1 Series E81 123d (N47S) 3-door: 2 Repair Instructions
Also for this vehicle: 1 Series E81 116i (N43) 3-door, 1 Series E81 116i (N45T) 3-door, 1 Series E81 118d (N47) 3-door, 1 Series E81 118i (N43) 3-door, 1 Series E81 118i (N46T) 3-door, 1 Series E81 120d (N47) 3-door, 1 Series E81 120i (N43) 3-door, 1 Series E81 120i (N46T) 3-door, 1 Series E81 130i (N52K) 3-door.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data63 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack
- Symbols Used And Information In Repair Instructions2
- Battery: Checking Display. If Necessary, Recharge Battery
- Body And Underbody: Checking For Corrosion And Damage
- Body: Check For Corrosion (except Cavities)
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- CBS Reset2
- Check Windscreen Wash/wipe System
- Checking Coolant Level And Concentration, Correcting If Necessary
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness (test Drive)
- Diagnostic Brief Test
- Information/warning Labels23
- Microencapsulated Screws
- Raising BMW Multi-trailer23
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Check Oil Level2
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Washer System: Checking Fluid Level, Topping Up If Necessary
- Interrogating Fault Memories In Diagnosis System
- Standard Scope Of Service
- CBS Reset23
- Engine Oil Service (N47, N47S)2
- Service - Front Brakes
- Service - Rear Brakes
- Service - Microfilter
- Service - Brake Fluid
- Service - Vehicle Check
- Checking/topping Up Oil Level In Rear Differential
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Oil Change In Rear Differential Incl
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (N47S)150 pages
0 Engine, General17 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Engine Oil Service (N47, N47S)2
- Checking Compression Of All Cylinders (N47, N47S)2
- Securing Engine In Installation Position (N47)23
- Engine Identification2345
- Mounting Engine On Assembly Stand (N47, N47S)2
- 11 Engine Block › Checking Crankcase For Water Leaks (N47, N47S)23
- 13 Oil Sump › Removing And Installing, Sealing Or Replacing Oil Sump (N47, N47S)23
- 23 Vibration Damper › Removing And Installing/replacing Vibration Damper (N47, N47S)2
- 24 Connecting Rod With Bearing › Replacing All Connecting Rod Bearings (N47, N47S)23
25 Piston With Rings And Pin8 pages
31 Camshaft19 pages
- Removing And Installing, Sealing/replacing Timing Case Cover At Rear (N47, N47S)23
- Checking Camshaft Timing (N47, N47S)2
- Replacing Inlet Camshaft (N47, N47S)2345
- Replacing Exhaust Camshaft (N47, N47S)23
- Installing And Removing/replacing Chain Tensioner Piston (N47, N47S)
- Checking Camshaft Timing (N47, N47S)2345
33 Rocker Arm With Bearing Mount6 pages
34 Valves With Springs5 pages
- 40 Oil Supply › Checking Engine Oil Pressure (N47, N47S)2
- 41 Oil Pump With Filter And Drive › Removing And Installing Or Replacing Oil/vacuum Pump (N47, N47S)234
- 42 Oil Filter And Lines › Removing And Installing/replacing Complete Main Flow Oil Filter (N47, N47S)2
- 43 Oil Filling, Dipstick › Removing And Installing/replacing Guide Tube For Dipstick (N47, N47S)
- 44 Oil Cooler › Removing And Installing/replacing Oil-water Heat Exchanger (N47, N47S)2
- 51 Water Pump With Drive › Removing And Installing/replacing Water Pump (N47, N47S)
53 Thermostat And Connections3 pages
- 62 Exhaust Manifold › Removing And Installing, Sealing/replacing Exhaust Manifold (N47S)2
71 Exhaust Gas Recirculation4 pages
78 Emission Control, Oxygen Sensor5 pages
12 Engine Electrical System (N47S)56 pages
- 21 Preheating Relay › Replacing Glow Control Unit (N47)
23 Preheater Plugs3 pages
31 Alternator With Drive And Mounting6 pages
41 Starter With Mounting2 pages
- 51 Engine Wiring Loom › Replacing Wiring Harness Section For Injectors (N47)23
61 Oil Pressure-oil Temperature-oil Gauge4 pages
90 Control Unit Box5 pages
13 Fuel System (N47S)54 pages
31 Fuel Pump With Drive And Line3 pages
32 Fuel Filter2 pages
51 Inj.pump, Regulator, Mixt.regulator6 pages
53 Injection Nozzle And Lines20 pages
- Layout Of Common Rail System (N47)
- Removing And Installing/replacing Pressure Accumulator Of Injection System (N47)2
- Removing And Installing/replacing All Pressure Lines To Injectors (N47)23
- Replacing Pressure Line (between High-pressure Pump And Pressure Accumulator) (N23
- Removing And Installing/replacing All Injectors In Fuel Injection System (N47)234
- Replacing Leakage Oil Lines (N47)23
- Removing And Installing/replacing Pressure Sensor On Pressure Accumulator Of Fue2
- Replacing Pressure Regulator On Pressure Accumulator Of Injection System (N47)2
- 61 Electronic Control Unit › Replacing (DDE) Control Unit (N47)2
62 Sensor For Control Unit15 pages
- Replacing Intake Air Temperature Sensor (N47, N47s, M57T2)2
- Replacing Intake Air Temperature Sensor (N47, N47s, M57T2)2
- Replacing Charge-air Pressure Sensor (N47)
- Replacing Fuel Metering Unit On High-pressure Pump (N47)
- Removing And Installing/replacing Air-mass Sensor (N47)
- Replacing Crankshaft Pulse Generator (N47)
- Replacing Camshaft Pulse Generator (N47)2
- Replacing Control Sensor (N47)2
- Replacing Exhaust-gas Pressure Sensor (N47)
- Replacing Exhaust-gas Temperature Sensor (N47)2
16 Fuel Supply System (N47S)33 pages
17 Cooling System (N47S)19 pages
- 10 Radiator, Expansion Tank, Pipes › Checking Cooling System For Water Leaks2
11 Engine Radiator With Attachment7 pages
- Removing And Installing Radiator (M47TU2, N47)
- Removing And Installing/replacing Fan Cowl With Electric Fan (M47T2/N47, N47S)
- Removing And Installing / Replacing Module Carrier2
- Removing And Installing Or Replacing Coolant Expansion Tank (M47T2, M57T2, N47)
- Removing And Installing/replacing Cooling Loop For Power Steering2
- 51 Charge Air Cooler With Mount › Removing And Installing Or Replacing Intercooler (M47T2, M57T2, N47)
18 Exhaust System (N47S)16 pages
- 0 Exhaust System, Complete › Removing And Installing Complete Exhaust System (N47) (without Catalytic Convert2
12 Mufflers, Petrol5 pages
- 31 Exhaust Pipe With Mounting › Removing And Installing/replacing Diesel Particulate Filter (N47)23
