- Astra J Workshop Manual
- Preface
- General Information
- Body Hardware and Trim
- Body Repair
- Body Systems
- General Vehicle Information
- Brakes
- Diagnostic Navigation
- Driveline/Axle
- Driver Information and Entertainment
- Engine
- Technical Service Bulletins
- Inspections
- Cruise Control
- Engine Cooling
- Engine Electrical
- Engine Exhaust
- Engine control and fuel system - 1.6L (LDE, LLU), 1.8L (2H0)
- Engine control and fuel system - 2.0L Diesel (LCD, LBS, LBX, LBY)
- Engine mechanics - 1.6L (LDE, LLU), 1.8L (2H0)
- Repair Instructions
- Description and Operation
- Component Locator
- Specifications
- Special Tools and Equipment
- Diagnostic Information and Procedures
- Other Information
- Oil Leak Diagnosis
- Oil Consumption Diagnosis
- Base Engine Misfire with Abnormal Valve Train Noise
- Engine Compression Test
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Drive Belt Rumbling and Vibration Diagnosis
- Drive Belt Falls Off and Excessive Wear Diagnosis
- Cylinder Leakage Test - 1.6L LDE, LXV, 1.8L 2H0, LUW and LFH
- Crankcase Ventilation System Inspection/Diagnosis - LDE, LED, LFJ, LXV, 2H0, LUW, LFH
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Symptoms - Engine Mechanical
- Coolant in Engine Oil
- Drive Belt Tensioner Diagnosis
- Engine Noise Under Load
- Drive Belt Chirping, Squeal, and Whine Diagnosis
- Coolant in Combustion Chamber
- Oil Pressure Diagnosis and Testing
- Crankcase Ventilation System Inspection/Diagnosis - 1.6L LLU
- Cylinder Leakage Test - 1.6L LLU
- Dual Mass Flywheel Diagnosis
- Cleanliness and Care
- Separating Parts
- Replacing Engine Gaskets
- Use of Room Temperature Vulcanizing (RTV) and Anaerobic Sealant
- Tools and Equipment
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Technical Service Bulletins
- Repair Instructions - On Vehicle
- Repair Instructions - Off Vehicle
- Engine mechanics - 2.0L Diesel (LCD, LBS, LBX, LBY)
- Engine control and fuel system - 1.4L (LDD, LDU, LLU, LUH, LUJ)
- Engine control and fuel system - 1.3L Diesel
- Engine control and fuel system - 1.7L Diesel (LPL or LPV)
- Engine mechanics - 1.4L (LDD, LDU, LLU, LUH, LUJ)
- Engine mechanics - 1.3L Diesel
- Engine mechanics - 1.7L Diesel (LPL, LPV, LUB)
- HVAC
- Power and Signal Distribution
- Roof
- Safety and Security
- Seats
- Steering
- Suspension
- Transmission/Transaxle