Astra G: Electrical Equipment and Instruments
Also for this vehicle: Astra, Astra F, Astra H, Astra J.
General
Maintenance
Body & interior
Heating & A/C
Steering & suspension
Brakes
Engine
Transmission
Electrical
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Description and Operation14 pages
- Introduction Division of new technical developments Astra G brochure
- Electrical equipment, instruments New file "Vehicle electronics Astra-G from model year 98 1/2"
- Techline Diagnosis software
- Techline Diagnostic plug layout
- Inspection system New developments to be noted in the case of the Astra G
- Inspection system Opel Service Manual, MY 98 1/2
- Inspection system Inspection brochure
- Inspection system Pre-delivery inspection
- Introduction Division of new technical developments Astra G brochure
- Introduction The product
- General Type and model code
- General View - saloon, 3-door
- General View - saloon, 5-door
- General View - estate, 5-door
- General Dimensions
- Specifications › Recommended torque values - Group N
- Special Tools and Equipment › Special Service Tools - Group N
- Warnings, Disclaimers, Safety › Power-Sounder (Vauxhall only)
- Other Information › Power-Sounder (Vauxhall only)
Technical Service Bulletins12 pages
- Abrasion, Wear › Interior Trim - Painted interior trim surfaces damaged by air refreshers
Inoperative - Totally, Partially2 pages
Poor Operation, Incorrect Operation6 pages
- Warning Lights, Telltale › Side airbag - Light comes on, TC 77/87
- Poor Finish › Interior Trim - Painted interior trim surfaces damaged by air refreshers
- Poor Radio Reception on vehicles with roof mounted aerial
- Technical Information › 1998 › Wiring harness repair - front wiring harness - Astra-G LHD X20DTL with fossil fuel heater element
Battery6 pages
- Repair Instructions › Immobiliser with Immobiliser Control Unit Transponder, Remove and Install
- Other Information › Battery Diagnosis
Technical Service Bulletins4 pages
- Inoperative - Totally, Partially › Alternator - Defect
Poor Operation, Incorrect Operation2 pages
- Leaks › Battery - Battery leaky
Anti-Theft Warning System-M5 pages
MID (Multi Info Display)17 pages
Repair Instructions8 pages
- Multi Info Display/Triple Info Display, Remove and Install
- Bulbs/Telltales, Replace
- Outside Temperature Sensor, Remove and Install
- Coolant Temperature Sensor, Remove and Install
- Coolant Residue Sensor, Remove and Install
- Cleaner Fluid Residue Sensor, Remove and Install
- Dynamic Oil Level Control, Remove and Install
- Program memory codes MID, TID, instrument, electronically-controlled AC
- Specifications › Program memory codes MID, TID, instrument, electronically-controlled AC
- Diagnostic Information and Procedures › Diagnostic Procedures
- Other Information › Program memory codes MID, TID, instrument, electronically-controlled AC
Schematic and Routing Diagrams › Circuit Diagram2 pages
- Technical Information › 1999 › Program memory codes MID, TID, instrument, electronically-controlled AC
TID (Triple Info Display)11 pages
- Specifications › Program memory codes MID, TID, instrument, electronically-controlled AC
- Diagnostic Information and Procedures › Diagnostic Procedures
- Other Information › Program memory codes MID, TID, instrument, electronically-controlled AC
- Schematic and Routing Diagrams › Circuit Diagram
- Technical Information › 1999 › Program memory codes MID, TID, instrument, electronically-controlled AC
Electrical Window Winders9 pages
- Diagnostic Information and Procedures › Diagnostic Procedures › Electrical Window Lifters
Technical Service Bulletins2 pages
Schematic and Routing Diagrams › Circuit Diagram2 pages
Instruments, Telltales16 pages
- Tachometer › Description and Operation › Electrical equipment, instruments Tachometer
