Leon Mk2
Note!
|
1 - | Hexagon bolt, 270 Nm |
q | M18 x 1.5 x 48 |
2 - | Drive shaft |
q | With rotor for speed sensor |
3 - | Wheel bearing housing |
4 - | Hexagon bolt, 10 Nm |
5 - | ABS speed sensor |
q | Before inserting sensor, clean inner surface of fitting hole and coat with lubricating paste G 000 650. |
6 - | Hexagon socket head bolt, 10 Nm |
7 - | Cover plate |
8 - | Brake disc |
q | Brake disc thickness: 26 mm. |
q | Wear limit: 22 mm. |
q | Internally ventilated brake disc: Ø 300 mm. |
q | When worn, always renew on both sides of axle. |
q | Never remove brake discs from wheel hub by force. If necessary use penetrating fluid, because otherwise brake discs can be damaged. |
9 - | Hexagon bolt |
10 - | Fitted bolt, 12 Nm |
11 - | Brake carrier |
q | Supplied as replacement part, assembled with sufficient grease on guide pins. |
q | Use repair set if protective caps are damaged |
q | Use supplied grease sachet to lubricate guide pins. |
12 - | Retaining spring |
q | Press under brake carrier and insert into both holes in brake caliper housing. |
13 - | Brake caliper |
q | Do not disconnect brake hose when changing brake pads. |
q | Removing: |
q | Remove brake pads → Chapter. |
q | Insert brake pedal actuator -V.A.G 1869/2- (and relieve pressure). |
q | Unscrew brake hose → Item from brake caliper |
q | Installing: |
q | Installing brake pads. |
q | Connect brake hose to brake caliper. |
q | Remove brake pedal actuator -V.A.G 1869/2-. |
q | Bleed brake system → Chapter. |
q | Repairing → Chapter. |
14 - | Brake pads |
q | Thickness 14.5 mm not including backplate. |
q | With wear indicator. |
q | When wear reaches a predetermined limit (approx 4 mm) the warning lamp in dash panel insert comes on. |
q | Wear limit: 2 mm excluding backing plate. |
q | Brake pad with retaining spring is seated on piston |
q | Checking thickness → Booklet10.1. |
q | Always renew both sides. |
q | Removing and installing → Chapter. |
15 - | Guide pin, 30 Nm |
16 - | Cover cap |
17 - | Connector |
q | When changing pads, remove from bracket → Item. |
18 - | Cable bracket |
19 - | Hexagon bolt, 10 Nm |
20 - | Retaining spring |
21 - | Brake line, 14 Nm |
22 - | Hexagon bolt, 10 Nm |
23 - | Bracket |
24 - | Brake hose |