S60 L5-2.4L VIN 64 B5244S6 (2003)
-
Remove the rear roof panel covers and the screws beneath them.
-
Carefully pry off the panel at the rear edge. Use a plastic weatherstrip tool.
-
Pull the rear edge of the panel downwards until the four clips on the top release.
-
If the car is equipped with lighting in the panel, unplug the connector from the panel.
-
Pull the panel backwards to release it.
-
Carefully pull off the D-post panel. Start at the top edge then pull down until the three clips on the inside release. Do not damage the panel.
-
Disconnect the connector on the D-post panel (if the car has a loudspeaker in the D-post, the connector is in the loudspeaker).
-
Remove the panel by pulling upwards slightly and unhooking it from the side panel.
Illustration A shows the removal of the cover for the load securing eyelets
-
Fold out the load securing eyelet.
-
Insert a scriber with an angled tip into the hole in the top of the cover.
-
Turn the scriber so that the angled tip engages in the reverse of the cover (1). Pull the cover off.
Illustration B applies to cars with two rows of seats