Engine

Model: 1.4 - K16 with MPi    Year: 1992 on

Engine

• Type/Capacity . . . . . . . . . . . . . . . . . . . . . . . K16/1397 cm³
• Firing order . . . . . . . . . . . . . . . . . . . . . . 1 - 3 - 4 - 2
• Compression ratio . . . . . . . . . . . . . . . . . . 10.0 : 1
• Idle speed controlled by E.C.U.: . . . . . . . . . 875 ± 50 rev/min
• Exhaust gas CO content at idle . . . . . . . . . . 0.5% hot
• Ignition timing at idle speed:*
    Vacuum connected . . . . . . . . . . . . . . . . . . . 10 ± 5° B.T.D.C.

Programmed ignition

• Distributor cap . . . . . . . . . . . . . . . . . . . . NJD 10010
• Distributor rotor arm . . . . . . . . . . . . . . . AUU 1641 Resistive type
• Rotation . . . . . . . . . . . . . . . . . . . . . . . Anti-clockwise
• Crankshaft sensor:
    Manual gearbox . . . . . . . . . . . . . . . . ADU 7340

Ignition Coil

• Type . . . . . . . . . . . . . . . . . . . . . . . . . NEC 10002, NEC 10003 or NEC 10004
• Primary resistance at 20° C . . . . . . . . . . . . 0.71 to 0.81 ohm
• Consumption - engine idling . . . . . . . . . . . . 0.25 to 0.75 amp average

Spark Plugs

• Type . . . . . . . . . . . . . . . . . . . . . . . . . GSP 6662
• Gap . . . . . . . . . . . . . . . . . . . . . . . . . . 0.85 mm

Electronic Fuel Injection

• Type . . . . . . . . . . . . . . . . . . . . . . . . Indirect multi-point injection with E.C.U.
    control.

M.E.M.S. - E.C.U:

• Alloy inlet manifold . . . . . . . . . . . . . . . MNE 101470
• Plastic inlet manifold . . . . . . . . . . . . . . MKC 101730
• Injectors . . . . . . . . . . . . . . . . . . . . . . MJY 10015
• Fuel pump . . . . . . . . . . . . . . . . . . . . . WQB 10016
• Fuel pressure regulator
    Alloy inlet manifold . . . . . . . . . . . . . MKW 10006
    Plastic inlet manifold . . . . . . . . . . MKW 10016
• Fuel pressure . . . . . . . . . . . . . . . . . . . . 3.0 ± 0.2 bar constant
• Throttle potentiometer voltage:
    Throttle closed . . . . . . . . . . . . . . . . . . 0 to 1 V
    Throttle open . . . . . . . . . . . . . . . . . . 4 to 5 V
• Air temperature sensor . . . . . . . . . . . . . NNK 10001
• Coolant temperature sensor . . . . . . . . . ADU 7161
• Oxygen sensor . . . . . . . . . . . . . . . . . . MHK 10004
• Fuel grade . . . . . . . . . . . . . . . . . . . . . 95 RON minimum - UNLEADED fuel

CAUTION: Serious damage to the engine may occur if a lower octane number fuel than recommended is used. Serious damage to the catalyst will occur if LEADED fuel is used.

* Ignition timing in Crankshaft degrees.