Z4 E85 2.0i Roadster (N46): 2 Repair Instructions
Also for this vehicle: Z Series E85 M roadst (S54) ROADST, Z Series E85 Z4 2.2i (M54) ROADST, Z Series E85 Z4 2.5i (M54) ROADST, Z Series E85 Z4 2.5i (N52) ROADST, Z Series E85 Z4 2.5Si (N52) ROADST, Z Series E85 Z4 3.0i (M54) ROADST, Z Series E85 Z4 3.0i (N52) ROADST, Z Series E85 Z4 3.0Si (N52) ROADST.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data86 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- BMW Service-inspection (petrol/gasoline Vehicles)2
- Notes On SMG Transmission Service Functions
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack
- Symbols Used And Information In Repair Instructions2
- Air Cleaner: Replacing Air Cleaner Element (shorten Replacement Interval Accordi
- Battery: Checking Display. If Necessary, Recharge Battery
- Battery: Checking Acid Level, Topping Up With Distilled Water If Necessary
- Body And Underbody: Checking For Corrosion And Damage
- Body And Underbody: Checking For Corrosion And Damage - Except Cavities
- Body: Check For Corrosion (except Cavities)
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Changing Brake Fluid
- Changing Engine Oil And Oil Filter
- Check Windscreen Wash/wipe System
- Checking Clutch Drive Plate For Wear
- Checking Coolant Level And Concentration, Correcting If Necessary
- Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Lighting System
- Checking Roadworthiness (test Drive)
- Coolant Hoses: Visual Inspection For Leaks
- Diagnostic Brief Test
- Diagnostic Brief Test
- Exhaust System: Checking Condition, Mounting And Inspecting For Leaks
- Front And Rear Brake Linings: Checking Lining Thickness With Measuring Gauge
- Fuel Lines, Fuel Tank And Fuel Hoses: Visual Inspection For Routing, Condition A
- Heating/air Conditioning: Replacing Microfilter/carbon Canister (shorten Replace
- Information/warning Labels23
- Locking Systems: Checking Status And Function, Oiling Or Greasing If Necessary
- Microencapsulated Screws
- Oil Change In Manual Transmission
- Oil Change In Rear Differential
- Output Shafts: Checking Gaiters For Leaks
- Power Steering/ride-height Control: Visual Inspection For Leaks, Checking Fluid
- Raising BMW Multi-trailer23
- Replacing Spark Plugs
- Resetting Service Interval Indicator According To Factory Specifications2
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Check Oil Level2
- Transmission (all Gears): Visual Inspection For Leaks
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Wash/wipe System: Checking Washer Fluid Reservoir And Spray Nozzle Ad
- Windscreen Washer System And Intensive Cleaning System: Checking Fluid Level, To
- Windscreen Washer System: Checking Fluid Level, Topping Up If Necessary
- Interrogating Fault Memories In Diagnosis System
- 62 N46)2
- Checking/topping Up Oil Level In Rear Differential
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Oil Change In Rear Differential Incl2
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (N46)233 pages
0 Engine, General16 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- 4 N46)2
- Checking Absolute Compression Of All Cylinders2
- Securing Engine In Installation Position (N46)2
- Removing And Installing/replacing Full-flow Oil Filter (N40/N42/N45/N46)2
- Engine Identification2345
12 Cylinder Head With Cover23 pages
- Removing And Installing/sealing Cylinder Head Cover (N42/N46)2345
- Removing And Installing/sealing Cylinder Head (N42)2345678
- Replacing Cylinder Head Gasket (N40/N42/N45/N46)
- Disassembling And Assembling Cylinder Head - Cylinder Head Removed (N40/N42/N4523
- Remachining A Valve Seat - Cylinder Head Disassembled (N40/N42/N45/N46)
- Checking A Valve Guide For Wear (N40/N42/N45/N46)
- Grinding Cylinder Head Lower Face (N42 / N46)2
- Leak-testing Cylinder Head (N40/N42/N45/N46)2
- 13 Oil Sump › Removing And Installing, Sealing Or Replacing Oil Sump (N40/N42/N45/N46)2
- 15 Crankcase Ventilation › Measuring Engine Internal Pressure (N40 / N42 / N45 / N45T / N45si / N46 / N46T
- 22 Flywheel › Removing And Installing Or Replacing Flywheel (N40/N42/N45/N46)2
- 23 Vibration Damper › Removing And Installing Or Replacing Vibration Damper (N40/N42/N45/N46)
- 24 Connecting Rod With Bearing › Replacing All Big-end Bearings (N40/N42/N45/N46)2
25 Piston With Rings And Pin9 pages
- 27 Balancing Shafts › Removing And Installing/replacing Balancing Shaft Housing With Balancing Shafts
28 V-ribbed Belt W.tens.-deflect.elemt3 pages
31 Camshaft64 pages
- Checking Camshaft Timing (N42/N46)234
- Removing And Installing/replacing Inlet Camshaft (N42/N46)234567891011121314151617
- Removing And Installing/replacing Exhaust Camshaft (N40 / N45)234567
- Removing And Installing/replacing Exhaust Camshaft (N42/N46)2345678910111213
- Replacing Timing Chain (N42/N46)2345678910111213
- Removing And Installing/replacing Chain Tensioning Piston (N40/N42/N45/N46)
- Adjusting Camshaft Timing (N42 / N46)23456
- Removing And Installing / Replacing Rocker Arms On Inlet Side (N42 / N46)23
33 Rocker Arm With Bearing Mount4 pages
37 Variable Valve Gear33 pages
- Removing And Installing / Replacing Rocker Arms On Inlet Side (N42 / N46)23
- Removing And Installing / Replacing Eccentric Shaft (N42 / N46)234567
- Removing And Installing/replacing Intermediate Levers (N42/N46)23456789101112131415161718
- Removing And Installing/replacing Positioning Motor For Eccentric Shaft (N42/N462
- Removing And Installing/replacing Eccentric Shaft Sensor (N42/N46)2
- Replacing Control Unit (Valvetronic)
- 40 Oil Supply › Checking Engine Oil Pressure (N40/N42/N45/N46)2
- 42 Oil Filter And Lines › Removing And Installing/replacing Full-flow Oil Filter (N40/N42/N45/N46)2
- 44 Oil Cooler › Removing And Installing/replacing Oil-water Heat Exchanger (N40/N42/N45/N46)2
