Z8 E52 Roadster (S62): 2 Repair Instructions
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data80 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Symbols Used And Information In Repair Instructions2
- Air Cleaner: Replacing Air Cleaner Element (shorten Replacement Interval Accordi
- Battery: Check Display (magic Eye); If Necessary, Recharge Battery
- Battery: Checking Acid Level, Topping Up With Distilled Water If Necessary
- Body And Underbody: Checking For Corrosion And Damage
- Body And Underbody: Checking For Corrosion And Damage - Except Cavities
- Brake And Clutch Hydraulic System: Checking Fluid Level, Topping Up If Necessary
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Changing Brake Fluid
- Changing Coolant
- Changing Differential Oil
- Changing Engine Oil And Oil Filter
- Changing Manual Transmission (gear) Oil
- Checking Clutch Drive Plate For Wear
- Checking Coolant Level In Event Of Topping Up: Checking Concentration
- Checking Handbrake Lever Travel, Adjusting According To Setting Specifications I
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness
- Coolant Hoses: Visual Inspection For Leaks
- Diagnostic Brief Test
- Diagnostic Brief Test
- Exhaust System: Checking Condition, Mounting And Inspecting For Leaks
- Fault Memory Interrogation
- Front And Rear Brake Linings: Checking Lining Thickness With Measuring Gauge
- Fuel Lines, Fuel Tank And Fuel Hoses: Visual Inspection For Routing, Condition A
- Heating/air Conditioning: Replacing Microfilter/carbon Canister (shorten Replace
- Information/warning Labels23
- Locking Systems: Checking Status And Function, Oiling Or Greasing If Necessary
- Microencapsulated Screws
- Oil Change In Manual Transmission
- Oil Change In Rear Differential
- Output Shafts: Checking Gaiters For Leaks
- Parking Brake: Checking Function, Adjusting/repairing As Prescribed
- Parking Brake: Checking Lining Thickness
- Power Steering/ride-height Control: Visual Inspection For Leaks, Checking Fluid
- Raising BMW Multi-trailer23
- Replacing Spark Plugs
- Resetting Service Interval Indicator According To Factory Specifications2
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Checking Fluid Level, Topping Up If Necessary
- Transmission (all Gears): Visual Inspection For Leaks
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Wash/wipe System: Checking Washer Fluid Reservoir And Spray Nozzle Ad
- Windscreen Washer System And Intensive Cleaning System: Checking Fluid Level, To
- BMW Running-in Inspection Incl
- BMW Engine Oil Service Incl2
- Checking/topping Up Oil Level In Rear Differential
- Oil Change In Manual Transmission
- Oil Change In Rear Differential Incl2
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (S62)968 pages
0 Engine, General13 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- BMW Engine Oil Service Incl2
- Checking Compression Of All Cylinders (M60 / M62 / M73 / S62 / M54)2
- Checking Absolute Compression Of All Cylinders
- Engine Identification2345
12 Cylinder Head With Cover574 pages
- Removing And Installing/sealing Both Cylinder Head Covers (S62)23
- Removing And Installing Left Cylinder Head (S62)234567891011121314151617181920212223
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Replacing Left Cylinder Head Gasket (M62 / S62 / N62)
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Replacing Right Cylinder Head Gasket (M62 / S62 / N62)
- Dismantling And Reassembling Cylinder Head (S62)23
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Both Cylinder Heads (S62)234567891011121314151617181920…33
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Remachining A Valve Seat (M62, S62)
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Checking A Valve Guide For Wear (M62, S62)
