Workshop Repair Manuals

Volvo Workshop Manuals

[PREV PAGE] [NEXT PAGE]

volvo Workshop Repair Guides


940 L4-2.3L SOHC VIN 88 B230F (1992)

Relays and Modules > Relays and Modules - HVAC > Control Module HVAC > Component Information > Technical Service Bulletins > All Technical Service Bulletins for Control Module HVAC: > 887955 > Sep > 97 > A/C - Unpleasent Odor On Startup > Page 451

Page 28
background image

G1
Preparations
-

Clean evaporator according to Service Manual:

Section 8(87)
Climate control
700/900 1982-
Section V

-

Make note of radio code if anti-theft coded radio installed.

Remove:
-

Negative battery lead.

-

Sound insulation on passenger side.

-

Glove compartment

-

Ashtray.

-

Cigarette lighter.

-

Storage compartment.

-

Detach, pull out and turn central electronics module.

Refer to Service Manual:

Section 3(35-39) (see group 37) Lighting, instrumentation and other electrical equipment 700/900 1982-
Section 8(82-86, 88) Interior, exterior 700/900 1982-

Cable connections

G2
Installing new relay on cable harness

-

Take out cable harness (P/N 9447729) supplied with kit.

-

Install relay supplied in the 5-pin connector.

G3
Route cables to engine compartment
-

Route cables without housing receptacles to engine compartment through unused cutout in grommet below suspension strut brace.

-

Install round housing receptacles supplied with cable harness on the cables in the engine compartment.

-

Separate existing connectors on the cable between the A/C compressor and the receiver/drier.

Relays and Modules > Relays and Modules - HVAC > Control Module HVAC > Component Information > Technical Service Bulletins > All Technical Service Bulletins for Control Module HVAC: > 887955 > Sep > 97 > A/C - Unpleasent Odor On Startup > Page 451

[PREV PAGE] [NEXT PAGE]