GV CABRIO L4-1300cc 1.3L SOHC VIN 5 2-bbl (1990)
Dear Yugo Dealer:
This is to inform you of Yugo's Voluntary Recall Campaign affecting 1990 and some 1991 Model Yugo GV Plus Vehicles.
Seventy-five percent of all the vehicles have been corrected, however; in the event an (intransit) customer wishes to verify that the recall has been
performed, check for a colored sticker attached to the Trim Panel below the passenger's side dashboard and/or contact the Warranty Office at
Refer to all Recall Documentation enclosed.
Warranty Mgr., Service Mgr., and Parts Mgr.
Yugo America, Inc.
Recall Claim Form Completion and Reimbursement Claim Number:
Properly complete the Recall Claim Form (see sample). Please make certain to print clearly, as illegible information will delay the processing time.
Incomplete forms will be returned to sender.
The form must be signed by both the vehicle owner and the authorized dealership represertative. For stock vehicles the service manager's signature
Mail the Recall Claim Form to Yugo America, Inc.'s Warranty Departmert in the self addressed / postage pre-paid envelope(s) (provided) once a
week. Yugo America, Inc. will reimburse your dealership at your approved warranty labor rate:
Labor time reimbursement = 0.8 hours.
Parts are supplied free of charge by Yugo America, Inc.'s Parts Department.
Do not enter recall claim(s) through your T.E.C. terminal.
Refer to your bimonthly credit memo for reimbursements.
September 3, 1991
Yugo America, Inc.
This notice is sent to you in accordance with the requirements of the National Traffic and Motor vehicle safety Act. Yugo America, Inc. has determined
that a defect which relates to motor vehicle safety exists in your 1990/1991 Yugo GV Plus.
The problem we have identified is poor sealing of the Electronic Control Unit (the vehicle's main computer which controls combustion and ignition
processes); at the vehicle firewall. Water contamination can cause the unit to fail, which would result in the vehicle stalling, and its failure to restart. A
stalled motor vehicle can present a significant traffic hazard, depending upon when and where it occurs.
Your Yugo dealer will repair this defect free of charge. Rubber sealing washers will be fitted between the Electrcnic Control Unit and the vehicle
firewall to prevent water ingress. The repair requires approximately one hour to complete. We recommend that you contact your Yugo dealer to set up an
appointment for this repair at your earliest possible convenience upon receipt of this notice. In the interim, until the vehicle is repaired at an authorized
Yugo service facility, we recommend that you avoid driving your Yugo GV Plus in heavy rain or through standing water, as these conditions are most
likely to result in the failure mode described above.
Should you have any questions or concerns regarding this recall that your Yugo dealer is unable to answer, please call Yugo America, Inc.'s Customer
Service Department at 1-800-USA YUGO.
You may also contact the National Highway Traffic Safety Administration to file a complaint should you believe that your dealer has failed to remedy
the defect, or has failed to remedy the defect within a reasonable time period (defined as within 60 days of your first attempt to have the vehicle
repaired), or fails to remedy the defect free of charge.