- 40 Exhaust Manifold With Integrated Catalyt › Removing And Installing, Sealing/replacing Exhaust Manifold (N47S)2
22 Engine And Gearbox Suspension8 pages
31 Transmission Suspension, Manual Transmis2 pages
32 Transmission Suspension, Autom. Transmis2 pages
23 Manual Transmission (MECH)23 pages
0 Complete Transmission19 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Draining/topping Up Gear Oil In Manual Transmission
- Oil Change In Manual Transmission
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Overview Of Transmission Housing (GS6-37/53BZ/DZ)
- Removing And Installing Transmission (GS6-37DZ) N47, N47S23456
- Installing Replacement Transmission (GS6-37BZ/DZ)2
11 Housing With Cover2 pages
14 Electrical Add-on Parts2 pages
25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission17 pages
- Overview Of Gearshift Mechanism For Manual Transmission
- Replacing U-gaiter
- Removing And Installing Shift Lever2
- Replacing Complete Shift Lever
- Replacing Bearing Shell For Shift Lever
- Replacing Knob For Shift Lever2
- Replacing Gaiter (shift Lever Cover) For Shift Lever
- Replacing Shift Rod
- Replacing Shift Rod Joint2
- Replacing Shift Arm For Shift-lever Mount2
- Replacing Bearing Bushes For Shift Arm
- Replacing Shift Arm Support Bearing
- Removing And Installing/replacing Vibration Damper
26 Propeller Shaft16 pages
- 0 Propeller Shaft, General › Propeller Shaft Deflection Angles
11 Propeller Shaft Assembly9 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle55 pages
0 General11 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle Overview
- Layout Of Spring Strut Shock Absorber
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads2
21 Wheel Bearings And Stub Axle4 pages
31 Spring Strut12 pages
90 Troubleshooting3 pages
32 Steering And Wheel Alignment114 pages
0 Electronic Chassis Alignment33 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Overview Of Steering
- Overview Of Steering Wheel/casing Components
- Chassis/wheel Alignment Check Procedure
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Identifying Suspension From Label On Front Axle
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Chassis/wheel Alignment Check
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- KDS Chassis/wheel Alignment Check With Ride-height Measurement Without Load23
- Adjusting Toe-in And Camber On Front Axle23
- Adjusting Rear Axle
- Adjustment For Active Front Steering
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
13 Steering Gear With Servo Unit14 pages
- Information On Replacing Steering Gear After Accident Damage2
- Teaching In End Stop Software For Electric Steering Gear (EPS)
- Replacing Gaiter For Electric Steering Gear (EPS) On Left Or Right2
- Bleeding Power Steering Unit2
- Removing And Installing/replacing Power Steering Gear2
- Removing And Installing/replacing Active Front Steering Power Steering Gear23
- Removing And Installing (replacing) Electric Steering Gear (EPS)2
21 Steering Arms, Tie Rods, Steer. Damper6 pages
31 Steering Column10 pages
- Removing And Installing/replacing Upper Section Of Steering Column Trim2
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing / Replacing Lower Section Of Steering Spindle2
- Removing And Installing/replacing Steering Angle Sensor
- Removing And Installing/replacing Steering Column2
- Replacing Steering Spindle Sleeve
- Replacing Adjusting Lever For Steering Column
33 Steering Wheel3 pages
34 Steering Wheel For Airbag9 pages
41 Pump And Oil Supply26 pages
- Bleeding Power Steering Unit2
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Notes On Hydraulic Line With Quick-connect Coupling2
- Checking Function Of Power Steering Vane Pump2
- Removing And Installing (replacing) Power Steering Pump For Power Steering Gear
- Removing And Installing (replacing) Vane Pump For Power Steering (N47)2
- Removing And Installing/replacing Belt Pulley On Vane Pump For Power Steering
- Removing And Installing/replacing Fluid Reservoir For Power Steering2
- Removing And Installing / Replacing Fluid Reservoir For Power Steering With Acti2
- Replacing Suction Line For Power Steering (N47)2
- Replacing Pressure Line For Power Steering (N47)2
- Replacing Cooler Return Line For Power Steering2
- Replacing Return Line For Power Steering (N47)2
43 Electronic Power Steering3 pages
90 Troubleshooting3 pages
33 Rear Axle112 pages
0 General17 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Rear Axle Layout
- Information On Replacing Shock Absorbers
- Notes On Repairing Threads
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Overview Of Rear Differential/output Shafts
- Overview Of Rear Axle Carrier With Rubber Mounts
- Overview Of Steering Links
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover12 pages
- Replacing Rear Cover Gasket On Rear Differential (168L)
- Replacing Rear Cover Gasket On Rear Differential (188L / 188LW)
- Replacing Rear Cover Gasket On Rear Differential (215L / 215LW)
- Replacing Shaft Seal For Input Flange On Rear Differential234
- Replacing Drive Flange On Left Or Right Of Rear Differential2
- Replacing Shaft Seal For Drive Flange Left Or Right2
- Replacing Rear Cover Gasket On Rear Differential
21 Output Shafts12 pages
- Pressing Output Shaft Out Of Drive Flange And Drawing In (output Shaft Removed F23
- Ribbed Teeth
- Removing And Installing Or Replacing Left Output Shaft
- Removing And Installing / Replacing Right Output Shaft2
- Replacing Gaiter On Left Output Shaft (altered Sealing Cover)234
- Replacing Gaiter On Right Output Shaft
32 Control Arms And Struts22 pages
- Replacing Left Or Right Trailing Arm
- Replacing Rubber Mount For Trailing Arm In Wheel Carrier2
- Replacing A Rubber Mount For Trailing Arm In Rear Axle Carrier23
- Replacing One Upper Control Arm2
- Replacing A Guide Arm2
- Replacing A Ball Joint In Lower Steering Knuckle/wheel Carrier2
- Removing And Installing / Replacing A Steering Knuckle / Wheel Carrier
- Removing And Installing Or Replacing Tension Strut
- Removing And Installing/replacing Left Or Right Toe Arm2
- Removing And Installing/replacing Left Or Right Camber Arm2
- Replacing Rubber Mount For Camber Arm In Rear Axle Carrier23
- Replacing Left Or Right Rear Axle Carrier Compression Strut