- 51 Water Pump With Drive › Removing And Installing/replacing Water Pump (N40/N42/N45/N46)234
- 53 Thermostat And Connections › Removing And Installing/replacing Coolant Thermostat (N40/N42/N45/N46)2
- 61 Intake Manifold › Removing And Installing Intake Manifold (N42/N46)23
- 62 Exhaust Manifold › Removing And Installing, Sealing/replacing Exhaust Manifold (N40/N42/N45/N46)
- 66 Vacuum Pump › Removing And Installing/replacing Vacuum Pump (N42/N46)
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
12 Engine Electrical System (N46)50 pages
0 Troubleshooting8 pages
- 12 Ignition Wires, Spark Plugs › Replacing All Spark Plugs (N42, N40, N46, N45, N52, N52K, N51)
14 Electronic Switching Or Contr.units11 pages
- Replacing Control Unit (Valvetronic)
- Replacing Crankshaft Pulse Generator (N42, N40, N46, N45, N43)
- Replacing Inlet Camshaft Pulse Generator (N42, N40, N46, N45)
- Replacing Exhaust Camshaft Pulse Generator (N42, N40, N46, N45)
- Replacing Control Unit (DME)2
- Removing/replacing Knock Sensors (N40, N42, N43, N45, N46)
- Coding Control Module (DME / DDE)
- Programming Control Unit (DME / DDE)
- Replacing Fan For Electronics Box (N52)
- Removing And Installing/replacing Engine Compartment B- Terminal
32 Regulator6 pages
41 Starter With Mounting2 pages
- 51 Engine Wiring Loom › Replacing Wiring Harness Section For Ignition Coil (N46)2
61 Oil Pressure-oil Temperature-oil Gauge3 pages
90 Control Unit Box2 pages
13 Fuel System (N46)25 pages
- 0 Checking-setting Engine-emission › Function Check Of Digital Engine Electronics (DME)
31 Fuel Pump With Drive And Line4 pages
- 53 Injection Nozzle And Lines › Replacing Complete Injection Pipe (N46, N45)2
62 Sensor For Control Unit7 pages
- 64 Start Valves › Removing And Installing/replacing All Fuel Injectors (N42, N40, N46, N45)
- 71 Intake Silencer › Removing And Installing Intake Filter Housing (N46)
- 72 Air Cleaner › Replacing Air Cleaner Element
- 90 Carbon Canister Ventilation › Replacing Tank Venting Valve (N46 / N45: N46T)
16 Fuel Supply System (N46)30 pages
0 Fuel Pick-up, Cleaning System14 pages
- E85 Fuel Supply System (spark-ignition Engines)23
- General Function Description For Fuel Supply Systems
- Draining And Filling Fuel Tank2
- Checking Fuel Tank And Tank Venting System For Leaks (petrol/gasoline Without Ta23
- Checking Fuel Tank And Tank Venting System For Leaks With Tank Leakage Diagnosis2
- Conducting Leak Test On Fuel Tank And Tank Ventilation System2
- Conducting Leak Test On Fuel Tank And Tank Ventilation System
12 Fuel Transfer, Sensor For Gauge4 pages
- 13 Fuel Ventilation › Removing And Installing/replacing Tank Leakage Diagnosis Module
17 Cooling System (N46)24 pages
0 Coolant, Checking Cooling System13 pages
10 Radiator, Expansion Tank, Pipes3 pages
- 22 Oil Cooler Lines › Removing And Installing/replacing Heat Exchanger For Automatic Transmission2
- 18 Exhaust System (N46) › 0 Exhaust System, Complete › Removing And Installing Complete Exhaust System (N46)23
21 Clutch29 pages
- 0 Maintenance And Inspections › Bleeding Clutch Hydraulic System23
- 21 Clutch With Driving Disc › Removing And Installing/replacing Clutch (SAC 228 N45/N46/N45T/N43/N46T)2345678910111213
- 51 Clutch Release Controller W. Lever › Removing And Installing Or Replacing Clutch Release Bearing/lever2345
52 Clutch Operation (hydraulic)5 pages
- 90 Troubleshooting › Troubleshooting The Clutch23
22 Engine And Gearbox Suspension8 pages
31 Transmission Suspension, Manual Transmis2 pages
32 Transmission Suspension, Autom. Transmis2 pages
23 Manual Transmission (MECH)28 pages
0 Complete Transmission18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Overview Of Transmission Housing (GS6-17BG)
- Removing And Installing Transmission (GS6-17BG)2345
- Installing Replacement Transmission (GS6-17BG/DG)2
- 11 Housing With Cover › Replacing Guide Tube For Clutch Release Unit (GS6-17BG/DG)
- 42 Hydraulic Add-on Parts SMG › Replacing Clutch Actuator GS6S53BZ (SMG)2
25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission16 pages
- Overview Of Gearshift Mechanism For Manual Transmission
- Replacing U-gaiter
- Replacing Shift Arm (reinforced) For Shift Lever Mounting2
- Replacing Shift Rod
- Removing And Installing Shift Lever2
- Replacing Complete Shift Lever
- Replacing Bearing Shell For Shift Lever
- Replacing Knob For Shift Lever
- Replacing Gaiter (shift Lever Cover) For Shift Lever
- Replacing Shift Rod Joint
- Replacing Shift Arm For Shift-lever Mount2
- Replacing Bearing Bushes For Shift Arm
- Replacing Shift Arm Support Bearing
26 Propeller Shaft17 pages
- 0 Propeller Shaft, General › Propeller Shaft Deflection Angles
11 Propeller Shaft Assembly10 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle54 pages
0 General11 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle Overview
- Layout Of Spring Strut Shock Absorber
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads2
11 Front Sub-frame2 pages
21 Wheel Bearings And Stub Axle6 pages
31 Spring Strut11 pages
90 Troubleshooting3 pages
32 Steering And Wheel Alignment90 pages
0 Electronic Chassis Alignment33 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Overview Of Steering
- Chassis/wheel Alignment Check Procedure
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle2
- Troubleshooting After Wheel/chassis Alignment Check On Rear Axle2
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- KDS Chassis/wheel Alignment Check With Ride-height Measurement Without Load23
- Adjusting Toe-in And Camber On Front Axle23
- Adjusting Rear Axle
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
- 13 Steering Gear With Servo Unit › Information On Replacing Steering Gear After Accident Damage2
21 Steering Arms, Tie Rods, Steer. Damper6 pages
31 Steering Column20 pages
