ford Workshop Repair Guides

Ford Workshop Service and Repair Manuals

ABOUT US
Low-Pressure Cutoff Switch > < Clutch and Clutch Field Coil

Transit.Tourneo Connect 2002.5 (06.2002-)

Air Conditioning - Suction Accumulator Transit/Tourneo Connect 2002.5 (06/2002-)
Removal and Installation

Special Tool(s)

Separator, refrigerant line 3/4" (white)

412-040 (34-002)
Materials
Name
Specification
O-rings
Green 

Removal

CAUTION:
CAUTION:Only renew the dehydrator if moisture has been allowed to enter the unopened system for a long period of time (two to three hours).
  1. Drain the air conditioning system.For additional information, refer to Section  412-00 Climate Control System - General Information.
  1. Raise the vehicle.For additional information, refer to Section  100-02 Jacking and Lifting.

  1. Remove the right-hand wheel arch trim panel (shown with the wheel removed for clarity).

  1. CAUTION:
    CAUTION:Close off the refrigerant lines and the dehydrator to prevent contamination.
    Remove the dehydrator.
    1. Disconnect the refrigerant line from the dehydrator using the special tool.
    1. Disconnect the refrigerant line from the dehydrator.
    1. Unscrew and remove the bolts and the nut on the dehydrator.

Installation

  1. NOTE:
    NOTE:Install new refrigerant line O-ring seals.
    NOTE:
    NOTE:Coat the O-rings for the refrigerant lines with clean refrigerant oil prior to installation.
    Refit the components in reverse order.

Low-Pressure Cutoff Switch > < Clutch and Clutch Field Coil