volvo Workshop Repair Guides

Volvo Workshop Service and Repair Manuals

Electronic Throttle System - Troubleshooting|Page 11518 > < Data Link Connector|Locations|Page 11513
Page 1
background image

Electronic Throttle Actuator: Technical Service Bulletins
Electronic Throttle System - Troubleshooting

NO: 25-149-A

DATE: 07-07-2006

MODEL/YEAR: 
C70 1999-2002
S70 1999-2000
S60 2001 all engine variants, 2002 non-turbo only.
V70 1999-2001 all engine variants, 2002 non-turbo only.
V70XC, 1999-2000
XC70 2001
S80 1999-2001

SUBJECT: 
Troubleshooting Electronic Throttle System (ETS)

REFERENCE: VIDA

This Tech Net Note supersedes the previous TNN 25-149A dated 12-6-2005 and TNN 25-149A dated 04-03-06. Please update your files.

The two prior versions of this TNN offered background and fault tracing information for the Electronic Throttle System on the above vehicles. With the
release of VIDA version 2006B the background and fault tracing information has been integrated into VIDA.

New Fault Tracing

The fault tracing for ETS codes in VIDA has been enhanced to include more background information on Faults sub system and the criteria for detecting
a fault. Where applicable if there are differences between the original software's fault detection criteria and the new ETS software (March 2006 and later)
the differences are described in the fault code information.

Design and Function

The Design and function section of VIDA described as Throttle Diagnostic has been enhanced significantly and offers an excellent description of the
system and all of the involved components, including the interaction of and dependence between components for system function. This is worth reading
as a refresher on the functionality.

Potentiometer Tool

Some of the ETS DTCs (9150, 9160, 91A7) may indicate that the signal value from the throttle position sensors was incorrect. One possible source for
this fault is wear or aging of the potentiometers themselves. From VIDA 2006B, when following the fault tracing for these DTCs, the information
suggests testing the potentiometers if counter 4 is higher than 10. The tool can be accessed by clicking the VCT symbol from the fault tracing, or by
looking under the advanced tab for the ETM / Vehicle Communication. The tool will sweep the throttle potentiometers, closed-open-closed, four times
while displaying the difference in values between the potentiometers.

The tool will only work with the latest ETM software, so it will need to be downloaded before the potentiometers can be evaluated. Please read the text
in the test tool dialogue box carefully the first time to understand the ignition key and button combination needed to start the test. For VIDA 2006B, the
test box will always have the wrong message along the bottom telling you the software needs to be upgraded, even if it has already been upgraded. Ignore
this message. DTCs may need to be erased after the ETM has been allowed to re-set.

Combined Fault Code Matrix

As with the TNN, the fault tracing in VIDA now has links from the individual DTCs to a combined Fault Code Matrix, to enable root cause DTCs to be
determined. The following statement:

"Of the above diagnostic trouble codes (DTC's), only the Electronic throttle module (ETM) can be a possible cause for the following diagnostic trouble
codes (DTC's): 903F, 910E, 914F, 9150, 9160, 91A7, 91B7, 91F0."

was translated incorrectly and should be ignored, there are many possible root causes for these DTC's and the fault tracing should be followed.

Software Part Number Identification

In VIDA 2006B, guidance is given to identify the latest ETS software as a part of most of the fault tracing steps. However, due to the long lead times
involved in publishing the VIDA information, the part numbers used for the turbo and 6-cylinder non-turbo vehicles are incorrect. (See below.)

Electronic Throttle System - Troubleshooting|Page 11518 > < Data Link Connector|Locations|Page 11513