- Removing And Installing/replacing Upper Section Of Steering Column Trim2
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing / Replacing Lower Section Of Steering Spindle2
- Removing And Installing/replacing Steering Angle Sensor2
- Removing And Installing Steering Column234
- Replacing Steering Spindle Sleeve
- Removing And Installing/replacing Holder For Steering Spindle Sleeve
- Replacing Adjusting Lever For Steering Column2
- Replacing Complete Steering Lock2
- Replacing Steering Tube Bearing23
- 41 Pump And Oil Supply › Instructions For Removing And Installing Ear Clips2
- 90 Troubleshooting › Troubleshooting On Steering
33 Rear Axle117 pages
0 General18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Rear Axle Layout
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Overview Of Rear Differential/output Shafts
- Overview Of Rear Axle Carrier With Rubber Mounts
- Overview Of Control Arms With Rubber Mounts
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover17 pages
- Replacing Rear Cover Gasket On Rear Differential (168K)
- Replacing Rear Cover Gasket On Rear Differential (168L)
- Replacing Rear Cover Gasket On Rear Differential (188K)
- Replacing Rear Cover Gasket On Rear Differential (188L / 188LW)
- Replacing Shaft Seal For Input Flange On Final Drive2345
- Replacing Left Drive Flange On Rear Differential2
- Replacing Right Drive Flange On Rear Differential
- Replacing Shaft Seal For Left Drive Flange2
- Replacing Shaft Seal For Right Drive Flange
- Replacing Rear Cover Gasket On Rear Differential2
21 Output Shafts10 pages
32 Control Arms And Struts25 pages
- Overview Of Control Arms With Rubber Mounts
- Replacing Bearing Block For Front Trailing Arm2
- Removing And Installing Complete Left Or Right Trailing Arm2
- Replacing Left Or Right Trailing Arm
- Replacing A Rubber Mount In Trailing Arm, Front2
- Replacing One Rubber Mount/ball Joint In Trailing Arm For Lower Control Arm2
- Removing And Installing/replacing Top Left Control Arm2
- Removing And Installing / Replacing Top Right Control Arm2
- Removing And Installing/replacing Bottom Left Control Arm23
- Removing And Installing/replacing Bottom Right Control Arm2
- Removing And Installing / Replacing Compression Strut For Rear Axle Carrier
- Replacing One Ball Joint In The Semi-trailing Arm (semi-trailing Arm Removed)2
- Replacing One Rubber Mount In The Upper Control Arm (control Arm Removed)
- Replacing One Rubber Mount In Lower Control Arm (control Arm Removed)
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
53 Springs With Suspension4 pages
90 Troubleshooting3 pages
34 Brakes78 pages
0 Brake Testing And Bleeding11 pages
11 Front Brakes13 pages
- Overview Of Front Brakes
- Removing And Installing/replacing Brake Linings Of Both Front Disc Brakes234
- Removing And Installing Or Replacing Both Front Brake Discs2
- Removing And Installing / Replacing A Brake Carrier / Brake Guard Plate At Front
- Removing And Installing/replacing Left Or Right Front Brake Caliper2
- Overhauling Left Or Right Front Brake Caliper (brake Caliper Removed)2
- Precision-turning Both Front Brake Discs On Both Sides
21 Rear Brakes13 pages
- Overview Of Rear Brake
- Replacing Rear Left Or Right Brake Anchor Plate
- Removing And Installing/replacing Both Rear Disc Brakes234
- Removing And Installing/replacing Both Brake Discs
- Removing And Installing/replacing Left Or Right Rear Brake Caliper2
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)23
- Precision-turning Both Rear Brake Discs On Both Sides
- 35 Electrical Components - Wear Indicator › Replacing A Brake Pad Sensor (front)
41 Parking Brake13 pages
- General Information On Braking In New Brake Discs / Brake Pads
- Adjusting Handbrake234
- Overview Of Parking Brake
- Removing And Installing/replacing Handbrake Lever With Mounting Pan23
- Removing And Installing/replacing Both Handbrake Bowden Cables
- Removing And Installing/replacing All Handbrake Shoes2
- Removing And Installing/replacing Expander Lock For Handbrake Shoes
- 51 Mechanical-hydraulic Components › Removing And Installing/replacing DSC Hydraulic Unit2
52 Electronic Components10 pages
- Overview Of Electronic Components
- Removing And Installing/replacing Control Unit For DSC2
- Replacing One Front Pulse Generator
- Replacing A Rear Pulse Generator2
- Removing And Installing/replacing DSC III Yaw Sensor (DSC Sensor)2
- Removing And Installing/replacing Pressure Sensor /H: For DSC
- Removing And Installing/replacing Pressure Sensor /V: For DSC
- 90 Troubleshooting › Troubleshooting Brake System234
35 Pedals5 pages
- 11 Pedal Mounting Block › Removing And Installing Mounting Block For Pedals
- 21 Brake Pedal With Linkage › Removing And Installing/replacing Brake Pedal2
- 31 Clutch Pedal With Linkage › Removing And Installing / Replacing Clutch Pedal
- 40 Accelerator Pedal Actuation › Removing And Installing Or Replacing Accelerator Pedal Module
36 Wheels With Tyres26 pages
37 Integrated Suspension Systems5 pages
14 Electrical Components2 pages
41 Body (ROADST)123 pages
0 Body61 pages
- Contents Of Body, General2
- Bonding Plastic Parts
- Bonding Steel Parts2
- Corrosion Protection2
- Frame Alignment Control Dimensions, Body23
- General Cementing Instructions
- Grinding Aluminum Parts
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Notes On Repairing Threads
- Opening Adhesive Bonds
- Opening Weld Joints
- Position Of Shaped Parts For Cavity Acoustic Baffle
- Quality Standard
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Stamping Vehicle Identification Number2
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Workshop Equipment2
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
11 Support Members17 pages
- Replacing Front Left Or Right Engine Bracket With Wheel Arch2