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Reaming A Valve Guide (M62, S62)
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Checking Cylinder Head For Water-tightness (S62)
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- Removing And Installing Right Cylinder Head (S62)2345678910111213141516171819202122
- 252345678910111213141516171819202122
- 22 Flywheel › Removing And Installing/replacing Flywheel (M62 / S62)2
- 23 Vibration Damper › Removing And Installing/replacing Vibration Damper (S62)23
- 24 Connecting Rod With Bearing › Replacing All Conrod Bearings (S62)2
25 Piston With Rings And Pin8 pages
28 V-ribbed Belt W.tens.-deflect.elemt2 pages
31 Camshaft176 pages
- Checking Camshaft Timing (S62)23456
- Replacing Left Camshafts (S62)234567891011121314151617181920…27
- Replacing Right Camshafts (S62)234567891011121314151617181920…27
- Replacing Timing Chain (S62)234
- Removing And Installing/replacing Piston For Chain Tensioner (S62)2
- Adjusting Camshaft Timing (S62)2345
- Removing And Installing/replacing Left VANOS Gear (S62)234567891011121314151617181920…25
- Removing And Installing/replacing Right VANOS Gear (S62)234567891011121314151617181920…26
- Removing And Installing/replacing Toothed Shafts Of VANOS Gear On Left (S62)2345678910111213
- Removing And Installing/replacing Toothed Shafts Of VANOS Gear On Right (S62)2345678910111213
- Removing And Installing/replacing Toothed Shafts Of VANOS Gear On Left And Right23456789101112131415161718192021
- Replacing Pulse Generator For Inlet Camshaft (S62)23
- Replacing Pulse Generator For Exhaust Camshaft (S62)2
- Replacing Throttle Potentiometer (S62)2
36 Variable Camshaft Timing122 pages
- Removing And Installing, Sealing/replacing Left VANOS Adjustment Unit (S62)2345678
- Removing And Installing, Sealing/replacing Right VANOS Adjustment Unit (S62)2345678
- Removing And Installing/replacing Left VANOS Gear (S62)234567891011121314151617181920…25
- Removing And Installing/replacing Right VANOS Gear (S62)234567891011121314151617181920…26
- Removing And Installing/replacing Toothed Shafts Of VANOS Gear On Left (S62)2345678910111213
- Removing And Installing/replacing Toothed Shafts Of VANOS Gear On Right (S62)2345678910111213
- Removing And Installing/replacing Toothed Shafts Of VANOS Gear On Left And Right23456789101112131415161718192021
- Replacing Solenoid Valves On Left VANOS Adjustment Unit (S62)234
- Replacing Solenoid Valves On Right VANOS Adjustment Unit (S62)234
- 40 Oil Supply › Checking Engine Oil Pressure2
41 Oil Pump With Filter And Drive2 pages
- 42 Oil Filter And Lines › Sealing/replacing Both Oil Lines (S62)2
- 44 Oil Cooler › Removing And Installing, Sealing Or Replacing Oil-water Heat Exchanger (S62)234
- 51 Water Pump With Drive › Removing And Installing/replacing Water Pump (M62 / S62)
- 52 Fan › Removing And Installing Or Replacing Fan Clutch (S62)
- 53 Thermostat And Connections › Removing And Installing/replacing Coolant Thermostat (S62)2
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
- 78 Emission Control, Oxygen Sensor › Replacing Oxygen Sensor (M62 / S62)
12 Engine Electrical System (S62)91 pages
0 Troubleshooting8 pages
- 12 Ignition Wires, Spark Plugs › Replacing All Spark Plugs (S62)
14 Electronic Switching Or Contr.units24 pages
- Replacing Pulse Generator (M62)2
- Replacing Pulse Generator For Inlet Camshaft (S62)23
- Replacing Pulse Generator For Exhaust Camshaft (S62)2
- Replacing Control Unit (DME) (S62)
- Replacing Right Knock Sensors (cylinder Bank 1-4) (S62)2
- Replacing Left Knock Sensors (cylinder Bank 5-8) (S62)2
- Coding Control Module (DME / DDE)
- Programming Control Unit (DME / DDE)
- Replacing Main Relay (S62)
- Removing And Installing/replacing Throttle Actuator (S62)23456
