skoda Workshop Repair Guides

Skoda Workshop Service and Repair Manuals

Removing and installing power-steering gear (TRW or KOYO) > < Summary of components of power-assisted steering (TRW) - RHD version
Summary of components of pressure line (hose) - power steering TRW - RHD version
   
Summary of components of pressure line (hose) - power steering TRW - RHD version
In the figure, the hose is illustrated at an engine pump aggregate of the TRW. The hose is identical for the engine pump aggregate of KOYO
1 - Engine pump aggregate
q   with noise encapsulation, assignment → Electronic Catalogue of Original Parts
q   with half noise encapsulation, assignment → Electronic Catalogue of Original Parts
q   without noise encapsulation, assignment → Electronic Catalogue of Original Parts
2 - Return line (return hose)
q   Assignment → Electronic Catalogue of Original Parts
q   must not be pinched off during disassembling work
q   No less than minimum bending radius of 100 mm
q   removing and installing → Chapter
3 - Line holder
4 - Power-steering gear
5 - Pressure line (expansion hose)
q   Assignment → Electronic Catalogue of Original Parts
q   must not be pinched off during disassembling work
q   No less than minimum bending radius of 100 mm
q   Pay attention to installation position relative to subframe → Chapter
q   removing and installing → Chapter
6 - Spacer holder
q   clipped onto body
7 - Cable of power-assisted steering sensor -G250-
q   power-assisted steering gear - engine pump aggregate

   
Fitting location of pressure line (flexible hose)
Maintain a clearance -A- of about 10 mm between pressure line -1- and subframe -2-.
–  Insert a suitable spacer between subframe and pressure line.
Use new hollow screw for power-assisted steering gear of TRW.
–  Tighten banjo bolt of pressure line by hand with new seals at the power-assisted steering gear.
–  Remove spacer.
–  Inspect clearance between subframe and pressure line, adjust if necessary.
–  Tighten banjo bolt fully to the specified tightening torque.
  S48-0315
Tightening torques:
Pressure line to the power-assisted steering gear (TRW)
t  Use new hollow screw!
35 Nm
Pressure line to the power-assisted steering gear (KOYO)40 Nm

   

Removing and installing power-steering gear (TRW or KOYO) > < Summary of components of power-assisted steering (TRW) - RHD version