- Replacing Left Engine Carrier (partial Replacement Before Front Axle)
- Replacing Front Left Engine Carrier (without Wheel Arch) (partial Replacement Be2
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Cover For Left Or Right Frame Side Member (side Panel Removed At Front23
- Replacing Front Left Or Right Support Carrier
- Replacing Front Luggage Compartment Floor Cross-member (luggage Compartment Floo2
- Replacing Complete Rear Tension Strut Mounting (luggage Compartment Floor And Ta2
- Replacing Door Pillar Inner Part (door Pillar Removed)2
14 Wheel Wells9 pages
- Stamping Vehicle Identification Number2
- Vehicle Identification Number, General
- Replacing Front Left Or Right Support Carrier
- Replacing Front Left Or Right Wheel Arch
- Replacing Rear Left Outer Wheel Arch Section (rear Left Side Panel Removed)
- Replacing Complete Rear Left Wheel Arch (rear Left Side Panel Removed)2
- Replacing Left B-pillar (rear Left Side Panel Removed)
21 Side Frame And Door Pillars10 pages
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Cover For Left Or Right Frame Side Member (side Panel Removed At Front23
- Removing And Installing Bottom Rear Window Frame Cover
- Replacing Door Pillar Inner Part (door Pillar Removed)2
- Replacing Left B-pillar (rear Left Side Panel Removed)
- Replacing Front Left Or Right Door Pillar (front Side Panel Removed)
- 33 Front Trim Panel › Replacing Front Wall
- 34 Rear Trim Panel › Replace Tail Panel
51 Front Side Doors4 pages
63 Other Flaps2 pages
51 Body Equipment (ROADST)238 pages
0 General9 pages
- Notes On Bonding/attaching Components With Double-sided Adhesive Tape
- Notes On Fitting Window Guide Seals2
- Safety Instructions For Working On Cars With Airbag Systems
- Service Position Of Engine Hood/bonnet2
- Overview Of Front Bumper
- Survey Of Rear Bumper
- Overview Of Storage Compartments And Side Trim Panels
11 Front Bumper12 pages
- Overview Of Front Bumper
- Removing And Installing/replacing Cover For Headlight Washer System On Left
- Removing And Installing / Replacing Carrier For Front Bumper Trim
- Removing And Installing Front Bumper Trim2
- Replacing Front Bumper Trim2
- Replacing Baseplate For License Plate
- Removing And Installing / Replacing Trim Grille In Bumper Trim
- Replacing Left Or Right Bracket For Front Bumper
- Removing And Installing/replacing Left Or Right Deformation Element For Front Bu2
12 Rear Bumper11 pages
- Survey Of Rear Bumper
- Removing And Installing / Replacing Carrier For Rear Bumper Trim
- Removing And Installing/replacing Carrier For Rear Bumper Trim (US Version)
- Removing And Installing Rear Bumper Trim2
- Replacing Rear Bumper Trim2
- Removing And Installing/replacing License Plate Holder
- Replacing An Impact Absorber For Rear Bumper (US Version)
- Replacing Bracket For Rear Bumper At Left Or Right
- Removing And Installing/replacing Guide For Rear Centre Bumper
13 Trim, Covers, Handle Trim14 pages
- Replacing Front Radiator Grill, Middle Left Or Right2
- Removing And Installing/replacing Front Radiator Grille, Middle Left Or Right
- Removing And Installing/replacing Trim On Front Left Or Right Side Panel
- Removing And Installing / Replacing Cowl Panel Cover2
- Replacing Trim Strip On Left Or Right Roof Gutter
- Removing And Installing/replacing Frame On Left Or Right Rear Light2
- Removing And Installing/replacing Trim On Left Or Right Rear Light
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Cowl Panel Seal2
14 BMW Emblems, Model Emblems7 pages
- Instructions For Attaching Number/letter Designation Combination
- Replacing Front BMW Badge (removing And Replacing)
- Replacing BMW Badge On Side Direction Indicator2
- Replacing (removing And Installing) Number/letter Combination On Front Left Or R
- Removing And Installing/replacing Rear BMW Badge
- Removing And Installing/replacing Rear Model Designation
16 Mirrors-covers-ashtrays-shelves-trays50 pages
- Overview Of Storage Compartments And Side Trim Panels
- Cementing Of Mirror Base2
- Removing And Installing Cover On Panel For Rear Storage Box
- Removing And Installing/replacing Centre Cover On Instrument Panel
- Removing And Installing/replacing Handbrake Lever Cover2
- Replacing Finisher On Left Instrument Panel Trim
- Removing And Installing/replacing Mirror On Left Or Right Front Door
- Replacing Mirror Glass
- Replacing Left Or Right Door Mirror Housing2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with Japanese Toll M23
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
- Removing And Installing/replacing Storage Compartment2
- Removing And Installing/replacing Front Cup Holder
- Removing And Installing/replacing Trim For Preselector Lever (gearshift Lever)
- Removing And Installing/replacing Trim For Storage Compartment
- Replacing Finisher On Right Instrument Panel Trim2
- Removing And Installing Panel For Rear Storage Box2
- Removing And Installing/replacing Lid On Rear Storage Box2
- Removing And Installing/replacing Rear Storage Box2
- Removing And Installing/replacing Lock On Rear Storage Box
- Removing And Installing/replacing Lock Fastener For Right Glovebox (with Active2
- Removing And Installing/replacing Lock Fastener For Right Glovebox (without Acti
- Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
- Removing And Installing Right Glovebox (with Active Knee Protection)
- Replacing Right Glovebox (with Active Knee Protection)
- Replacing Right Glovebox (without Active Knee Protection)
- Removing And Installing Right Glovebox With Housing (without Active Knee Protect
- Removing And Installing Right Glovebox With Housing (with Active Knee Protection2
- Removing And Installing/replacing Damper For Glovebox
- 20 Lock Cylinders, Assembly › Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