53 Springs With Suspension5 pages
90 Troubleshooting2 pages
34 Brakes76 pages
0 Brake Testing And Bleeding13 pages
- General Information2
- General Information On Braking In New Brake Discs / Brake Pads
- Checking Brakes On Test Stand
- Checking Thickness Of Brake Pad
- Parking Brake Function Check2
- Replacing Fluid In ABS/ASC-T Brake System2
- Bleeding Brake System With DSC2
- Checking Parking Brake Setting (vehicle Check For Service)
- Checking Service Brake: High- And Low-pressure Tests
35 Electrical Components - Wear Indicator3 pages
41 Parking Brake19 pages
- General Information On Braking In New Brake Discs / Brake Pads
- Adjusting Handbrake234
- Overview Of Handbrake
- Removing And Installing Or Replacing Gaiter For Handbrake Lever
- Removing And Installing / Replacing Handbrake Lever23
- Replacing Handle For Handbrake Lever
- Removing And Installing Or Replacing Both Handbrake Bowden Cables2
- Removing And Installing Or Replacing Guide Tube For Handbrake Cables2
- Removing And Installing/replacing All Handbrake Shoes2
- Removing And Installing/replacing Expander Lock For Handbrake Shoes2
- 51 Mechanical-hydraulic Components › Removing And Installing Or Replacing DSC Hydraulic Unit2
- 90 Troubleshooting › Troubleshooting Brake System234
35 Pedals9 pages
21 Brake Pedal With Linkage2 pages
31 Clutch Pedal With Linkage3 pages
- 40 Accelerator Pedal Actuation › Removing And Installing Or Replacing Accelerator Pedal Module
36 Wheels With Tyres25 pages
37 Integrated Suspension Systems6 pages
14 Electrical Components3 pages
41 Body (3-door)172 pages
0 Body61 pages
- Contents Of Body, General2
- Bonding Steel Parts2
- Corrosion Protection2
- Frame Alignment Control Dimensions, Body23
- Gap Dimensions, Body23
- General Cementing Instructions
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Notes On Repairing Threads
- Opening Adhesive Bonds
- Opening Weld Joints
- Position Of Shaped Parts For Cavity Acoustic Baffle
- Quality Standard
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Spot-weld Bonding Steel Parts
- Stamping Vehicle Identification Number23
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Workshop Equipment2
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
11 Support Members23 pages
- Replacing Front Section Of Engine Support To Left Wheel Arch234
- Replacing Left Engine Carrier (partial Replacement Before Front Axle)
- Replacing Front Section Of Left Engine Support2
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Front Left Or Right Support Carrier (partial Replacement, Front Side P2
- Replacing Rear Left Outer Wheel Arch Section (rear Left Side Panel Removed)2
- Replacing Complete Rear Left Wheel Arch (rear Left Side Panel Removed)23
- Replacing Inside Left Side Frame (B-pillar Reinforcement)234
- Replacing Rear Left Side Panel23
12 Luggage Compartment Floor14 pages
14 Wheel Wells15 pages
- Stamping Vehicle Identification Number23
- Vehicle Identification Number, General
- Replacing Front Section Of Engine Support To Left Wheel Arch234
- Replacing Front Left Or Right Support Carrier (partial Replacement, Front Side P2
- Replacing Rear Left Outer Wheel Arch Section (rear Left Side Panel Removed)2
- Replacing Complete Rear Left Wheel Arch (rear Left Side Panel Removed)23
- 31 Roof Outer Skin › Replacing Roof Outer Skin (version With Slide/tilt Sunroof)23
- 32 Dash Cowl › Replacing Front Left Door Pillar (front Side Panel Removed)234
- 33 Front Trim Panel › Replacing Front Wall2
- 34 Rear Trim Panel › Replacing Complete Tail Panel2
35 Side Panels13 pages
- Replacing Rear Left Outer Wheel Arch Section (rear Left Side Panel Removed)2
- Replacing Complete Rear Left Wheel Arch (rear Left Side Panel Removed)23
- Replacing Inside Left Side Frame (B-pillar Reinforcement)234
- Removing And Installing/replacing Side Panel, Front Left Or Right
- Replacing Rear Left Side Panel23
51 Front Side Doors7 pages
52 Rear Side Doors7 pages
61 Front Lid3 pages
63 Other Flaps5 pages
51 Body Equipment (3-door)309 pages
0 General10 pages
- Notes On Bonding/attaching Components With Double-sided Adhesive Tape
- Notes On Fitting Window Guide Seals2
- Safety Instructions For Working On Cars With Airbag Systems
- Service Position Of Engine Hood/bonnet2
- Overview Of Front Bumper
- Overview Of Rear Bumper
- Overview Of Front Door Locks
- Overview Of Dashboard (after 03/2007)
11 Front Bumper16 pages
- Installing/replacing Number/license Plate (without Base)
- Overview Of Front Bumper
- Removing And Installing/replacing Front Cover For Headlight Washer System On Lef
- Removing And Installing/replacing Cover Cap On Spray Nozzle For Headlight Washer2
- Removing And Installing/replacing Carrier For Front Bumper Trim2
- Removing And Installing (replacing) Front Bumper Trim (from 03/2007)2
- Removing And Installing/replacing Front Bumper Trim (M Technic Aerodynamic Kit)23
- Replacing Baseplate For License Plate
- Replacing Body Moulding For Left Or Right Bumper
- Removing And Installing / Replacing Trim Grille In Bumper Trim
- Removing And Installing/replacing Grille In Bumper Trim (M Technic Aerodynamic K
12 Rear Bumper7 pages
- Overview Of Rear Bumper
- Removing And Installing/replacing Carrier For Rear Bumper Trim
- Removing And Installing (or Replacing As From 03/2007) Rear Bumper Panel2
- Removing And Installing/replacing Body Molding For Rear Bumper
- Replacing Bracket For Rear Bumper At Left Or Right
- Removing And Installing/replacing Guide For Rear Centre Bumper
13 Trim, Covers, Handle Trim45 pages
- Removing And Installing/replacing Front Cover For Headlight Washer System On Lef
- Removing And Installing / Replacing Trim Grille In Bumper Trim
- Removing And Installing/replacing Grille In Bumper Trim (M Technic Aerodynamic K
- Replacing Front Radiator Grill, Middle Left Or Right2
- Removing And Installing/replacing Front Radiator Grille, Middle Left Or Right
- Removing And Installing / Replacing Cowl Panel Cover2
- Removing And Installing/replacing Trim Strip On Roof Frame At Left Or Right
- Removing And Installing Or Replacing Trim Strip On Roof Gutter At Left Or Right
- Removing And Installing/replacing Trim For Gearshift
- Removing And Installing/replacing Trim For Storage Compartment At Rear2
- Removing And Installing Center Armrest2
- Removing And Installing/replacing Cover For Centre Armrest2
- Replacing A Clip-mounted Trim (decorative Strip On Instrument Panel Trim)2
- Removing And Installing Or Replacing Trim Cover For Glove Compartment
- Removing And Installing Or Replacing Front Grab Handle
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Cover On Outside Handle
- Removing And Installing/replacing Cover On Outside Handle With Lock Cylinder
- Removing And Installing Or Replacing Window Cavity Cover Strip On Outside Of Lef2
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
- Removing And Installing/replacing Retaining Strip For Cowl Panel Cover
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing Or Replacing Cover On Door Handle, Front Left Or Right
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Replacing Side Cover On Instrument Panel2
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Replacing Footrest For Front Passenger Compartment2
- Notes On Fitting Covers In Front Wheel Arch
- Removing And Installing/replacing Left Or Right Steering Gear Cover
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (front Se
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (rear Sec
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
16 Mirrors-covers-ashtrays-shelves-trays48 pages
- Calibrating Compass In Interior Rearview Mirror
- Cementing Of Mirror Base2
- Removing And Installing/replacing Inside Corner Trim On Front Door
- Removing And Installing/replacing Mounting For Cup Holder At Front
- Removing And Installing/replacing Trim For Gearshift
- Removing And Installing/replacing Trim For Storage Compartment At Rear2
- Removing And Installing Or Replacing Mirror On Left Or Right Front Door2
- Replacing Mirror Glass2
- Removing And Installing/replacing Housing On Left Or Right Door Mirror
- Removing And Installing Or Replacing Retaining Ring On Left Or Right Door Mirror2
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with Japanese Toll M23
- Removing And Installing/replacing Interior Rearview Mirror (with Mirror Arm End23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter Support
- Replacing Ashtray Insert
- Removing And Installing Center Armrest2
- Removing And Installing/replacing Cover For Centre Armrest2
- Removing And Installing Storage Compartment23
- Replacing Storage Compartment
- Replacing A Clip-mounted Trim (decorative Strip On Instrument Panel Trim)2
- Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
- Removing And Installing Or Replacing Trim Cover For Glove Compartment
- Replacing Right Glovebox (from 03/2007)
- Removing And Installing Or Replacing Glove Compartment Lid (after 03/2007)
- Removing And Installing Right Glovebox With Housing (from 03/2007)2
- Removing And Installing/replacing Damper For Glovebox (from 03/2007)
- Removing And Installing/replacing Rear Left/right Grab Handle
- Removing And Installing Or Replacing Front Grab Handle
17 Lids9 pages
- 20 Lock Cylinders, Assembly › Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
21 Front Door Locks, Handles, Fittings28 pages
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Overview Of Front Door Locks
- Replacing Door Detent (lock Striker), Front Left Or Right
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock In Left Or Right Front Door23
- Removing And Installing/replacing Carrier For Left Or Right Outside Door Handle2
- Removing And Installing/replacing Carrier For Left Or Right Outside Door Handle
- Removing And Installing/replacing Complete Lock Cylinder In Left Or Right Front
- Replacing Locks For Simultaneous Closing With CAS Control Unit
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Cover On Outside Handle
- Removing And Installing/replacing Cover On Outside Handle With Lock Cylinder
- Removing And Installing Or Replacing Inside Door Opener For Left Or Right Front2
- Removing And Installing/replacing Bowden Cable For Outside Door Handle On Left O
- Removing And Installing/replacing Bowden Cable For Inside Door Opener On Left Or
- Removing And Installing Or Replacing Door Brake On Left Or Right Front Door2
- Removing And Installing Or Replacing Window Cavity Cover Strip On Outside Of Lef2
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
23 Hood Latch, Locks11 pages
- Adjusting/replacing Bump Stops2
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Right Hood/bonnet Lock
- Adjusing/replacing Striker On Hood/bonnet
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Cable For Hood/bonnet Lock (in Engine Compartm2
- Removing And Installing/replacing Cable For Hood/bonnet Lock (to Interior)2
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
31 Front And Rear Window20 pages
- Instructions On Gluing Windscreen23456789
- Removing And Installing/replacing Retaining Strip For Cowl Panel Cover
- Removing Windscreen With /Roll Out 20002345
- Removing And Installing / Replacing Windscreen
- Repairing Damage To Windscreens Caused By Pitting (stone Chips) (clear And Tinte
- Removing And Installing/replacing Rubber Frame For Windscreen
- Removing And Installing/replacing Rear Window
- Removing And Installing/replacing Sound Insulation On Cowl Panel/windscreen
33 Front Electrically Operated Windows3 pages
41 Front Door Trim Panel With Arm Rest14 pages
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
- Replacing Speaker Cover On Left Or Right Door Trim Panel
- Removing And Installing (replacing) Front Left Or Right Door Trim Panel23
- Replacing Front Left Or Right Door Trim Panel (up To 08/2007)
- Removing And Installing Or Replacing Cover On Door Handle, Front Left Or Right
- Removing And Installing Or Replacing Door Handle On Door Trim Panel, Front Left2
- Removing And Installing (replacing) Armrest On Door Trim Panel, Front Left Or Ri2
- Removing And Installing/replacing Sound Insulation In Left Or Right Front Door2
43 Side Covering With Armrests9 pages
- Removing And Installing Rear Left Or Right Side Trim Panel
- Removing And Installing/replacing Armrest On Rear Left Or Right Side Trim Panel2
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing Or Replacing Panel For Left Or Right Door Pillar
- Removing And Installing Or Replacing Trim For Roof Pillar At Front (A-pillar), L2
- Removing And Installing Or Replacing Trim Panel For Left Or Right Rear Roof Pill
45 Instrument Cluster Trim Panel14 pages
- Overview Of Dashboard (after 03/2007)
- Replacing Side Cover On Instrument Panel2
- Removing And Installing Instrument Panel Trim2
- Replacing Instrument Panel Trim2
- Removing And Installing Trim From Lower Left Instrument Panel (from 03/2007)
- Removing And Installing/replacing Bottom Right Trim For Instrument Panel
- Removing And Installing/replacing Panel For Pedals
- Removing And Installing Or Replacing Outer Trim Cover On Lower Left Dashboard Tr
- Removing And Installing (replacing) Outer Trim On Right Glovebox
- Removing And Installing (or Replacing From 03/2007) Centre Trim Cover On Dashboa2
46 Parcel Shelf Trim Pan.-roller Sun Blind2 pages
47 Floor-lugg.comp.-eng.comp.tr.panels17 pages
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing/replacing Left Or Right Underbody Panelling
- Removing And Installing/replacing Lip On Underbody Panelling On Left Or Right
- Removing And Installing/replacing Rear Left Or Right Ram-air Lip
- Removing And Installing/replacing Rear Left Or Right Underbody Panelling
- Removing And Installing/replacing Front (inside) Left Or Right Entrance Cover St
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Left Luggage Compartment Wheel Arch Trim
- Removing And Installing/replacing Left Or Right Capping In Luggage Compartment
- Removing And Installing/replacing Right Luggage Compartment Wheel Arch Trim
- Replacing Footrest For Front Passenger Compartment2
- Removing And Installing / Replacing Front Carpet For Passenger Compartment
- Removing And Installing Or Replacing Rear Carpet On Seat Pan
- Removing And Installing / Replacing Front Underbody Protection
- Removing And Installing/replacing Rear Underbody Protection
- 61 Reinforcement, Body › Removing And Installing/replacing Tension Strut On Left Or Right Spring Strut Do2
64 Front Panel, Front End2 pages
71 Gaskets-seals, Loose Body Components18 pages
- Removing And Installing / Replacing Cowl Panel Cover2
- Replacing Front Left Or Right Rubber Guide For Left Or Right Door Window
- Notes On Fitting Covers In Front Wheel Arch
- Removing And Installing/replacing Cover For Carbon Canister
- Removing And Installing/replacing Left Or Right Steering Gear Cover
- Removing And Installing/replacing Left Spring Support Passage Cover
- Removing And Installing/replacing Multifunction Pan2
- Removing And Installing/replacing Right Spring Support Passage Cover
- Removing And Installing / Replacing Seal On Front Door, Left Or Right
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (front Se
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover (rear Sec
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Tension Strut On Left Or Right Spring Strut Do2
- Removing And Installing Or Replacing Panel For Cover On Left Or Right Side Membe2
52 Seats170 pages
13 Front Seat, Normal, Manual26 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat Backre2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Replacing Seat Cover On Left Or Right Front Seat (normal/manual)234
- Replacing Backrest Cover For Left Or Right Front Seat (normal / Manual)23
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Replacing Left Or Right Support For Front Seat Backrest (normal / Manual)
- Replacing Heating Elements For Left Or Right Front Seat (basic)2
- Performing Function Check With Adapter Cable (for Seat Repairs)
14 Front Seat, Normal, Electric32 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Replacing Seat Cover On Left Or Right Front Seat (normal/manual)234
- Replacing Backrest Cover For Left Or Right Front Seat (normal / Manual)23
- Replacing Left Or Right Support For Front Seat (normal / Manual)
- Replacing Left Or Right Support For Front Seat Backrest (normal / Manual)
- Replacing Heating Elements For Left Or Right Front Seat (basic)2
- Performing Function Check With Adapter Cable (for Seat Repairs)
- Removing And Installing Carrier For Outer Cover On Left Or Right Front Seat (ele
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing/replacing Lumbar Cushion On Front Seat2
- Removing And Installing/replacing Valve Housing For Lumbar Cushion2
15 Front Seat, Sports, Manual39 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing/replacing Outer Cover On Left Or Right Front Seat Backre2
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Performing Function Check With Adapter Cable (for Seat Repairs)
- Removing And Installing/replacing Thigh Support On Left Or Right Front Seat (spo2
- Removing And Installing Or Replacing Lumbar Cushion On Front Seat2
- Removing And Installing / Replacing Valve Housing For Lumbar Support / Backrest2
- Replacing An Air Cushion For Left Or Right Backrest Width Adjustment2
- Removing And Installing/replacing Thigh Support Cover On Front Seat (sport/manua
- Replacing Backrest Cover For Left Or Right Front Seat (sport/manual)23
- Replacing Padding For Left Or Right Front Seat (sport/manual)
- Replacing Padding For Left Or Right Thigh Support (sport/manual)
- Replacing Padding For Left Or Right Front Seat Backrest (sport/manual)
- Replacing Heating Elements For Left Or Right Front Seat (sport / Manual)2
- Replacing Seat Cover For Left Or Right Front Seat (sports/electric)234
- Replacing Backrest Cover On Front Left Or Right Seat (sports/electric)23
16 Front Seat, Sports, Electric43 pages
- Replacing Guide Sleeves For Front Left Or Right Head Restraint
- Removing And Installing Left Or Right Front Seat (normal / Manual)2
- Removing And Installing / Replacing Flexmat On Left Or Right Front Seat
- Removing And Installing/replacing Backrest Frame On Left Or Right Front Seat2
- Removing And Installing/replacing Release Mechanism On Left Or Right Front Seat23
- Removing And Installing / Replacing Inner Cover On Left Or Right Front Seat Back
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Head Restraint
- Performing Function Check With Adapter Cable (for Seat Repairs)
- Removing And Installing Carrier For Outer Cover On Left Or Right Front Seat (ele
- Removing And Installing/replacing Outer Cover On Front Left Or Right Seat (norma23
- Removing And Installing/replacing Lumbar Cushion On Front Seat2
- Removing And Installing / Replacing Valve Housing For Lumbar Support / Backrest2
- Removing And Installing/replacing Thigh Support Cover On Front Seat (sport/manua
- Replacing Backrest Cover For Left Or Right Front Seat (sport/manual)23
- Replacing Padding For Left Or Right Front Seat (sport/manual)
- Replacing Padding For Left Or Right Thigh Support (sport/manual)
- Replacing Padding For Left Or Right Front Seat Backrest (sport/manual)
- Replacing Heating Elements For Left Or Right Front Seat (sport / Manual)2
- Removing And Installing Thigh Support On Left Or Right Front Seat (sport/electri2
- Replacing An Air Cushion For Left Or Right Backrest Width Adjustment2
- Removing And Installing/replacing Valve Housing For Lumbar Cushion2
- Replacing Seat Cover For Left Or Right Front Seat (sports/electric)234
- Replacing Backrest Cover On Front Left Or Right Seat (sports/electric)23
- 24 Rear Seat, Normal › Removing And Installing/replacing Rest Side Section On Left Or Right Rear Seat B
26 Rear Seat, Through-loading29 pages
- Removing And Installing/replacing All Guide Sleeves For Rear Head Restraints
- Removing And Installing/replacing Cup Holder In Armrest For Rear Seat Backrest
- Removing And Installing/replacing Ski Bag With Casing On Rear Seat (through-load2
- Removing And Installing Or Replacing Rear Seat
- Removing And Installing/replacing Rest Side Section On Left Or Right Rear Seat B
- Removing And Installing/replacing Backrest For Left Or Right Rear Seat
- Removing And Installing/replacing Both Backrests For Rear Seat
- Removing And Installing Complete Centre Armrest For Rear Seat Backrest (through-2
- Removing And Installing/replacing Seat Frame
- Removing And Installing/replacing Left Backrest Frame For Rear Seat
- Removing And Installing/replacing Right Backrest Frame For Rear Seat
- Removing And Installing/replacing Rear Panel On Left Rear Seat Backrest2
- Removing And Installing/replacing Rear Panel On Right Rear Seat Backrest
- Removing And Installing/replacing Lock For Left Or Right Rear Seat Backrest2
- Removing And Installing/replacing Rear Middle Head Restraint
- Removing And Installing Or Replacing Left Or Right Rear Head Restraint
- Replacing Seat Cover For Rear Seat2
- Replacing Left Backrest Cover For Rear Seat23
- Replacing Right Backrest Cover For Rear Seat2
- Replacing Padding For Rear Seat
- Removing And Installing/replacing Rear Seat Storage Tray
54 Slide-tilt Sunroof And Convertible Top (3-door)24 pages
- 10 Sunroof › Repair Instructions For Bonded Seals23
12 Mechanical Sun Roof Components18 pages
- Replacing Complete Glass Slide/tilt Sunroof Frame
- Adjusting Glass Slide/tilt Sunroof Lid2
- Replacing Left Or Right Gaiter For Glass Slide/tilt Sunroof
- Removing And Installing Glass Slide/tilt Sunroof Lid
- Replacing Seal For Glass Slide/tilt Sunroof Lid
- Removing And Installing/replacing Roofliner For Glass Slide/tilt Sunroof2
- Removing And Installing/replacing Rain Gutter For Glass Slide/tilt Sunroof2
- Removing And Installing/replacing Connecting Element Pair For Glass Slide/tilt S23
- Removing And Installing/replacing Inspection Trim For Glass Slide/tilt Sunroof
- Removing And Installing/replacing Stop For Glass Slide/tilt Sunroof
- Removing And Installing Complete Glass Slide/tilt Sunroof2
- Removing And Installing/replacing Wind Deflector For Glass Slide/tilt Sunroof
13 Electrical Sun Roof Components3 pages
61 General Electrical System220 pages
0 Troubleshooting20 pages
- Instructions On Starting Aid
- Battery
- Diagnosis For Condition Based Service234
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- General Information On Intelligent Battery Sensor (IBS)
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
- 11 Wiring Harness › Notes On Handling Wiring Harnesses And Cables
12 Auxiliary Cable14 pages
- General Information On Intelligent Battery Sensor (IBS)
- Replacing Battery Positive Lead
- Replacing Battery Positive Lead (from Luggage Compartment Connector To Engine Bu23
- Replacing Battery Negative Lead (from 03/2007)
- Replacing Wiring Harness In Left Or Right Front Door2
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
13 Plug Connection, Terminal, Fuse Box54 pages
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Removing And Installing/replacing OBD-II Socket2
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
- Removing And Installing Or Replacing Fuse Box In Passenger Compartment (built Af2
- Removing And Installing/replacing USB/audio Interface Connecting Socket
14 Distribution Box, Power Support Points4 pages
20 Battery19 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- General Information On Intelligent Battery Sensor (IBS)
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- Disconnecting And Connecting Battery Negative Lead2
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
21 Battery-vapour Separator3 pages
31 Switch43 pages
- Overview Of Switches
- Removing And Installing Front Passenger Power Window Switch (up To 08/2007)23
- Removing And Installing/replacing Fixture For Steering Column Stalk2
- Removing And Installing/replacing Volute Spring Cassette2
- Removing And Installing/replacing Start/Stop Switch
- Removing And Installing/replacing Light Control Unit2
- Removing And Installing (replacing) Switch For Passenger Airbag Deactivation
- Removing And Installing Or Replacing Roof Switch Centre2
- Removing And Installing (or Replacing Version Without CCC) Centre Console Switch
- Removing And Installing (or Replacing Version With CCC) Centre Console Switch Cl
- Removing And Installing/replacing Switch For Hazard Warning Flashers/central Loc
- Removing And Installing/replacing Switch For Unlocking Rear Lid
- Removing And Installing/replacing Switch For Backrest Width Adjustment
- Removing And Installing/replacing Both Shift Paddles For Automatic Transmission
- Replacing (removing And Installing) Rocker Switch For Side Window Operation (fro2
- Replacing Rocker Switch For Side Window Operation (front) (up To 08/2007)
- Replacing Front Passenger Power Window Switch
- Replacing Front Passenger Power Window Switch (up To 08/2007)2
- Removing And Installing/replacing AV Connection Socket
- Removing And Installing/replacing USB/audio Interface Connecting Socket
- Replacing Knob For Controller
- Removing And Installing (replacing) Front Controller23
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Switch For Front Lumbar Support
- Removing And Installing/replacing Both Switches On Sport Steering Wheel
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror
- Replacing Switch For Reversing Light
- Removing And Installing/replacing Clutch Switch Module
- Replacing Brake Light Switch
- Replacing Coolant Level Switch
- Replacing Level Switch For Windscreen Washer System
- Carrying Out Steering Angle Sensor Adjustment
- 33 Horn › Removing And Installing/replacing A Fanfare Horn
- 34 Insert Holder For Cigarette Lighter › Removing And Installing Or Replacing Socket Outlet In Luggage Compartment
35 ECUs, Modules30 pages
- Removing And Installing/replacing Control Unit For Active Front Steering2
- Overview Of Control Units
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing (replacing) Trailer Module2
- Removing And Installing (replacing) Control Unit For Car Access System2
- Removing And Installing/replacing Control Unit/module For Left Or Right Seat Adj2
- Removing And Installing/replacing Control Unit/module For Seat Heating
- Removing And Installing Or Replacing Junction Box Electronics
- Removing And Installing/replacing Footwell Module
- Removing And Installing (replacing) Rain/light Sensor2
- Initializing Rain/light Sensor
- Removing And Installing (replacing) Control Unit For Comfort Access System2
- Removing And Installing/replacing Interior Antenna For Comfort Access System (fr
- Removing And Installing/replacing Interior Antenna For Comfort Access System (re
- Removing And Installing/replacing Rear Luggage Compartment Antenna For Comfort A
- Removing And Installing/replacing Bumper Antenna For Comfort Access System
- Replacing Fogging Sensor2
- Removing And Installing (replacing) USB Hub
- Removing And Installing (replacing) Hands-free Charging Electronics (High)2
- Vehicle Programming And Coding
36 Relays2 pages
61 Windscreen Wipers10 pages
- Adjusting Left Or Right Windscreen Wiper23
- Overview Of Windscreen Wiper And Washer System
- Checking/adjusting Contact Angle Of Windscreen Wiper Arms On Windscreen2
- Replacing Both Windscreen Wiper Blades
- Removing And Installing/replacing Both Windscreen Wiper Arms2
- Removing And Installing Or Replacing Bracket For Windscreen Wiper System Complet
62 Rear Window Wiper6 pages
- Overview Of Windscreen Wiper And Washer System
- Removing And Installing/replacing Rear Window Wiper Blade
- Removing And Installing/replacing Wiper Arm On Rear Window
- Removing And Installing/replacing Rear Window Wiper Motor
- Replacing Spray Nozzle For Rear Window Washer Unit
- Removing And Installing/replacing Window Washer Pump For Rear Window Washer Unit
67 Headlight Washer System7 pages
- Overview Of Windscreen Wiper And Washer System
- Removing And Installing/replacing Washer Pump Of Headlight Washer System
- Removing And Installing/replacing Spray Nozzles For Left Or Right Headlight Clea2
- Removing And Installing/replacing Spray Nozzles (nozzle Heads) Of Headlight Wash
- Removing And Installing/replacing High-pressure Nozzle (housing) Of Headlight Wa2
- 62 Instruments › 11 Instrument Cluster › Removing And Installing (replacing) Instrument Cluster
63 Lights68 pages
12 Headlights19 pages
- Removing And Installing/replacing Left Headlight
- Removing And Installing/replacing Right Headlight
- Removing And Installing Or Replacing Left Headlight (xenon Headlight)2
- Removing And Installing Right Headlight (xenon Headlight)
- Removing And Installing Or Replacing Left Headlight (adaptive Headlight)
- Removing And Installing/replacing Right Headlight (adaptive Headlight)
- Replacing Control Unit For Left Xenon Headlight (from 03/2007)
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight (with Xenon Bulb) (from 03/20072
- Replacing Ignition Unit For Right Xenon Headlight (with Xenon Bulb) (from 03/2002
- Replacing Drive Unit For Left Adaptive Headlight (after 03/2007)2
- Replacing Drive Unit For Right Adaptive Headlight (from 03/2007)2
- Removing And Installing/replacing Left Headlight Vertical Aim Adjuster
- Removing And Installing/replacing Right Headlight Vertical Aim Adjuster
- 13 Turn Signal Indicator Lights › Removing And Installing/replacing Front Left Or Right Auxiliary Direction Indica
- 25 Brake Lights › Removing And Installing/replacing Auxiliary Brake Light
- 26 Licence Plate Lights › Removing And Installing/replacing Left Or Right Number/license Plate Light
31 Interior Lights12 pages
- Overview Of Interior Lights
- Removing And Installing Or Replacing Complete Roof Light (front)
- Removing And Installing/replacing Complete Ceiling Light (rear)
- Removing And Installing Or Replacing Complete Ceiling Light (rear, With Module F23
- Removing And Installing/replacing Footwell Light (footwell)
- Removing And Installing/replacing Mirror Light
- Removing And Installing/replacing Luggage Compartment Light
- Removing And Installing/replacing Glovebox Light
- Removing And Installing/replacing Door Handle Light On Left Or Right Front Door2
99 Light Bulbs24 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For Left (or Right) High-beam Headlight
- Replacing Halogen Bulb For Left (or Right) Headlight
- Replacing Bulb For Left (or Right) Xenon Headlight (with Ignition Unit)
- Replacing Bulb For Front Left (or Right) Side Light (after 03/2007)
- Replacing Bulb For Front Left (or Right) Side Lights (xenon) (from 03/2007)
- Replacing Bulb For Front Left (or Right) Turning Lights
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp2
- Replacing Halogen Bulb For Left Or Right Fog Light (M-package/aerodynamics Packa
- Replacing Bulb For Left (or Right) Front Turn Indicator
- Replacing Bulb For Auxiliary Direction Indicator, Front Left Or Right
- Replacing Light Bulb(s) For Left Or Right Rear Light
- Replacing Bulb For Left Or Right License Plate Light
- Replacing Bulb For Front Ceiling Light2