- Replacing Throttle Potentiometer (S62)2
- Note On Replacing Codable/programmable Control Units
31 Alternator With Drive And Mounting4 pages
32 Regulator6 pages
41 Starter With Mounting3 pages
- 51 Engine Wiring Loom › Replacing Wiring Harness Section For Engine (S62)234567
61 Oil Pressure-oil Temperature-oil Gauge3 pages
- 62 Coolant Temperature › Replacing Coolant Temperature Sensor (DME) (S62)
- 72 Sensor For Control Unit › Removing And Installing/replacing Throttle Actuator (S62)23456
13 Fuel System (S62)62 pages
- 0 Checking-setting Engine-emission › Checking Function Of Digital Engine Electronics (DME)
31 Fuel Pump With Drive And Line7 pages
- 32 Fuel Filter › Replacing Fuel Filter (S62)2
- 41 Speed Governor › Replacing Idle Speed Control Valve (S62)
- 51 Inj.pump, Regulator, Mixt.regulator › Replacing Fuel Pressure Regulator (S62)2
53 Injection Nozzle And Lines6 pages
54 Throttle And Operation27 pages
- Replacing Sealing Flange For Left Or Right Intake Air Manifold (S62)
- Replacing Complete Injection Pipe (S62)23
- Supplementary Work For Basic Throttle Setting (S62)234
- Performing Throttle Basic Setting (S62)234567891011121314
- Removing And Installing/replacing Throttle Body (S62)234
- Replacing Intake Hose (between Air-mass Flow Sensor And Manifold) (S62)
62 Sensor For Control Unit3 pages
63 Throttle Potentiometer, Fuel Pump Relay3 pages
- 64 Start Valves › Replacing All Fuel Injectors (S62)
- 72 Air Cleaner › Replacing Both Air Cleaner Elements (S62)
- 90 Carbon Canister Ventilation › Replacing Tank Venting Valve (S62)2
16 Fuel Supply System (S62)42 pages
0 Fuel Pick-up, Cleaning System16 pages
- Fuel Supply System E5223
- General Function Description For Fuel Supply Systems
- Draining And Filling Fuel Tank2
- Checking Fuel Tank And Tank Ventilation System For Leaks2345
- Checking Fuel Tank And Tank Venting System For Leaks With Tank Leakage Diagnosis2
- Conducting Leak Test On Fuel Tank And Tank Ventilation System
- Checking Filler Cap Pressure Relief Valve2
11 Fuel Tank With Mounting18 pages
- Removing And Installing/replacing Leak Diagnosis Pump (LDP) For Tank Leak Diagno2
- Removing And Installing/replacing Overflow Hose On Cover Pot
- Removing And Installing/replacing Partition Wall, Retaining Bracket And Wheel Ar2
- Removing And Installing/replacing Screw Cap With Rubber Seal2
- Removing And Installing/replacing Tank Cap With Cover Pot
- Removing And Installing/replacing Vent Hose From Carbon Canister To Dust Filter2
- Removing And Installing/replacing Vent Hose From Carbon Canister To Leak Diagnos
- Removing And Installing/replacing Fuel Tank23
- Removing And Installing/replacing Fuel Filler Pipe2
- Checking Filler Cap Pressure Relief Valve2
- 13 Fuel Ventilation › Removing And Installing/replacing Dust Filter With Seal Grommet
17 Cooling System (S62)24 pages
18 Exhaust System (S62)17 pages
0 Exhaust System, Complete7 pages
- 10 Mufflers, Diesel › Replacing Final Muffler23
12 Mufflers, Petrol5 pages
- 32 Exhaust Catalytic Converter › Removing And Installing/replacing Left Or Right Catalytic Converter (S62)2
21 Clutch26 pages
- 22 Engine And Gearbox Suspension › 11 Engine Suspension › Replacing Engine Mounts
23 Manual Transmission (MECH)32 pages
0 Complete Transmission18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Oil Change In Manual Transmission
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Removing And Installing Transmission (S6S 420G)234567
- Installing Exchange Transmission (S6S 420G)2
- 11 Housing With Cover › Replacing Guide Tube For Clutch Release Mechanism (S6S 420G)
12 Bearing In Housing, Sealing Ring11 pages
- 21 Transmission Shafts › Replacing Transmission Output Flange (S6S 420G)2