21 Front Door Locks, Handles, Fittings19 pages
- Replacing Door Detent (lock Striker), Front Left Or Right
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock In Left Or Right Front Door2
- Removing And Installing/replacing Complete Lock Cylinder In Left Or Right Front2
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Outside Handle And Lock Actuation Of Left Or R23
- Removing And Installing Or Replacing Inside Door Opener In Left Or Right Front D2
- Removing And Installing/replacing Bowden Cable For Inside Door Opener On Left Or
- Removing And Installing Or Replacing Door Brake On Left Or Right Front Door2
- Removing And Installing/replacing Window Cavity Cover Strip On Front Door2
23 Hood Latch, Locks10 pages
- Adjusting/replacing Bump Stops2
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Right Engine Hood/bonnet Lock
- Removing And Installing/replacing Left Hood/bonnet Lock
- Adjusing/replacing Striker On Hood/bonnet
- Adjusting Left Or Right Striker On Engine Hood
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Cable For Front Hood/bonnet Locks (in Engine C
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
24 Trunk Latch, Locks9 pages
- Adjusting Rear Lid Lock (lower Section Of Rear Lid Lock)23
- Removing And Installing/replacing Lock Element (lock Cylinder) For Rear Lid2
- Removing And Installing/replacing Rear Lid Lock (upper Section)
- Removing And Installing/replacing Striker For Rear Lid Lock
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
- Replacing Rubber Mount On Rear Lid Lid Support
31 Front And Rear Window17 pages
41 Front Door Trim Panel With Arm Rest11 pages
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing Left Or Right Front Door Trim Panel23
- Replacing Front Left Or Right Door Trim Panel2
- Removing And Installing/replacing Cover On Door Handle, Front Left Or Right
- Removing And Installing/replacing Door Handle On Door Trim Panel, Front Left Or
- Removing And Installing/replacing Sound Insulation In Front Door, Left Or Right23
43 Side Covering With Armrests10 pages
- Removing And Installing/replacing Trim Behind Rollover Bar On Left Or Right
- Removing And Installing/replacing Rear Left Or Right Upper Side Trim Section2
- Removing And Installing/replacing Rear Left Or Right Lower Side Trim Section
- Removing And Installing/replacing Cover On Front Left Or Right Rollover Protecti
- Removing And Installing/replacing Cover On Rear Left Or Right Rollover Protectio
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing/replacing Deflector For Roofliner
- Removing And Installing/replacing Panel For Roof Pillar At Front (A-pillar), Lef
- 44 Roof Trim Panel › Replacing Trim For Front Roofliner
45 Instrument Cluster Trim Panel10 pages
- 46 Parcel Shelf Trim Pan.-roller Sun Blind › Removing And Installing/replacing Top Trim On Rear Apron
47 Floor-lugg.comp.-eng.comp.tr.panels9 pages
- Removing And Installing/replacing Deflector For Roofliner
- Removing And Installing/replacing Front (inside) Left Or Right Entrance Cover St
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Replacing Front Trim For Luggage Compartment Floor
- Removing And Installing / Replacing Panel For Luggage Compartment Partition
- Removing And Installing / Replacing Left Luggage Compartment Wheel Arch Trim
- Removing And Installing / Replacing Right Luggage Compartment Wheel Arch Trim
- Removing And Installing / Replacing Front Underbody Protection
- 48 Front Lid Insulation Lining › Removing And Installing/replacing Sound Insulation In Front Door, Left Or Right23
- 49 Rear Lid Trim Panel › Removing And Installing/replacing Recessed Handle/lock Cylinder Trim On Rear Lid
71 Gaskets-seals, Loose Body Components14 pages
- Removing And Installing / Replacing Cowl Panel Cover2
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Splash Guard
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Cowl Panel Seal2
- Removing And Installing/replacing Tension Strut On Left Or Right Spring Strut Do
- Removing And Installing/replacing Reinforcement Plate On Front Axle Support2
- Removing And Installing/replacing Reinforcement Plate On Rear Axle2
- Removing And Installing Or Replacing Panel For Cover On Left Or Right Side Membe
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
52 Seats94 pages
13 Front Seat, Normal, Manual26 pages
- Overview Of Front Seat (normal/manual)
- Removing And Installing/replacing Guide For Front Left Or Right Head Restraint
- Removing And Installing/replacing Strip (trim) Of Left Or Right Belt Guide
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Actuating Unit On Left Or Right Front Seat234
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/manual)
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat2
- Removing And Installing/replacing Seat Angle Adjuster (normal/manual) On Left Or2
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Headrest
- Replacing Cover For Left Or Right Front Seat234
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Support For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
14 Front Seat, Normal, Electric26 pages
- Removing And Installing/replacing Guide For Front Left Or Right Head Restraint
- Removing And Installing/replacing Strip (trim) Of Left Or Right Belt Guide
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Headrest
- Replacing Cover For Left Or Right Front Seat234
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Support For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
- Additional Work In Event Of Faulty Drive/gearing For Longitudinal Seat Adjustmen2
- Overview Of Front Seat (normal/electric)
- Removing And Installing/replacing Carrier For Outer Cover On Left Or Right Front
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/electric)
