XC90 L5-2.5L Turbo VIN 59 B5254T2 (2004)
authorized Volvo workshop.
Is the car equipped with SRS/SIPS?
Cars with SRS are most easily recognized by the letters SRS on the steering wheel pad. If the car also has an airbag on the passenger side, the letters SRS
are embossed on the dashboard above the glove compartment. SIPS decals are located on the seat panels and the windscreen.
Do not damage the SRS wiring!
Do not trap, fray, pierce or damage the SRS wiring. SRS wiring has orange casing and/or is plaited.
Steering and front suspension
The contact reel in the SRS system can easily be damaged when working on the steering wheel, steering shaft or steering gear. Refer to the SRS service
information on carrying out such work. This is to prevent damage.
SRS warning lamp
If the SRS warning lamp lights after repairs have been carried out, take the car to an authorized Volvo workshop.
SRS collision sensor control module
S60 / V70 (00-) / S80
The collision sensor control module is located on the transmission tunnel in the centre console, beside the parking brake. The air bag inflation areas must
not be obstructed. Never place any objects, such as upholstery, within these areas. The panels must be able to open in the correct way and at the right
time.
WARNING!
The ignition must be in position "0" and the key removed from the ignition if any connector in the SRS system is to be disassembled. Then wait
at least five minutes. Then disconnect the battery negative lead before disassembling any of the connectors.
Tow hitch, fixed
Note! Kit contents:
1. Cross member
2. Screw M12x110 (x6)
3. Spacer washer, left-hand
4. Spacer washer, right-hand
5. Mounting pin (x2)
6. Protective cover for the towing ball.
Type approval of the tow hitch is in a table in the instructions.
Illustration A
Applies to cars with two rows of seats
-
Fold up the centre rear floor hatch (1) slightly
-
Remove it by pulling it off the mountings at the front edge
-
Remove the storage box underneath and lift it out. If the floor hatch has a carrier bag holder on the underneath, it is secured by a strap on each of
the shorter sides of the storage box. The straps must be undone.
