Multipla Factory Service Manual (1998-2010): Heating, air conditioning and auxiliary units
General
Maintenance
Diagnostics
Engine
Transmission
Brakes
Steering & suspension
Heating & A/C
Electrical
Body & interior
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
- 15Heating, air conditioning and auxiliary unitsHeating, air conditioning and auxiliary units: Sections
- Climate control - miscellaneous › Introduction - CLIMATE CONTROL - MISCELLANEOUS
Heating/ventilation - miscellaneous13 pages
- Introduction
- Engine/heater line - r r
- Heater/engine line - r r
- Ventilation system outside air purifying filter (antipollen) - r+r
- Purifying filter (antipollen) filter element - replace
- Under-facia air ducts r r
- Central air duct to rear seat - arrange
- Central air outlet on fascia - r+r
- L/h or r/h side air outlet (one) on fascia - r+r
- Air diffuser to rear seat - r+r
- Lh or rh rear air outlet -one- r r
- Top mixed air temperature sensor - r+r following electrical wiring check with heater case removed
- Passenger compartment air sensor fan - r+r
Heater29 pages
- Introduction - HEATER
- Box and components
- Heater controls
- Supplementary independent heater
- Introduction
- Heater box - r+r
- Heater casing - r+r with facia removed
- Heater box - dismantle and rebuild at bench
- Heater fan motor - r+r
- Heater fan motor selector - r+r
- Heater fan motor resistor - r+r
- Heater radiator - r+r
- Heater radiator - r+r with heater box removed
- Heater control support - r+r
- Heater control support control (one) - arrange
- Air conditioner symbol light bulb/s - includes control panel r+r
- Air distribution flap control cable - r+r
- Air mixer flap control cable - r+r
- Heater system wiring bundle - r r or replace
- RECEIVER for remote control ADDITIONAL INDEPENDENT HEATER - R.R.
- Independent heater unit - r r
- Supplementary independent heater mountbracket r r
- Air intake HOSE for additional independent heater - R.R.
- Pump for metering fuel to supplementary independent heater r r
- Fuel delivery pipe to supplementary independent heater pump - r r
- Supplementary independent heater exhaust pipe - r r
- Coolant intake hose to supplementary independant heater unit r r with heater unit removed
- Coolant outlet hose from supplementary independant heater unit r r with heater unit removed
- System wiring harness - r r
Air conditioning casing and components41 pages
- Introduction - AIR CONDITIONING CASING AND COMPONENTS
- Air conditioner coolant circuit
- Air conditioner box and components
- Air conditioner controls
- Introduction - AIR CONDITIONING CASING AND COMPONENTS
- Checking operation of air conditioner (temperature)
- Check on operation of air conditioning system (pressures)
- Check operation of three-stage pressure switch
- Introduction
- Air conditioning refrigerant CIRCUIT - Draining and Refilling
- Air conditioner cooling circuit - check and repair any leaks by tightening fittings
- Air conditioner compressor - r+r - includes fluid level check and top up if necessary
- Air conditioner condenser - r+r
- Air conditioner dehydrating filter/accumulator - r+r
- Pipe from compressor to air conditioner condenser - r+r
- Pipe from condenser to dehydrating filter - r+r
- Pipe from dehydrating filter to expansion valve - r+r
- Pipe from expansion valve to compressor - r+r
- Air conditioner system multi-level pressure switch - r+r
- Expansion valve (tube orifice) - r+r
- Sensor on evaporator for a/c ecu - r + r
- Air conditioner box - r+r
- Air conditioner housing - r r with facia disconnected
- Air conditioner box - dismantle and rebuild at bench
- Fan motor - r+r
- Fan motor electronic variator - r+r
- Air conditioner heater radiator - r+r
- Air conditioner heater radiator - r+r with fan unit disconnected
- A/c evaporator - r+r
- Air conditioner evaporator - r+r with air conditioner box removed
- Condensate drain pipe and aniti-condensation filter - arrange
- Air conditioner control support - r+r
- Control (one) of air conditioner control support - arrange
- Bulb/s of climate control illumination r r
- Air distribution flap control cable - r+r with control support removed
- Air mixer flap control cable - r + r
- Air inlet and recirculation flap actuator - r r
- A/c manual control switch (one) - r+r
- Air conditioner system wiring bundle - r r
- Air conditioner control unit - r r
- Air conditioner mixer flap control motor - r r
Screen washers and headlamp wash/wipe19 pages
- Introduction - SCREEN WASHERS AND HEADLAMP WASH/WIPE
- Introduction
- Windscreen washer fluid reservoir (in engine bay) - r+r
- Reservoir plug (in engine bay) or windscreen washer fluid level sensor - check and top up if necessary
- Front windscreen washer jets - r+r clean and/or position
- Front and rear screen washer pump - r+r
- Windscreen wiper blade/s - r+r
- Windscreen wiper arm/s - r+r
- Windscreen wiper assembly - r+r or repair
- Windscreen wiper motor - r+r
- Windscreen wiper motor intermittent function - r+r with motor removed
- Front windscreen wiper motor intermittent function - r r
- Rear window washer jet - r+r clean and/or position
- Rear wiper arm - r+r
- Rear wiper motor - r+r
- Rear motor wiper intermittent function - r r with motor removed
- Rear motor wiper intermittent function - r r
- Headlamp washer jet/s - r+r with bumpers removed
- Headlamp washer pump - r+r