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing/replacing Seat Angle Adjuster On Left Or Right Front Sea2
15 Front Seat, Sports, Manual21 pages
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/manual)
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Actuating Unit On Front Left Or Right Seat (sp
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (sport2
- Removing And Installing/replacing Seat Angle Adjuster (sport/manual) On Left Or2
- Removing And Installing/replacing Belt Guide On Left Or Right Backrest
- Removing And Installing Backrest On Left Or Right Front Door
- Replacing Backrest On Left Or Right Front Seat
- Replacing Cover For Left Or Right Front Seat2345
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Padding For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
16 Front Seat, Sports, Electric21 pages
- Replacing Seat Pan And Flexmat On Left Or Right Front Seat2
- Removing And Installing/replacing Left Or Right Seat Mechanism (normal/electric)
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing Left Or Right Front Seat
- Removing And Installing/replacing Belt Guide On Left Or Right Backrest
- Removing And Installing Backrest On Left Or Right Front Door
- Replacing Backrest On Left Or Right Front Seat
- Replacing Cover For Left Or Right Front Seat2345
- Replacing Backrest Cover For Left Or Right Front Seat2
- Replacing Padding For Left Or Right Front Seat
- Replacing Padding For Left Or Right Front Seat Backrest
- Removing And Installing/replacing Seat Angle Adjuster On Left Or Right Front Sea2
54 Slide-tilt Sunroof And Convertible Top (ROADST)110 pages
- 10 Sunroof › Repair Instructions For Bonded Seals23
- 21 Hardtop › Removing And Installing/replacing Hard Top Mounting
31 Convertible Top Linkage-operation47 pages
- Overview Of Convertible Top
- Overview Of Convertible Top And Add-on Parts
- Overview Of Mechanical Convertible Top Catch
- Overview Of Variable Convertible Top Compartment
- Adjusting Convertible Top
- Replacing Convertible Top Frame
- Removing And Installing/replacing Main Mount For Convertible Top2
- Removing And Installing Or Replacing Handle For Convertible Top Cover Lock
- Removing And Installing/replacing Gas Spring Strut On Convertible Top (mechanica
- Removing And Installing/replacing Left Or Right Convertible Top Catch (mechanica
- Removing And Installing Or Replacing The Base Plate On Left Or Right
- Removing And Installing/replacing One Funnel
- Removing And Installing/replacing Convertible Top Catch Turn Cross
- Replacing Cover
- Removing And Installing/replacing Tension Belts2
- Removing And Installing/replacing All Window Guides On Right And Left Of Convert
- Replacing Convertible Top Strip2
- Replacing Convertible Top Lock (stowage Lock)
- Removing And Installing/replacing Convertible Top Compartment Floor2
- Removing And Installing/replacing Damper For Variable Convertible Top Compartmen
- Removing And Installing/replacing A Mounting For Convertible Top Compartment Flo
- Removing And Installing/replacing Center Mount For Convertible Top Compartment F
- Replacing Convertible Top Center Lock (mechanical)
- Removing And Installing/replacing Hard Top Mounting
- Opening/closing Convertible Top In Event Of A Technical Fault23
- Removing And Installing/replacing Left Or Right Wind Deflector
- Replacing Convertible Top Fabric2345
- Removing And Installing/replacing Trim On Convertible Top Lock2
- Removing And Installing Or Replacing Headlining In Convertible Top2
- Removing And Installing/replacing Left Convertible Top Catch (automatic)
- Removing And Installing/replacing Right Convertible Top Catch (automatic)
- Removing And Installing/replacing Tension Cable
- Replacing Both Rubber Straps23
34 Motor-operated Convertible Top59 pages
- Overview Of Convertible Top
- Overview Of Convertible Top And Add-on Parts
- Adjusting Convertible Top
- Replacing Cover
- Removing And Installing/replacing Tension Belts2
- Removing And Installing/replacing All Window Guides On Right And Left Of Convert
- Replacing Convertible Top Strip2
- Replacing Convertible Top Lock (stowage Lock)
- Removing And Installing/replacing Convertible Top Compartment Floor2
- Removing And Installing/replacing Damper For Variable Convertible Top Compartmen
- Removing And Installing/replacing A Mounting For Convertible Top Compartment Flo
- Removing And Installing/replacing Center Mount For Convertible Top Compartment F
- Mounting Of Hydraulic Components2
- Opening/closing Convertible Top In Event Of A Technical Fault23
- Overview Of Automatic Convertible Top Catch
- Overview Of Hydraulic System For Convertible Top
- Removing And Installing/replacing Left Or Right Wind Deflector
- Repair Instructions For Hydraulic System Of Convertible Top And Convertible Top23
- Topping Up/extracting Fluid, Checking Fluid Level
- Removing And Installing/replacing Hydraulic Unit For Convertible Top Drive23
- Removing And Installing/replacing Hydraulic Cylinder For Convertible Top2
- Replacing Bowden Cable For EH Convertible Top Emergency Release Mechanism
- Removing And Installing Complete Convertible Top234
- Replacing Convertible Top Fabric2345
- Removing And Installing/replacing Trim On Convertible Top Lock2
- Removing And Installing Or Replacing Headlining In Convertible Top2
- Removing And Installing/replacing Left Convertible Top Catch (automatic)
- Removing And Installing/replacing Right Convertible Top Catch (automatic)
- Removing And Installing/replacing All Hydraulic Lines On Convertible Top2
- Removing And Installing/replacing Tension Cable
- Replacing Both Rubber Straps23
- Removing And Installing/replacing Complete Hydraulic Unit234
- Troubleshooting, Automatic Convertible Top
61 General Electrical System182 pages
0 Troubleshooting14 pages
