02 · Maintenance

Warning (page 2 of 2)

Make: Alfa Romeo
Model: 145/146 Factory Service Manual
Year: 1994–1999
Section: Maintenance

Technical data and maintenanceWarning · page 2 of 2

WARNING:
THE FOLLOWING SERVICE PLAN IS VALID FROM APRIL 1997 FOR T. SPARK 16V AND 1929 TD VERSIONS.

Operations to be performed at the km shown	km x 1.000
Operations to be performed at the km shown	20	40	60	80	100	120	140	160	180
Check tyre wear and conditions	●	●	●	●	●	●	●	●	●
Check front disc brake pad wear sensor operation	●	●	●	●	●	●	●	●	●
Check rear disc brake pad coditions		●		●		●		●
Check rear drum brake seal conditions are wear			●			●			●
Check intactness of drive shaft protective bellows, power steering and steering joint caps ande check tightness of brake and fuel feed system pipes	●	●	●	●	●	●	●	●	●
Check and, if required, adjust accessory belt tension (excluding engines with automatic take-up devices)		●		●		●		●
Check counter-rotating shaft belt conditions (where relevant)		●		●				●
Inspect accessory belt conditions		●		●		●		●
Check handbrake stroke		●		●		●		●
Check/adjust tappet clearance (specific for turbodiesel engine)		●		●		●		●
Check exhaust emissions (petrol engines)		●		●		●		●
Check smokiness (tubodiesel engine)		●		●		●		●
Check evaporation system operation				●				●
Replace fuel filter (petrol engines)				●				●
Replace fuel filter (turbodiesel engine)		●		●		●		●
Replace air cleaner cartridge (petrol engines)		●		●		●		●
Replace air cleaner cartridge (turbodiesel engine)	●	●	●	●	●	●	●	●	●
Check and, if required, top up fluid levels (brakes, hydraulic clutch, power steering, windscreen washer, battery, engine coolant, etc.)	●	●	●	●	●	●	●	●	●
Check timing belt conditions				●
Replace timing belt						●
Replace counter-rotating shaft belt (where relevant)						●
Replace spark plugs					●
Check engine control system operation (by means of diagnostic socket)		●		●		●		●
Check gearbox and differential oil level				●				●
Change engine oil (*) (every 10.000 km for turbodiesel version)	●	●	●	●	●	●	●	●	●
Change engine oil filter (every 10.000 km for turbodiesel version)	●	●	●	●	●	●	●	●	●
Change brake fluid (or every 24 months)			●			●			●
Replace pollen filter (or every 12 months)	●	●	●	●	●	●	●	●	●

(*): Or every 18 months in the event of lower mileage.

‹ Prev Warning Next › Warnings

Parts & tools for this job For 1994 Alfa Romeo 145/146

Links open Amazon search results in a new tab. As an Amazon Associate I earn from qualifying purchases.