Express 2500 V8-6.6L DSL Turbo (2010)
Recharging).
14. Leak test the fittings of the repaired or replaced component using the J 39400-A.
15. Install the battery. Refer to Battery Replacement (Primary) (See: Starting and Charging/Battery/Service and Repair/Removal and Replacement).
Temperature Valve Actuator Replacement
Temperature Valve Actuator Replacement
Removal Procedure
1. Disconnect the air temperature actuator electrical connector.
2. Remove the air temperature actuator retaining screws.
3. Remove the air temperature actuator (1) from the heater assembly (2).
Installation Procedure
1. Install the air temperature actuator (1) to the heater assembly (2).
Caution: Refer to Fastener Caution (See: Service Precautions/Vehicle Damage Warnings/Fastener Caution).
2. Install the air temperature actuator retaining screws and tighten to 1.9 Nm (17 lb in).
3. Connect the air temperature actuator electrical connector.
Auxiliary Temperature Valve Actuator Replacement
Auxiliary Temperature Valve Actuator Replacement
Removal Procedure
1. Remove the left rear quarter trim panel. Refer to Body Side Trim Panel Replacement - Left Side (See: Body and Frame/Interior Moulding /
Trim/Trim Panel/Service and Repair/Body Side Trim Panel Replacement - Left Side).
2. Disconnect the electrical connector from the air temperature actuator.
3. Remove the retaining screws from the air temperature actuator.