- Instructions On Starting Aid
- Battery
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
12 Auxiliary Cable19 pages
- Replacing Battery Positive Lead
- Replacing Battery Positive Lead (from Luggage Compartment Connector To Engine Bu234
- Replacing Battery Negative Lead
- Replacing Wiring Harness For Rear Bumper
- Replacing Left Wiring Harness For Fully Automatic EH Convertible Top2
- Replacing Wiring Harness For Heated Rear Window
- Replacing Wiring Harness In Left Or Right Front Door
- Replacing Wiring Harness For Electrically Adjustable Front Seat
- Replacing Cable For Left Or Right Belt Buckle Tensioner
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
13 Plug Connection, Terminal, Fuse Box50 pages
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
- Replacing Fuse Box For Distribution Box2
- 14 Distribution Box, Power Support Points › Removing And Installing/replacing Engine Compartment B- Terminal
20 Battery18 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- Disconnecting And Connecting Battery Negative Lead2
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
21 Battery-vapour Separator3 pages
31 Switch39 pages
- Overview Of Switches
- Overview Of Switches In Instrument Panel/driver's Footwell
- Overview Of Switches On Center Console Or Panel For Storage Box At Rear
- Removing And Installing/replacing Fixture For Steering Column Stalk
- Removing And Installing/replacing Turn Indicator/headlight Dipping Switch
- Removing And Installing/replacing Cruise Control Switch
- Removing And Installing/replacing Ignition Starter Switch
- Removing And Installing/replacing Light Switch Unit
- Removing And Installing/replacing Switch For Windscreen Wipers
- Removing And Installing/replacing Shift Paddles For SMG Transmission
- Removing And Installing/replacing Switch Unit In Center Console
- Removing And Installing/replacing Switch For Passenger Airbag Deactivation
- Removing And Installing/replacing Indicator For Front Passenger Airbag Deactivat
- Removing And Installing/replacing Switch For Hazard Warning Flashers/central Loc
- Removing And Installing/replacing Switch For Unlocking Rear Lid
- Removing And Installing/replacing Both Shift Paddles For Automatic Transmission2
- Replacing Rocker Switch For Side Window Operation (driver's Side)
- Replacing Rocker Switch For Side Window Operation (passenger Side)
- Removing And Installing/replacing Emergency Call Button
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Multifunction Steering Wheel Switch
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror (from 04/2006)
- Replacing Switch For Door Mirror (up To 04/2006)
- Replacing Switch For Reversing Light
- Removing And Installing/replacing Driving Dynamics Switch
- Removing And Installing/replacing Clutch Switch Module
- Replacing Brake-light Switch
- Removing Switch For Glovebox Light
- Removing And Installing/replacing Microswitch For Storage Box Lighting2
- Replacing Level Switch For Coolant
- Removing And Installing/replacing Temperature Switch For Heated Windshield Spray
- Replacing Level Switch For Windshield Washer System
- Removing And Installing/replacing Sensor On Left Convertible Top Catch
- Removing And Installing/replacing Microswitch -convertible Top Compartment-
- Replacing Both Sensors On Left Convertible Top Main Bearing
- Carrying Out Steering Angle Sensor Adjustment
35 ECUs, Modules13 pages
- Overview Of Control Units, Modules
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing/replacing Module For Folding Door Mirror
- Removing And Installing/replacing Convertible Top Module2
- Removing And Installing (replacing) Rain/light Sensor
- Removing And Installing/replacing General Module
- Initializing Rain/light Sensor
- Removing And Installing/replacing Ring Antenna Of Electronic Immobilizer
- Removing And Installing/replacing Control Unit Of Electronic Immobilizer
- Vehicle Programming And Coding
36 Relays2 pages
61 Windscreen Wipers10 pages
- Adjusting Left Or Right Windscreen Wiper23
- Overview Of Windshield Washer System And Headlight Cleaning System (SRA)
- Checking/adjusting Contact Angle Of Windscreen Wiper Arms On Windscreen2
- Replacing Both Windscreen Wiper Blades
- Removing And Installing/replacing Both Windshield Wiper Arms2
- Removing And Installing/replacing Bracket For Windscreen Wiper System Complete W
67 Headlight Washer System4 pages
- 62 Instruments › 11 Instrument Cluster › Removing And Installing (replacing) Instrument Cluster
63 Lights59 pages
12 Headlights12 pages
- Overview Of Headlight
- Removing And Installing/replacing Left Headlight
- Removing And Installing/replacing Right Headlight
- Removing And Installing/replacing Left Headlight (xenon Headlight)
- Removing And Installing Right Headlight (xenon Headlight)
- Replacing Control Unit For Left Xenon Headlight
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight
- Replacing Right Ignition Unit For Right Xenon Headlight
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster (xenon He2
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster (xenon H
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Front Left Or Right Auxiliary Turn Signal Lamp
14 Clearance And Side Marker Lamps2 pages
- 17 Fog Lights, Auxiliary Lights › Removing And Installing (replacing) Left Or Right Front Fog Lamp2
- 25 Brake Lights › Removing And Installing/replacing Additional Stop Light
- 26 Licence Plate Lights › Removing And Installing/replacing Left Or Right Number/license Plate Light
31 Interior Lights6 pages
99 Light Bulbs25 pages
- Overview Of Bulbs
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For Left (or Right) High-beam Headlight2
- Replacing Halogen Bulb For Left (or Right) Headlight2
- Replacing Bulb For Left (or Right) Xenon Headlight2
