Workshop Manuals Factory service & repair MG
01 Introduction02 General information03 General data, torque settings and capacities04 Maintenance05 Engine (K Series)06 Engine management (MEMS 3), fuel and emission systems07 Cooling system08 Manifolds and exhaust system09 Clutch10 Manual gearbox11 Automatic gearbox (Stepspeed Em-CVT)12 Drive shafts13 Steering14 Front suspension15 Rear suspension16 Brakes17 Restraint systems (SRS)18 Body19 Heating and ventilation20 Air conditioning21 Wipers and washers22 Electrical23 Instruments
MG TF Factory Workshop Manual (2002-2005)16 · Brakes
16 · Brakes

Pedal box assembly

Make
MG
Model
TF Factory Workshop Manual
Year
2002–2005
Section
Repairs › Pedal box assembly
BrakesPedal box assembly

PEDAL BOX ASSEMBLY

Service repair no - 70.35.03

Remove

  1. Remove bulkhead closing panel. See BODY, Repairs.
Pedal box assembly – Remove bulkhead closing panel. See BODY, Repairs.
  1. Remove 2 nuts and 1 bolt securing throttle pedal. Release pedal and position aside.
  2. Release brake light switch and position aside.
  3. Remove clip securing brake pedal push rod clevis pin and remove clevis pin.
Pedal box assembly – Remove clip securing brake pedal push rod clevis pin and remove clevis pin.
  1. With assistance, remove 3 nuts and bolts and 4 bolts securing pedal box assembly.
  2. Manoeuvre pedal box assembly over steering column and remove assembly.
Pedal box assembly – Manoeuvre pedal box assembly over steering column and remove assembly.
  1. Remove nut securing end bracket and remove end bracket and pedal.
  2. Remove return spring circlip and return spring from pivot shaft.

Refit

  1. Position return spring on pivot shaft and secure with circlip.
  2. Examine pedal bushes for wear or damage and replace as required.
  3. Position pedal and end bracket, fit nut and tighten to 22 Nm.
  4. Position pedal box assembly, manoeuvre over steering column and align to bulkhead.
  5. Fit and tighten nuts and bolts securing pedal box assembly to 22 Nm.
  6. Align brake pedal push rod, fit clevis pin and secure with clip.
  7. Position brake light switch and secure in end bracket.
  8. Position throttle pedal, fit nuts and tighten to 6 Nm.
  9. Fit bulkhead closing panel. See BODY, Repairs.

Parts & tools for this job For 2002 MG TF

Links open Amazon search results in a new tab. As an Amazon Associate I earn from qualifying purchases.