25 Gear Shift Mechanism (MECH) › 11 Centre Shift, Manual Transmission12 pages
26 Propeller Shaft10 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle46 pages
0 General10 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Instructions (damage To Suspension)
- Layout Of Spring Strut Shock Absorber
- 10 Front Axle Suspension › Removing And Installing Complete Front Axle (with Spring Strut Shock Absorber)234
- 11 Front Sub-frame › Replacing Front Axle Carrier23
21 Wheel Bearings And Stub Axle2 pages
- 90 Troubleshooting › Front Axle Troubleshooting
32 Steering And Wheel Alignment91 pages
0 Electronic Chassis Alignment25 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Notes
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle2
- Troubleshooting After Wheel/chassis Alignment Check On Rear Axle
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- Adjusting Toe-in And Camber On Front Axle
- Adjusting Rear Axle
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
21 Steering Arms, Tie Rods, Steer. Damper4 pages
31 Steering Column13 pages
- Replacing Upper Section Of Steering Column Trim
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing/replacing Lower Section Of Steering Spindle
- Removing And Installing Or Replacing Steering Angle Sensor
- Removing And Installing Complete Steering Column2
- Replacing Upper Steering Spindle Bearing2
- Replacing Lower Steering Spindle Bearing
- Dismantling And Assembling Complete Steering Column234
- 33 Steering Wheel › Removing And Installing Steering Wheel2
34 Steering Wheel For Airbag14 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (airbag System)234
- Removing And Installing Or Replacing Airbag Unit2
- Replacing Contact Ring (airbag)
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Procedure After Airbag Triggering As Result Of An Accident23
41 Pump And Oil Supply12 pages
- Bleeding Power Steering Unit2
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Checking Function Of Power Steering Vane Pump (Basis)2
- Removing And Installing Vane Pump For Power Steering Unit2
- Removing And Installing Or Replacing Oil Cooler/cooling Coil For Power Steering2
33 Rear Axle76 pages
0 General17 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack (vehicle Equipped With Jacking Point)2
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Rear Axle Assembly2
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Rear Differential: Assignment To Model Series
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- 17 Final Drive Mounting › Replacing All Rubber Mounts On Front And Rear Final Drive Mounts2
- 31 Rear Sub-frame › Removing And Installing Complete Rear Axle Carrier2
32 Control Arms And Struts11 pages
- Replacing Left Or Right Push Rod/integral Link2
- Removing And Installing/replacing Left Or Right Swinging Arm2
- Replacing One Upper Control Arm2
- Replacing A Guide Arm2
- Replacing A Ball Joint In Lower Steering Knuckle/wheel Carrier
- Removing And Installing / Replacing A Steering Knuckle / Wheel Carrier
- Replacing Ball Joint In Lower Steering Knuckle/wheel Carrier (wheel Carrier Remo
- 33 Axle Mounting › Replacing Two Rubber Mounts For Rear Axle Carrier2
52 Shock Absorber10 pages
- Information On Replacing Shock Absorbers
- Layout Of Spring Strut Shock Absorber
- Removing And Installing Rear Left Or Right Spring Strut Shock Absorber
- Replacing Rear Left Or Right Spring Strut Shock Absorber2345
- Replacing Rear Left Or Right Thrust Bearing For Spring Strut/shock Absorber
- Rear Axle Troubleshooting
53 Springs With Suspension2 pages
- 55 Stabiliser Bar › Removing And Installing / Replacing Rear Stabilizer
- 90 Troubleshooting › Rear Axle Troubleshooting
34 Brakes70 pages
0 Brake Testing And Bleeding13 pages
- General Data23