- Replacing Bulb For Front Left (or Right) Side Lights2
- Replacing Bulb For Front Left (or Right) Side Lights (xenon Headlight)2
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp
- Replacing Bulb For Left (or Right) Front Turn Indicator2
- Replacing Bulb For Auxiliary Turn Signal Light, Front Left Or Right
- Replacing Light Bulb(s) For Left Or Right Rear Light2
- Replacing Bulb For Left Or Right License Plate Light
- Replacing Bulb For Front Ceiling Light
- Replacing Light Bulb For Footwell Light
- Replacing Light Bulb For Luggage Compartment Lighting
- Replacing Bulb For Glovebox Light
- Replacing Bulb For Storage Box Light
64 Heating And Air Conditioning83 pages
- 0 General › Overview Of Heater - A/C System Components
11 Heater With Operation22 pages
- Overview Of Heater - A/C System Components
- Overview Of Heater/air Conditioner Components
- Installing Servodrive
- Removing And Installing/replacing Trims On Control Panel For Heater - A/C System
- Removing And Installing Or Replacing Heater23
- Replacing Heater Core
- Removing And Installing/replacing Heater - A/C Fan2
- Replacing Controller For Heater - A/C Fan
- Removing And Installing (replacing) Control Panel For Heater - A/C System2
- Removing And Installing/replacing Servodrive For Fresh-/recirculated-air Flap
- Removing And Installing/replacing Servodrive For Ventilation Flaps (automatic A
- Removing And Installing/replacing Servodrive For Footwell Flap (automatic A/C)
- Removing And Installing/replacing Servodrive For Central Kinematics (heater - A
- Removing And Installing/replacing Servodrive For Blending Flap
- Removing And Installing/replacing Servodrive For Defrosting Flap (automatic A/C)
- Replacing Evaporator Temperature Sensor
- Replacing Temperature Sensor For Heater
- Removing And Installing/replacing Sensor For Automatic Recirculated Air Control
50 Air Conditioning System17 pages
- Overview Of Heater - A/C System Components
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
51 AC Housing-evaporator, Switching Elemts14 pages
53 Condenser And Dryer With Lines15 pages
- Overview Of Heater - A/C System Components
- Leak-testing Condenser23
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Notes On Replacing Drier Bottle Or Drier Insert
- Replacing Valve Insert For Refrigerant Line2
- Removing And Installing / Replacing Drier Bottle For Air Conditioner2
- Replacing Safety Pressure Switch2
- Removing And Installing Or Replacing Condenser For A/C System2
65 Audio, Navigation And Information System54 pages
12 Stereo Radio, Amplifier5 pages
13 Speaker And Cover5 pages
- Overview Of Radio And Special Equipment
- Removing And Installing/replacing Speaker (treble Speaker In Mirror Triangle Tri
- Removing And Installing/replacing Speaker (mid-range Speaker In Door Trim Panel)
- Removing And Installing/replacing Speaker (mid-range Speaker In Rear Door Trim)
- Removing And Installing/replacing Subwoofer
20 Aerial-antenna8 pages
- Overview Of Radio And Special Equipment
- Removing And Installing/replacing Antenna Rod
- Removing And Installing/replacing Antenna Base2
- Removing And Installing/replacing Antenna Amplifier (rod-type Antenna)
- Removing And Installing/replacing Antenna Amplifier (diversity)
- Removing And Installing/replacing Antenna Amplifier (FM)
- Removing And Installing/replacing Bumper Antenna
77 Airbag Trigger Device, Diagnosis Unit18 pages
- Overview Of Control Units, Modules
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Removing And Installing/replacing Airbag Control Unit2
- Removing And Installing/replacing Airbag Control Unit (build Date From 01/2006)2
- Removing And Installing/replacing Front Left Sensor2
- Removing And Installing/replacing Front Right Sensor
- Removing And Installing/replacing Control Electronics For Passenger Seat Occupan
- Replacing Sensor Mat For Passenger Seat Occupancy Detector
- Removing And Installing/replacing B-pillar Sensor (build Date From 01/2006)
- Removing And Installing/replacing Left B-pillar Sensor (build Date Up To 12/2005
- Removing And Installing (replacing) Left Front Door Sensor2
- Removing And Installing/replacing Right Front Door Sensor
- Overview Of Airbag Modules, Seat Belts And Airbag Triggering Units
81 On-board Computer2 pages
66 Distance Systems, Cruise Control › 20 Park Distance Control3 pages
67 Electrical Drives25 pages
11 Central Locking Unit - Unlocking Units6 pages
13 Mirror Adjustment2 pages
61 Drive, Slide-tilt Sunroof-conv. Top3 pages
63 Drive Unit, Headlight Wipe-wash Unit3 pages
72 Parts - Accessories (Body)40 pages
11 Seat Belts11 pages
- Safety Precautions And General Information
- Checking Automatic Safety Belt23
- Inspection List For Automatic Seat Belt2
- Removing And Installing/replacing Front Left Or Right Seat Belt2
- Removing And Installing/replacing Front Left Or Right Lower Belt Fitting (seat B2
- Overview Of Airbag Modules, Seat Belts And Airbag Triggering Units
12 Airbag Generator-airbag Unit For Pass25 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Components With Gas Generators2
- Deactivating Front Passenger Airbags With Key-operated Switch2
- Firing Pyrotechnical Components (E85)2
- Notes On Scrapping Vehicles With Gas Generators (airbag System)2
- Overview Of Airbag Modules, Seat Belts And Airbag Triggering Units
- Procedure After Airbag Triggering As Result Of An Accident23
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing/replacing Airbag Module On Passenger Side2
- Removing And Installing/replacing Airbag Module For Driver's Knee Protection2
- Removing And Installing/replacing Airbag Module For Passenger's Knee Protection
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door
84 Communication Systems12 pages
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages