Workshop Manuals Factory service & repair MG
01 Introduction02 General information03 General data, torque settings and capacities04 Maintenance05 Engine (K Series)06 Engine management (MEMS 3), fuel and emission systems07 Cooling system08 Manifolds and exhaust system09 Clutch10 Manual gearbox11 Automatic gearbox (Stepspeed Em-CVT)12 Drive shafts13 Steering14 Front suspension15 Rear suspension16 Brakes17 Restraint systems (SRS)18 Body19 Heating and ventilation20 Air conditioning21 Wipers and washers22 Electrical23 Instruments
MG TF Factory Workshop Manual (2002-2005)02 · General information
02 · General

Joints and joint faces

Make
MG
Model
TF Factory Workshop Manual
Year
2002–2005
Section
General precautions and fitting instructions › Joints and joint faces
General informationJoints and joint faces

Joints and joint faces

Fit joints dry unless specified otherwise.

  • When jointing compound is used, apply in a thin uniform film to metal surfaces; take care to prevent jointing compound from entering oilways, pipes or blind tapped holes.
  • If gaskets and/or jointing compound is recommended for use; remove all traces of old jointing material prior to reassembly. Do not use a tool which will damage the joint faces and smooth out any scratches or burrs on the joint faces using an oil stone. Do not allow dirt or jointing material to enter any tapped holes or enclosed parts.
  • Prior to reassembly, blow through any pipes, channels or crevices with compressed air.

Locking Devices

Always replace locking devices with one of the same design.

Tab washers - always release locking tabs and fit new locking washers. Do not re-use locking tabs.

Locking nuts - always use a backing spanner when loosening or tightening locking nuts, brake and fuel pipe unions.

Roll pins - always fit new roll pins of an interference fit in the hole.

Circlips - always fit new circlips of the correct size for the groove.

Keys and keyways - remove burrs from edges of keyways with a fine file and clean thoroughly before attempting to refit key.

Clean and inspect key closely; keys are suitable for refitting only if indistinguishable from new, as any indentation may indicate the onset of wear.

Split pins -

Locking devices – Split pins -

Always fit new split-pins of the correct size for the hole in the bolt or stud. Do not slacken back nut to enter split-pin.

Parts & tools for this job For 2002 MG TF

Links open Amazon search results in a new tab. As an Amazon Associate I earn from qualifying purchases.