- Checking Brakes On Test Stand
- Checking Thickness Of Brake Lining
- Parking Brake Function Check
- Checking Brake Booster (low-pressure Test)
- Replacing Fluid In ABS/ASC-T Brake System2
- Bleeding Brake System With DSC2
- Checking Parking Brake Setting (for Inspection)
- Checking Service Brake: High- And Low-pressure Tests
11 Front Brakes12 pages
- Configuration Of Floating Caliper (front)
- Removing And Installing/replacing Brake Linings On Both Front Disk Brakes234
- Removing And Installing/replacing Both Front Brake Disks2
- Removing And Installing/replacing Left Or Right Front Brake Caliper2
- Overhauling Left Or Right Front-brake Caliper (brake Caliper Removed)23
51 Mechanical-hydraulic Components5 pages
- 90 Troubleshooting › Troubleshooting The Brake System234
35 Pedals13 pages
21 Brake Pedal With Linkage3 pages
- 31 Clutch Pedal With Linkage › Removing And Installing Or Replacing Clutch Pedal
40 Accelerator Pedal Actuation2 pages
36 Wheels With Tyres19 pages
37 Integrated Suspension Systems5 pages
14 Electrical Components2 pages
41 Body (ROADST)132 pages
0 Body55 pages
- Contents Of Body, General2
- Bonding Aluminium Parts23
- Bonding Plastic Parts
- Corrosion Protection2
- General Cementing Instructions
- Grinding Aluminum Parts
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Opening Adhesive Bonds
- Opening Weld Joints
- Quality Standard
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Sectional Repair Of Extruded Aluminium Sections With Repair Elements2
- Stamping Vehicle Identification Number E522
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding Aluminum Parts (E52 Only)2
- Workshop Equipment2
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- General Instructions On Painting
11 Support Members26 pages
- Replacing Complete Engine Carrier With Wheel Arch At Front Left Or Right2345
- Replacing Front Left Or Right Engine Carrier (part Replacement Before Front Axle2
- Replacing Complete Front Left Or Right Wheel Arch23
- Replacing Complete Rear End2345
- Replacing Complete Left Or Right Side Frame (with A- And B-pillars)234567
- Replacing Complete Rear Trim Panel (part Replacement Piece After Rear Axle)234
- 12 Luggage Compartment Floor › Replacing Complete Rear End2345
21 Side Frame And Door Pillars10 pages
- 32 Dash Cowl › Replacing Complete Window Frame23
51 Front Side Doors3 pages
- 61 Front Lid › Removing And Installing Hood Lid
51 Body Equipment (ROADST)135 pages
16 Mirrors-covers-ashtrays-shelves-trays18 pages
- Cementing Of Mirror Base2
- Replacing Left Or Right Outside Mirror Housing23
- Removing And Installing/replacing Mirror On Left Or Right Front Door
- Replacing Mirror Glass For Rear-view Mirror (on Front Door)
- Removing And Installing Or Replacing Interior Rearview Mirror2
- Removing And Installing/replacing Left Or Right Sun Visor
- Removing And Installing Center Console2
- Removing And Installing/replacing Finisher For Storage Tray
- Removing And Installing Trim For Center Console
- Replacing Trim For Center Console
- Removing And Installing Rear Storage Compartment2
- Removing And Installing Right Glovebox With Housing
- 17 Lids › Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
21 Front Door Locks, Handles, Fittings14 pages
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock In Left Or Right Front Door23
- Removing And Installing/replacing Complete Lock Cylinder
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo2
- Removing And Installing/replacing Cover On Outside Handle
- Removing And Installing Cover On Outside Handle With Locking Cylinder
- Removing And Installing/replacing Outside Handle And Lock Actuation Of Left Or R2
- Removing And Installing/replacing Inner Door Opener On Left Or Right Front Door
