Rear door water penetration
- Make
- Fiat
- Model
- Multipla Factory Service Manual
- Year
- 1998–2010
- Section
- Water penetration › Rear door water penetration
Fault diagnosisRear door water penetration
REAR DOOR WATER PENETRATION
When it is raining or after washing, water enters in the area of one of the rear doors
| Results of the tests | ||||
| 1 | CHECK DOOR COMPARTMENT SEAL | All OK | Problems met | Operation |
|---|---|---|---|---|
Check the door seal In particular, ascertain:
| Continue to Step 2 | Faulty fitting of seal | Fit the sealing strip correctly Op. 7010A34 | |
| 2 | CHECK DOOR ALIGNMENT | All OK | Problems met | Operation |
Check the door is properly fitted. In particular, ascertain:
| Continue to Step 3 | door incorrectly fitted | Refit the door properly Op. 7010A14 | |
| 3 | CHECK MOVING WINDOW GLASS | All OK | Problems met | Operation |
Check the moving window glass seal In particular, ascertain:
| Continue to Step 4 | Channel incorrectly positioned | Refit the shield correctly Op. 7010D05 | |
| Window glass incorrectly fitted | Refit the moving window glass guide correctly Op. 7010D23 | |||
| Glass scraper incorrectly fitted | Refit the glass scraper correctly Op. 7010D26 | |||
| 4 | CHECK DOOR DRAINAGE | All OK | Problems met | Operation |
| Check the drainage on the lower part of the doors. In particular, check for dirt, leaves etc. | Continue to Step 5 | Dirt in drains | Clean the drains. If necessary, refit the lower seal correctly Op. 7010A46 | |
| 5 | CHECKING CORRECT OPERATION | All OK | Problems met | Operation |
| Check that the fault is no longer present | End of diagnosis | Fault persists | Search for the fault starting from another symptom' | |
Parts & tools for this job For 1998 Fiat Multipla
- TOOLTrim removal tool kitSearch: trim removal tool kit
- PARTTouch-up paintSearch: Fiat touch up paint
- PARTPanel clip assortmentSearch: Fiat panel clips assortment
Links open Amazon search results in a new tab. As an Amazon Associate I earn from qualifying purchases.