Leon Mk1
|
1 - | ABS control unit -J104- |
q | Assembly location: in the hydraulic control unit, in the engine compartment, to the right |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Do not separate connector before successfully completing self-diagnosis. Switch ignition off before separating connector. |
The control unit is equipped with the following components: |
t | Lateral acceleration sender -G200- |
t | Yaw rate sender -G202- |
t | Longitudinal acceleration sender -G251- (Vehicles with 4WD and hill start assistant) |
q | Removing and installing → Chapter |
2 - | Hydraulic units for the ABS. -N55- |
q | Fitting location: in engine compartment (right-side) |
The hydraulic unit consists of the following components: |
q | ABS hydraulic pump -V64- |
q | Brake pressure sender 1 -G201- |
q | Can be checked using „Guided fault finding“ of the vehicle diagnostic, testing and information system -VAS 505X-. |
q | Valve block (contains inlet and outlet valves). |
q | The ABS hydraulic pump -V64- must not be separated from the valve block |
q | Removing and installing → Chapter |
3 - | Button for TCS and ESP -E256 -, up to week 12.09 |
q | Only in vehicles fitted with ABS/EDS/ASR/ESP |
q | Location: in centre console. |
4 - | Button for TCS and ESP -E256 -, from week 12.09 |
q | Only in vehicles fitted with ABS/EDS/ASR/ESP |
q | Location: in centre console. |
5 - | Diagnostic connection |
q | Installation area: cover in footwell on the driver side |
6 - | Steering angle sender -G85- |
q | Installation location: on the steering column between the steering wheel and the steering wheel lever. |
Note
On vehicles with 3rd generation electro-mechanical steering aid, the steering angle sensor is located in the steering gear |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Removing and installing → Chapter |
7 - | Wheel hub with wheel bearing |
q | The ABS sensor ring is fitted in the wheel bearing |
8 - | Wheel bearing housing |
Figure for front traction |
9 - | Rear right speed sensor -G44 -/rear left speed sensor -G46- |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Removing and installing → Chapter |
10 - | Wheel hub with wheel bearing |
q | The ABS sensor ring is fitted in the wheel bearing |
11 - | Wheel bearing housing |
12 - | Revolution sensor for the front right hand wheel -G45 -/Revolution sensor for the front left hand wheel -G47- |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
q | Removing and installing → Chapter |
13 - | Brake pedal position sender -G100- |
q | Location: on brake pump |
q | Removing and installing → Chapter |
q | Can be checked in „Guided fault finding“, using vehicle diagnostic, testing and information system -VAS 505X-. |
1 - | Dash panel insert up to week 12.2009 |
14 - Brake system indicator -K118- |
q | Function: → Chapter |
15 - ABS warning lamp -K47- |
q | Function: → Chapter |
16 - Brake pad warning lamp -K32- |
q | Function: → Chapter |
17 - Stability Program Indicator, ASR/ESP -K155- |
q | Only in vehicles fitted with ABS/EDS/ASR/ESP |
q | Function: → Chapter |
2 - | Dash panel insert from week 12.2009 |
18 - Brake system indicator -K118- |
q | Brake malfunction, handbrake |
q | If flashing, check the brake fluid level |
q | Function: → Chapter |
19 - ABS warning lamp -K47- |
q | Function: → Chapter |
20- Tyre pressure control indicator, RKA -K220- |
q | For more information about the functionality of the RKA, see Workshop Manual → Running gear, axles, steering; Rep. gr.44 |
21- Warning light for selector lever lock -K169- |
q | For models with automatic gearbox only |
q | Function: → Chapter |
22- Traction control system warning lamp -K86- |
q | Only in vehicles fitted with ABS/EDS/ASR/ESP |
q | Function: → Chapter |
23- Warning lamp for deactivated ESP |
q | From week 22.10 |
q | Function: → Chapter |