ford Workshop Repair Guides

Ford Workshop Service and Repair Manuals

ABOUT US
321-03 2.5 Diesel Engine (76 PS)|Description and Operation > < Crankshaft Rear Oil Seal ‐ Renew (engine or transmission removed) (21 468 4)

Transit 1995 (08.1994-07.2000)

General Specifications Transit 1995 (08/1994-07/2000)
Print Print
Specifications
Engine data
General
Identification code'95 model year4HB
Identification code'97 model year4HC
Emission standard: 4HB95/97 EEC
Emission standard: 4HC97 EEC
Injection sequence (cylinders numbered from front to rear)1‐2‐4‐3
Bore93,67 mm
Stroke90,54 mm
Cubic capacity2496 cc
Compression ratio20.8 : 1
Power output (EEC)56 kW
Power output (EEC)76 (PS)
at rev/min4000
Torque (EEC)168 Nm
at rev/min2500
Idle speed850 ± 25
Max. permissible engine speedContinuous rev/min4000
Intermittent rev/min4400
Location of engine code on cylinder block

  • 1. Engine code
  • 2.5 diesel engine (76 PS): 4HB
  • 2. Engine serial number
Dimensions
Note:
Dimensions: refer to General Specifications ‐ Turbocharged Diesel Engine 85 PS
Lubricants, Adhesives, Coolants and Sealers
DescriptionFord Specification
High‐temperature grease for input shaft splines and for sliding surface of clutch release bearing on guide sleeveESD‐M1C220‐A
Grease for mounting surface of timing belt tensionerSM1C‐4515‐A
Thread‐locking compound ‐ Loctite 2706SDM‐4G‐9107‐A
Super‐Plus 4 Coolant ConcentrateESD‐M97B‐49‐A
Sealer, non‐hardening ‐ Hylomar PL32MSPM‐4G‐9112‐F
Capacity
DescriptionLitres
Engine Oil ‐ Initial fill incl. filter7
Engine oil ‐ oil change without filter change5,7
Engine Oil ‐ Oil change incl. filter change6
Coolant11,5
Engine oil
Viscosities/Ambient TemperatureDesignationSpecification
Recommended engine oil:
SAE 10W30 / ‐20 to over 40 degrees CentigradeFord Super Multigrade Engine OilACEA A2‐96/B2‐96 or A3‐96/B3‐96 or API/SH/CD EC
Alternative engine oils:
SAE 5W40 / ‐20 to over 40 degrees CentigradeFord Formula S Synthetic Engine OilACEA A3‐96/B3‐96 or API/SH/CD EC
SAE 10W40 / ‐20 to over 40 degrees CentigradeFord XR+ High Performance‐High Lubricity Engine OilACEA A3‐96/B3‐96 or API/SH/CD EC
SAE 15W40 / ‐15 to over 40 degrees CentigradeFord Super Multigrade Engine OilACEA A2‐96/B2‐96 or A3‐96/B3‐96 or API/SG/CD
SAE 5W30 / ‐20 to over 10 degrees CentigradeFord Formula E Economy Engine OilACEA A1‐96/B1‐96 and WSS‐M2C912‐A1

NOTE:

