XC90 FWD L6-3.2L VIN 98 B6324S (2007)
Fit the lower bolt to the engine pad, M10, x1.
Installing the gearbox bolts to the lower torque rod
Fit the bolts, x2, in accordance with: Tightening torque, B8444S See: Engine, Cooling and Exhaust/Engine/Specifications/Mechanical
Specifications/Tightening Torque.
Installing the lower steering shaft joint
Install:
-
the lower steering shaft joint
-
the bolt, M8
-
the connector to the solenoid.
Installing the exhaust pipes between front and rear catalytic converters
Note! To ensure that there is no exhaust leakage, see: Flanged joint, assembling See: Engine, Cooling and Exhaust/Exhaust System/Exhaust
Pipe/Service and Repair/Flanged Joint, Assembling
Install:
-
both exhaust pipes
-
both exhaust pipes' nuts M8.
Installing the protective cover under the engine
Install:
-
the protective cover under the engine
-
the bolts, M8, x6.
Installing the protective plate
Move the protective plate up in the bumper cover. Press forward until the mounting brackets enter the subframe. Fit the bolts, M10.
Fitting the bolts to the right-hand engine pad
Fit the bolts, x2, in accordance with: Tightening torque, B8444S See: Engine, Cooling and Exhaust/Engine/Specifications/Mechanical
Specifications/Tightening Torque.
Installing the wing liner
Install:
-
the wing liner
-
the plastic nuts, x2.
Removing the lifting tool
Remove the lifting tool: 999 5716 Reading off tool See: Tools and Equipment/999 5716 Reading off Tool , the kit: 999 7070 Mounting See: Tools and
Equipment/999 7070 Mounting and lifting hooks: 999 5460 Lifting hook See: Tools and Equipment/999 5460 Lifting Hook.
Fitting the bolts to the torque rod
Fit the bolts, M10 x2, at the suspension turrets on both sides.
Filling the power steering fluid reservoir
Caution! Avoid skin contact with the oil.
Note! For the correct oil grade use Volvo power steering fluid, part number: 116 1529-1.
Fit the battery cable. Fill the power steering fluid reservoir.
Turn the steering wheel between both end positions several times.
Check and fill with oil as necessary.
Apply the parking brake.
Start the engine.
A: Turn the steering wheel slowly to the right, keep it at the end position for 2 seconds.