- Temperature Gauge › Description and Operation › Electrical equipment, instruments Coolant temperature display
- Fuel Gauge › Description and Operation › Electrical equipment, instruments Fuel tank display
- Oil Pressure Instrument › Repair Instructions › Odometer Sensor, Remove and Install (F13/F13+)
- Speedometer › Description and Operation › Electrical equipment, instruments Speedometer
Wiring Harnesses25 pages
Repair Instructions18 pages
- General
- Repairable Damage
- Restrictions
- Operational steps - Brief Survey
- Step A - Observe Service Literature, Safety Regulations
- Step B1 - Prepare Special Service Tools
- Step C - Preparations, General
- Step D - Damage type 1, Repair of damaged cables
- Step E - Final Operations
- General
- Time Allowances - General
- Time Allowances
- Step B2 - Prepare materials
- Step D - Damage type 2, Replacement of plug casings
- Step D - Damage type 3, Replacement of individual spring contacts
- Step D - Damage type 4, Replacement of plug casings and individual spring contacts
- Step D - Damage type 5, Replacement of complete wiring harness plugs
- Step D - Damage type 6, Repair of damaged CAN-bus cables
- Step F - Environmental protection
- Description and Operation › Electrical equipment, instruments Bulkhead wiring harness plug
- Component Locator › Wiring Harness Plugs with Lead Ends - All Vehicles as of MY 1996
Technical Service Bulletins5 pages
Fuse Box › Repair Instructions5 pages
- Relay Frame - Engine Compartment, Remove and Install
- Fuel pump relay, Remove and Install (X 14 XE, X 16 XEL)
- Fuel Pump Relay, Remove and Install (X 18 XE1, Z 18 XE, Z 18 XEL)
- Fuel Pump Relay, Remove and Install
- Fuel Pump Relay, Remove and Install
- Fuel Pump Relay, Remove and Install
- Fuse Box, Replace
Switches, Control Unit, Relays, Ignition Lock20 pages
Repair Instructions11 pages
- Reversing Lamp Switch, Replace or Seal (F13/F13+/F17/F17+/F18)
- Parking Brake Telltale Switch, Remove and Install
- TC Switch, Remove and Install (up to MY '01)
- Bulb Control Sensor, Remove and Install / Bulb Control Sensor - Trailer Hitch, Remove and Install
- Lock Cylinder for Steering and Ignition Lock, Remove and Install
- Contact Part for Steering and Ignition Lock, Replace
- Ignition Key Solenoid Valve Release, Remove and Install
- Signal Switch, Remove and Install
- Brake Lamp Switch, Remove and Install
- Light Switch Centre, Remove and Install
- Switch for Parking Brake Telltale, Remove and Install
Steering and Ignition Lock › Technical Service Bulletins3 pages
Signal Switch3 pages
- Low Beam Range Control Unit › Schematic and Routing Diagrams › Circuit Diagram › Headlamp levelling
Headlamps, Lamps and Horn49 pages
Repair Instructions2 pages
- Technical Service Bulletins › Inoperative - Totally, Partially › Brake lights on constantly (bracket has been bent away)
Schematic and Routing Diagrams › Circuit Diagram3 pages
Turn Signal Lamps3 pages
Luggage Compartment Lamp › Repair Instructions2 pages
Bulbs11 pages
Repair Instructions10 pages
- Bulbs - Headlamp/Signal Lamp, Replace
- Side Turn Signal Lamp, Remove and Install / Bulb - Side Turn Signal Lamp, Replace
- Rear Lamp, Remove and Install / Bulbs - Rear Lamp, Replace
- License Plate Lamp, Remove and Install - Models F08/F69/F48; Bulb - License Plate Lamp, Replace - Models F08/F69/F48
- License Plate Lamp, Remove and Install - Models F35/F70; Bulb - License Plate Lamp, Replace - Models F35/F70
- Lamp - Glove Compartment, Remove and Install / Bulb - Glove Compartment Lamp, Replace
- Switch - Load/Luggage Compartment Illumination, Remove and Install
- Load/Luggage Compartment Lamp, Remove and Install; Bulb - Load/Luggage Compartment Lamp, Replace
