trouble code (DTC) TCM 0046 is stored if the transmission fluid temperature exceeds 150° C for more than 2 minutes.
On cars used in continuous taxi service and / or used for towing a trailer or caravan for most of its mileage, the oil must be replaced at a service interval
of 75, 000 km ± 5000 km. This is to conform to the regular service program.
Warning! The oil may be very hot if the car has just been driven. Avoid skin contact.
Drain the oil
Suck up the oil through the dip stick pipe using an oil suction device. There is no drain plug.
Slacken off the nut on the return line for the oil pipe bracket a few turns
Remove the splash guard under the engine