Range Rover P38
10
MAINTENANCE
NEW RANGE ROVER
6
MAINTENANCE
CHECK INTERCOOLER/RADIATOR FOR
EXTERNAL OBSTRUCTIONS
FLUSH DIESEL INTERCOOLER ELEMENT
Remove intercooler.
See FUEL SYSTEM, Repair.
Flush the intercooler using Intercooler flushing solvent
following the manufacturer’s instructions. Dry the
intercooler completely and check for damage or
deterioration. Fit a new intercooler if necessary.
CHECK CONDITION OF STEERING
INTERMEDIATE SHAFT
The intermediate shaft has a red indicator clip fitted
which must be inspected at service, or after the
vehicle has been subjected to an impact. If the clip is
not present, or is not fully seated against the clamp
plate, a new intermediate shaft must be fitted.
See
STEERING, Repair.
DEPRESSURISE ELECTRONIC AIR SUSPENSION.
Depressurise air suspension system using TestBook.
RENEW ELECTRONIC AIR SUSPENSION
COMPRESSOR INTAKE AND EXHAUST FILTERS.
Compressor inlet filter.
See FRONT SUSPENSION,
Repair.
REMOVE/REFIT AIR RESERVOIR DRAIN PLUG.
1. Clean area around reservoir drain plug.
2. Partially open drain plug, allow residual air to
escape.
3. Remove drain plug.
4. Renew air dryer if there is evidence of water in
the system.
See FRONT SUSPENSION,
Repair.
5. Fit drain plug. Tighten to
70 Nm (52 lbf.ft)
REPRESSURISE AIR SUSPENSION SYSTEM.
