Idea Factory Service Manual (2003-2012): Heating, air conditioning and auxiliary units
General
Maintenance
Diagnostics
Engine
Transmission
Brakes
Steering & suspension
Heating & A/C
Electrical
Body & interior
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
- 15Heating, air conditioning and auxiliary unitsHeating, air conditioning and auxiliary units: Sections
Climate control - miscellaneous16 pages
- Introduction - CLIMATE CONTROL - MISCELLANEOUS
- Introduction - CLIMATE CONTROL - MISCELLANEOUS
- (DUPLEX) supply and return PIPE between engine and heater - R.R.
- Purifying filter (antipollen) filter element - replace
- AIR INTAKE DUCT on climate control unit - R.R.
- Under-facia air ducts r r
- Centre air outlet on facia one lh or rh r r
- L/h or r/h side air outlet (one) on fascia - r+r
- Air VENT for defrosting SIDE WINDOWS in dashboard (one), left or right - R.R.
- Lh or rh rear air outlet -one- r r
- Outside air temperature sensor on door mirror - r+r following electrical circuit check
- Upper mixed air temperature sensor (1), lh or rh - r r following electrical circuit check
- Upper mixed air temperature sensor (1), lh or rh r r following electrical circuit check
- Passenger compartment air temperature sensor - r+r following electrical wiring check operation
- Passanger compartment air temperature sensor r r with interfeing parts removed
- Solar sensor - r r after checking electrical system
Air conditioning casing and components35 pages
- Introduction - AIR CONDITIONING CASING AND COMPONENTS
- Check on operation of air conditioning system (temperature)
- Check activation/deactivation of climate control compressor from linear sensor
- Check on operation of air conditioning system (pressures)
- Check on climate control fan' speed control signal
- Check on operation of solar sensor
- Introduction - AIR CONDITIONING CASING AND COMPONENTS
- Air conditioner compressor - r+r - includes fluid level check and top up if necessary
- Compressor mount - r r
- Air conditioner condenser - r+r
- Air conditioner dehydrating filter/accumulator - r+r
- Pipe from compressor to air conditioner condenser - r+r
- Evaporator inlet pipe - r r
- Pipe from expansion valve to compressor - r+r
- Pipe from condenser to evaporator (expansion pipe) - r+r
- PIPE from condenser to connector for evaporator - R.R.
- Air conditioner system multi-level pressure switch - r+r
- Expansion valve (tube orifice) - r+r
- Air conditioner box - r+r
- Air conditioner housing - r r with facia disconnected
- Recirculation air intake assembly - r.r. with air conditioning casing removed
- Air conditioning HEATER/DISTRIBUTOR ASSEMBLY - R.R. with air conditioning casing removed
- Air conditioner box - dismantle and rebuild at bench
- Fan motor - r+r
- Fan motor electronic variator - r+r
- Air conditioner heater radiator - r+r with air conditioner box removed
- Air conditioner evaporator - r+r with air conditioner box removed
- AIR INTAKE and RECIRCULATION FLAP - R.R. with fan assembly removed
- Air conditioner control unit - r r
- Air conditioner control switches/button unit - r r
- Air conditioning recirculation flap control MOTOR - R.R.
- Air conditioner left hand air mixer flap control motor - r r
- Air conditioner right hand air mixer flap control motor - r r
- Air conditioning upper left air distribution flap control MOTOR (DEFROST) - R.R.
- Air conditioning upper right air distribution flap control MOTOR (DEFROST) - R.R.
Screen washers and headlamp wash/wipe14 pages
- Introduction - SCREEN WASHERS AND HEADLAMP WASH/WIPE
- Introduction - SCREEN WASHERS AND HEADLAMP WASH/WIPE
- Windscreen washer fluid reservoir (in engine bay) - r+r
- Front windscreen washer jets - r+r clean and/or position
- Front and rear screen washer pump - r+r
- Windscreen wiper blade/s - r+r
- Windscreen wiper arm/s complete with blade - r+r
- Windscreen wiper assembly - r+r or repair
- Windscreen wiper motor - r+r
- Rain sensor/dusk sensor - r.r.
- Rear window washer jet - r+r clean and/or position
- Rear wiper blade - r+r
- Rear wiper arm with blade - r+r
- Rear wiper motor - r+r