Croma Factory Service Manual (2005-2010): Heating, air conditioning and auxiliary units
General
Maintenance
Diagnostics
Engine
Transmission
Brakes
Steering & suspension
Heating & A/C
Electrical
Body & interior
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
- 15Heating, air conditioning and auxiliary unitsHeating, air conditioning and auxiliary units: Sections
- General › Auxiliary components - general remarks
Climate control - miscellaneous21 pages
- Introduction - climate control - miscellaneous
- Climate control - miscellaneous - general remarks
- Heater water supply pipe - r.r.
- Heater water return pipe - r.r.
- Climate control outside air purifying (pollen) filter - r.r.
- Climate control unit air intake duct - r.r.
- Under-facia air ducts - r.r.
- Side air duct to rear seats (one), lh or rh - r.r.
- Duct between climate control system housing and air duct to rear seats - r.r.
- Duct between climate control unit housing and air duct to rear seats (one), lh or rh - r&r
- Windscreen demister diffuser - r+r
- Top outlet (one) on fascia - r+r
- Central air vent in dashboard - r.r.
- Air vent on tunnel cover for rear seats - r.r.
- Right lower air diffuser - r+r
- Left lower air diffuser - r r
- Lh or rh rear air outlet vent (one) - r.r
- Upper mixed air temperature sensor (one), lh or rh - r.r. following electrical circuit check
- Lower mixed air temperature sensor (one), lh or rh - r.r. following electrical circuit check
- Solar sensor - r.r following electrical system check
- Air quality sensor - r.r. following electrical circuit check
Heater9 pages
- Supplementary independent heater
- Independent heater unit - r r
- Air intake sleeve for supplementary independent heater rr
- Pump for metering fuel to supplementary independent heater r r
- Intermediate fuel delivery pipe for supplementary independent heater unit r r
- Fuel intake hose to independent heater unit r r
- Supplementary independent heater exhaust pipe silencer r r
- Hose for coolant entering additional self-standing heater unit - r r
- Flexible piping for coolant exiting from additional self-standing heater unit - r r
Air conditioning casing and components52 pages
- Air conditioning casing and components
- Refrigerant circuit check
- Climate control compressor linear sensor on/off check
- Linear sensor operation check
- Sequential procedure for checking air conditioning fan resistor operation
- Sequential procedure for checking distribution actuator operation
- Solar sensor operation check
- Pollution sensor signal check
- Sequential procedure for checking recirculation actuator operation
- Sequential procedure for checking air conditioning fan operation
- Mixture actuator check
- Sequential procedure for checking mixture and distribution actuator operation
- Air conditioning system operation check (pressure)
- Iair conditioning casing and components - general remarks
- Air conditioning compressor - r+r - includes fluid level check and top up if necessary
- Air conditioning compressor - partially r.r. from the engine without disconnecting the pipes
- Air conditioning compressor support - r.r.
- Air conditioning condenser - r+r
- Air conditioning drier filter/accumulator - r+r
- Line from dehydrating - r r
- Evaporator inlet pipe - r.r.
- Tandem pipe for delivery and return to air conditioning compressor - r.r.
- Tandem supply and return pipe to the evaporator - r.r.
- Pipe from compressor to condenser and expansion valve fitting r r
- Air conditioning system multistage pressure switch - r+r
- Expansion valve (tube orifice) - r+r
- Expansion valve (orifice tube) r r with air conditioner case removed
- Air conditioning casing - r.r
- Air conditioning casing - r.r. with dashboard removed
- Recirculation air intake unit - r.r with air conditioning casing removed
- Air conditioning casing - dismantling and reassembly at the bench
- Air conditioning fan - r.r.
- Air conditioning fan - r.r. with air conditioning casing removed
- Fan motor electronic variator - r+r
- A/c fan motor resistor - r+r
- Air conditioning heater radiator - r.r.
- Air conditioning heater radiator - r+r with air conditioning casing removed
- A/c evaporator - r+r
- Air conditioning evaporator - r+r with air conditioning casing removed
- Air intake and recirculation flap - r r with air conditioning housing disconnected
- Air conditioning control unit - r.r.
- Air conditioner air distribution left flap drive motor - r&r with dashboard cross member removed
- Air conditioner mixer left flap motor - r r with instrument panel cross member taken off
- Air conditioning recirculation flap control motor - r.r
- Air contitioner distribution flap control motor - r r
- Air conditioner mixer flap control motor - r r
- Air conditioner system wiring bundle - r r or replace
- Air conditioning left air mixture flap control motor - r.r
- Air conditioning right air mixture flap control motor - r.r
- Control motor of any flap - r r with air conditioner casing removed
- Air conditioning left upper air distribution flap motor (defrost) - r.r
- Air conditioning right upper distribution flap motor (defrost) - r.r
Screen washers and headlamp wash/wipe17 pages
- Introduction - screen washers and headlamp wash/wipe
- Introduction - screen washers and headlamp wash/wipe
- Windscreen washer fluid reservoir (in engine compartment) - r+r
- Pipe in engine bay for carrying liquid to windscreen washer resevior r r
- Reservoir plug (in engine compartment) or windscreen washer fluid level sensor - check and top up if necessary
- Front windscreen washer jets - r+r clean and/or position
- Front and rear screen washer pump - r+r
- Windscreen wiper blade/s - r+r
- Windscreen wiper arm/s - r+r
- Windscreen wiper assembly - r+r or repair
- Rain/dusk sensor - r.r.
- Rear window washer jet - r+r clean and/or position
- Rear wiper arm with blade - r+r
- Rear wiper motor - r+r
- Headlamp washer jet/s - r r
- Headlamp washer system types and fittings - r r
- Headlamp washer pump - r+r