- Interior Lamp, Remove and Install; Bulb - Interior Lamp, Replace
- Rear Reading Lamp, Remove and Install; Bulb - Rear Reading Lamp, Replace
- Technical Service Bulletins › Inoperative - Totally, Partially › Burning out of dipped beam bulb H7
Rear Lamp7 pages
Interior Lamp7 pages
- Description and Operation › Electrical equipment, instruments Lamps Interior lamps and reading lamps
Schematic and Routing Diagrams › Circuit Diagram4 pages
Licence Plate Lamp3 pages
- Servo Motor Headlamp Range Control › Repair Instructions › Headlamp Range Control Servo Motor, Remove and Install
Windscreen Wash/Wipe System, Heated Screen12 pages
- Technical Service Bulletins › Inoperative - Totally, Partially › Washer system, pump - Without function
- Schematic and Routing Diagrams › Circuit Diagram › Window washer front/rear
Rear Screen Wash/Wipe System6 pages
- Description and Operation › Electrical equipment, instruments Tailgate wiper and washer system
Schematic and Routing Diagrams › Circuit Diagram2 pages
Central Door Locking System1 page
- Diagnostic Information and Procedures › Diagnostic Procedures › Central Door Locking CDL
- Schematic and Routing Diagrams › Circuit Diagram › Central door locking
Immobiliser13 pages
Description and Operation6 pages
- Engine, engine attaching parts Electronic immobiliser with transponder
- Engine, engine attaching parts Layout in the vehicle
- Engine, engine attaching parts Function
- Engine, engine attaching parts Functional diagram
- Engine, engine attaching parts Car pass
- Engine, engine attaching parts Description of individual components Transponder
- Diagnostic Information and Procedures › Diagnostic Procedures
- Technical Service Bulletins › Electrostatic Discharging, Electric Shocks › Immobiliser control unit,
- Schematic and Routing Diagrams › Circuit Diagram
Control Unit6 pages
Repair Instructions3 pages
- Immobiliser Control Unit, Remove and Install
- Immobiliser Control Unit, Remove and Install
- Immobiliser Control Unit, Remove and Install
- Immobiliser with Immobiliser Control Unit Transponder, Remove and Install
- Immobiliser Control Unit, Remove and Install Install
- Immobiliser Control Unit, Remove and Install
- Immobiliser Control Unit Remove and Install
Description and Operation2 pages
- Technical Information › 1998 › Immobiliser Control Unit Remove and Install
Multitimer2 pages
- Repair Instructions › Multi-timer, Remove and Install
- Description and Operation › Electrical equipment, instruments Multitimer Modular mimic display
- Diagnostic Information and Procedures › Diagnostic Procedures
- Schematic and Routing Diagrams › Circuit Diagram
Central locking with ATWS (electronic)18 pages
Description and Operation6 pages
- Electrical equipment, instruments Central door locking system (CDLS) with radio remote control
- Electrical equipment, instruments Anti-theft warning system (ATWS) with cen. door lock. (CDLS) & rad. rem. cont.
- Electrical equipment, instruments Layout in the vehicle
- Electrical equipment, instruments Anti-theft warning sys. (ATWS) functions
- Electrical equipment, instruments Modular mimic display
- Electrical equipment, instruments Battery change with key type with rad. rem. cont. cent. door locking
- Diagnostic Information and Procedures › Diagnostic Procedures › Anti-Theft Warning with Central Door Locking ATWS+CDL
- Other Information › Radio remote control transmitter with new fob casing
Technical Service Bulletins2 pages
Schematic and Routing Diagrams › Circuit Diagram3 pages
- Technical Information › 1999 › Radio remote control transmitter with new fob casing
- Switches › Repair Instructions › Door Contact Switch, Remove and Install
Servo › Repair Instructions2 pages
Central Electrics › Repair Instructions3 pages
Communication / navigation9 pages