- Replacing Bulb For Rear Ceiling Light2
- Replacing Light Bulb For Footwell Light2
- Replacing Bulb For Mirror Light
- Replacing Light Bulb For Luggage Compartment Lighting
- Replacing Bulb For Glovebox Light
64 Heating And Air Conditioning105 pages
11 Heater With Operation42 pages
- Removing And Installing/replacing Heater2345
- Removing And Installing/replacing Heater2345
- Replacing Heater Core2
- Removing And Installing/replacing Heater/air Conditioner Fan
- Replacing Controller For Heater/air Conditioner Fan
- Removing And Installing/replacing Auxiliary Water Pump2
- Removing And Installing Or Replacing Heater/air Conditioner Operator Unit (versi23
- Removing And Installing Or Replacing Heater/air Conditioner Operator Unit (versi23
- Removing And Installing/replacing Servodrive For Fresh-/recirculated-air Flap
- Replacing Servodrive For Ventilation Flaps (automatic A/C)
- Replacing Servodrive For Footwell Flap (automatic A / C)2
- Removing And Installing / Replacing Servodrive For Central Kinematics (heater -2
- Removing And Installing/replacing Servodrive For Blending Flap (left)2
- Removing And Installing/replacing Servodrive For Blending Flap (left)2
- Removing And Installing/replacing Servodrive For Blending Flap (right, Automatic2
- Removing And Installing/replacing Ventilation Temperature Sensor
- Removing And Installing/replacing Footwell Temperature Sensor
- Replacing Evaporator Temperature Sensor
- Replacing Fogging Sensor2
- Removing And Installing/replacing Sensor For Automatic Recirculated Air Control
- Removing And Installing Or Replacing Solar Sensor
- Overview Of A/C Circuit Components
- 12 Auxil. Heater With Control Elements › Removing And Installing/replacing Complete Electric Auxiliary Heater2
50 Air Conditioning System16 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
53 Condenser And Dryer With Lines15 pages
- Leak-testing Condenser23
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Overview Of A/C Circuit Components
- Notes On Replacing Drier Bottle Or Drier Insert
- Replacing Valve Insert For Refrigerant Line2
- Replacing Desiccant Insert For A/C System2
- Replacing Safety Pressure Switch2
- Removing And Installing Or Replacing Condenser For A/C System2
65 Audio, Navigation And Information System46 pages
12 Stereo Radio, Amplifier9 pages
- Overview Of Audio Components (HiFi System)
- Overview Of Audio Components (Top HiFi System)
- Overview Of Audio Components (stereo System)
- Removing And Installing/replacing Left Or Right Central Bass Speaker (under Fron
- Removing And Installing Or Replacing Amplifier
- Removing And Installing (replacing) Amplifier (Top Hi-fi System)2
- Removing And Installing (replacing) Audio System Controller (from 03/2007)2
13 Speaker And Cover5 pages
- 50 Video And TV Equipment › Removing And Installing/replacing Central Information Display
77 Airbag Trigger Device, Diagnosis Unit8 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Removing And Installing/replacing Airbag Control Unit2
- Removing And Installing (replacing) Left B-pillar Sensor2
- Removing And Installing/replacing Right B-pillar Sensor
- Overview Of Airbag Modules, Seat Belts, Airbag Sensors And Airbag Control Unit
- 81 On-board Computer › Removing And Installing/replacing Outside Temperature Sensor
83 Car Communication Computer (CCC)13 pages
- Removing And Installing Or Replacing Car Communication Computer (after 03/2007)2
- Removing And Installing/replacing Fan For Car Communication Computer
- Removing And Installing/replacing Front Trim For Car Communication Computer
- Removing And Installing/replacing CD Drive For Car Communication Computer2
- Removing And Installing/replacing DVD Drive For Car Communication Computer23
- Removing And Installing/replacing Gyro Sensor Drive For Car Communication Comput2
- Replacing HIP Module For Car Communication Computer2
66 Distance Systems, Cruise Control5 pages
- 12 Radio-controlled Locking System › Removing And Installing/replacing Slide-in Unit For Radio Control Key
20 Park Distance Control4 pages
- Removing And Installing (replacing) Control Unit (Park Distance Control)
- Removing And Installing/replacing An Ultrasonic Transducer At Front (Park Distan
- Removing And Installing/replacing A Rear Ultrasonic Transducer (Park Distance Co
- Removing And Installing/replacing Front Signal Sensor (Park Distance Control)
67 Electrical Drives12 pages
11 Central Locking Unit - Unlocking Units4 pages
- 13 Mirror Adjustment › Replacing Drive Unit For Electrically Operated Left Or Right Door Mirror
- 61 Drive, Slide-tilt Sunroof-conv. Top › Replacing Drive With Gear For Actuating Slide/tilt Sunroof
- 63 Drive Unit, Headlight Wipe-wash Unit › Replacing Wiper Motor
72 Parts - Accessories (Body)42 pages
11 Seat Belts12 pages
- Safety Precautions And General Information
- Checking Automatic Safety Belt23
- Removing And Installing Or Replacing Front Seat Belt2
- Removing And Installing/replacing Front Left Or Right Lower Belt Fitting (seat B2
- Removing And Installing/replacing Rear Left Or Right Seat Belts
- Removing And Installing/replacing All Rear Lower Belt Fittings2
- Overview Of Airbag Modules, Seat Belts, Airbag Sensors And Airbag Control Unit
12 Airbag Generator-airbag Unit For Pass26 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Components With Gas Generators2
- Deactivating Front Passenger Airbags With Key-operated Switch2
- Notes On Scrapping Vehicles With Gas Generators (airbag System)2
- Overview Of Airbag Modules, Seat Belts, Airbag Sensors And Airbag Control Unit
- Procedure After Airbag Triggering As Result Of An Accident23
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing Or Replacing Airbag Module On Passenger Side
- Removing And Installing Side Airbag (basic Seat)23
- Removing And Installing Side Airbag (sport Seat)2
- Removing And Installing Or Replacing Left Or Right Head Airbag23
84 Communication Systems15 pages
10 Cellular Telephone2 pages
11 Transceiver, Handset-support, Card Reade6 pages
31 Hands-free System, Microphone, Speaker2 pages
- 50 Antenna › Removing And Installing Or Replacing Bluetooth Aerial
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2