Use of engine oil with the specification SAE 5W30 is only permitted in north European countries.
If engine oils with these specifications are not available, only oils which conform to or exceed the API SH/CD EC and CCMC PD2 specifications may be used.
Torques
GeneralNmlbf.ft
Bracket of front exhaust pipe2418
Hood lock panel with radiator118
Support brace to crossmember118
Radiator grille118
Torques
Inlet manifoldNmlbf.ft
Plenum chamber halves2317
Inlet manifold bracket to exhaust manifold2317
Inlet manifold to cylinder head2317
Torques
Exhaust manifoldNmlbf.ft
Exhaust manifold to cylinder head4836
Threaded studs of exhaust manifold2317
Front exhaust pipe to exhaust manifold4030
Bracket of front exhaust pipe2418
Torques
AlternatorNmlbf.ft
Drive belt tensioning strap2418
Alternator mounting bolt2418
Alternator bracket1914
Alternator clamp bolt2418
Torques
Transmission and driveshaftNmlbf.ft
Driveshaft centre bearing to floor assembly3324
Driveshaft to transmission8462
Shift lever to transmission housing2519
Transmission to engine3526
Fuel line bracket to transmission flange3526
Clutch housing front cover2519
Clutch housing adaptor plate107
Transmission to rear transmission mounting8462
Bolt/nut of rear transmission mounting to transmission crossmember8462
Nut of rear transmission mounting to transmission5037
Starter motor to transmission flange3526
Starter motor ground cable to transmission flange3526
Torques
Coolant circuitNmlbf.ft
Water pump pulley107
Fan pulley107
Coolant hose bracket2317
Coolant drain plug2317
Temperature gauge sender unit1511
Engine coolant temperature sensor (ECT sensor)1310
Torques
SteeringNmlbf.ft
Clamp bolt of steering intermediate shaft3022
Steering gear to crossmember5037
Power steering pump mounting bolt2317
V‐belt clamp bolt2317
Torques
Oil circuitNmlbf.ft
Oil pressure switch1410
Oil pressure regulating valve5641
Oil intake pipe to cylinder block1813
Oil pump to adaptor plate1914
Oil pump housing to cylinder block1914
Oil pump housing retaining plate2317
Oil drain plug2418
Sump to cylinder block1410
Oil cooler7052
Vacuum pump oil pressure pipe2115
Torques
Exhaust gas recirculation (EGR)Nmlbf.ft
Plenum chamber halves2317
EGR pipe to exhaust manifold2317
Torques
Engine mountingsNmlbf.ft
Engine mounting bracket to cylinder block5541
Engine mounting bracket to transmission6246
Engine mounting nuts5037
Torques
Fuel systemNmlbf.ft
Fuel pump to cylinder block2317
Fuel pump heat shield2317
Fuel injection pump to adaptor plate2317
Fuel injection pump rear bracket2317
Fuel line to fuel injection pump1813
Fuel filter1712
Fuel injection pump timing belt pulley2519
Fuel injection pipes1914
Torques
Cylinder blockNmlbf.ft
Camshaft rear cover to cylinder block2317
Front pressure plate/bracket to cylinder block2317
Cylinder head to cylinder block ‐ Stage 17052
Cylinder head to cylinder block ‐ Stage 27052
Cylinder head to cylinder block ‐ Stage 390°90°
Engine adaptor plate to cylinder block ‐ bolts 1 ‐ 83627
Engine adaptor plate to cylinder block ‐ bolt 92317
Starter motor to cylinder block3526
Crankshaft rear oil seal housing to cylinder block1914
Allen screws ‐ rear oil seal housing 1410
Camshaft timing pulley ‐ 1st stage107
Camshaft timing pulley ‐ 2nd stage160118
Big‐end bearing caps ‐ Stage 15641
Big‐end bearing caps ‐ Stage 26951
Crankshaft main bearing caps ‐ Stage 18462
Crankshaft main bearing caps ‐ Stage 212089
Bolt of crankshaft pulley/vibration damper16312
Flywheel to crankshaft ‐ Stage 12115
Flywheel to crankshaft ‐ Stage 230°30°
Timing belt cover to adaptor plate75
Splash shield to timing belt cover10,7
Timing belt tensioner clamp bolt2418
Tensioning pulley bolt5843
Water pump to adaptor plate ‐ M82317
Water pump to adaptor plate ‐ M104634
Timing case cover to adaptor plate2317
Engine adaptor plate bracket (bolts)4634
Engine adaptor plate bracket (bolt and nut)2317
Clutch pressure plate to flywheel3022
Drive belt tensioning strap2418
Flywheel immobilising tool to cylinder block3526
Torques
Cylinder headNmlbf.ft
Cylinder head cover ‐ Stage 175
Cylinder head cover ‐ Stage 275
Rocker shaft bearing pedestal bolts, M82921
Rocker shaft bearing pedestal bolts, M106649
Rocker arm adjusting bolt, min.129
Rocker arm adjusting bolt, max.4836
Bolt for injector retaining plate4029
Thermostat housing to cylinder head2317
Thermostat housing bolts2317
EGR valve to throttle housing1813
Bypass hose to cylinder head1813
Engine lifting eye2317
Bracket for holding the engine lifting fixture2317

321-03 2.5 Diesel Engine (76 PS)|Description and Operation > < Crankshaft Rear Oil Seal ‐ Renew (engine or transmission removed) (21 468 4)