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door
31 Front And Rear Window22 pages
- 33 Front Electrically Operated Windows › Removing And Installing Power Window Regulator In Left Or Right Front Door2
- 44 Roof Trim Panel › Removing And Installing/replacing Trim For Headliner At Front (cowl At Top)2
45 Instrument Cluster Trim Panel14 pages
- Removing And Installing Trim Panel For Speaker On Left
- Removing And Installing/replacing Left Knee Protection
- Removing And Installing Trim For Instrument Panel (lower Section)2
- Replacing Trim For Instrument Panel (lower Section)
- Removing And Installing Trim For Upper Section Of Instrument Panel2
- Replacing Trim For Upper Section Of Instrument Panel23
- Removing And Installing/replacing Speaker Cover On Left
- Removing And Installing/replacing Speaker Cover On Right
- Removing And Installing/replacing Trim For Pedal Assembly
- Replacing Instrument Cluster Trim Panel
47 Floor-lugg.comp.-eng.comp.tr.panels12 pages
- Removing And Installing/replacing Rear Left Or Right Side Trim Panel
- Removing And Installing/replacing Panel For Convertible Top Compartment At Top
- Removing And Installing/replacing Panel For Rollover Protection On Left Or Right
- Removing And Installing/replacing Trim On Panel For Rollover Protection On Left
- Removing And Installing/replacing Left Or Right Entrance Cover Strip
- Removing And Installing/replacing Finishing Strip At Front Left Or Right Entranc
- Removing And Installing/replacing Trim On B-pillar On Left Or Right
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Panel For Trunk Separating Wall
- Removing And Installing/replacing Left (or Right) Trunk Wheel Arch Trim (bottom)
- Removing And Installing/replacing Trunk Trim Panel On Left Side Panel
- Removing And Installing/replacing Trunk Trim Panel On Right Side Panel
- 48 Front Lid Insulation Lining › Removing And Installing/replacing Acoustic Insulation On Left Or Right Front Doo23
71 Gaskets-seals, Loose Body Components6 pages
- Removing And Installing/replacing Soundproofing In Firewall (top)
- Removing And Installing/replacing Top Air Duct
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover2
- Removing And Installing/replacing Partition Wall For Equipment Compartment On Le
- Removing And Installing/replacing Partition Wall For Equipment Compartment On Ri
52 Seats › 16 Front Seat, Sports, Electric9 pages
- Additional Work In Event Of Faulty Longitudinal Adjustment Drive2
- Removing And Installing/replacing Gearing For Longitudinal Seat Adjustment On Le2
- Removing And Installing Left Or Right Front Seat2
- Removing And Installing/replacing Outer Cover On Left Or Right Front Door
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Removing And Installing Or Replacing Front Left Or Right Headrest
54 Slide-tilt Sunroof And Convertible Top (ROADST)87 pages
- 10 Sunroof › Repair Instructions For Bonded Seals23
21 Hardtop25 pages
- Notes On Rear Window Cementing (hard Top)234
- Fitting Hard Top (with Settings At Fastening, B-pillar)2
- Removing Hard Top2
- Installing Hard Top (refitting As Before Without Adjusting Height)
- Replacing Rubber Seal On Hard Top At Front2345
- Replacing Rubber Seal On Hard Top At Rear2
- Removing And Installing/adjusting Rear Hard Top Catch
- Removing And Installing/replacing Mounting Plate, Front Left Or Right2
- Removing And Installing/replacing Panel, Rear Window Frame, Bottom
- Removing And Installing/replacing Molded Roof Lining On Hard Top
- Replacing Rear Window For Hard Top234
34 Motor-operated Convertible Top50 pages
- Checking Convertible Top
- Mounting Of Hydraulic Components2
- Opening Convertible Top In Event Of A Technical Fault
- Repair Instructions For Hydraulic System Of Convertible Top And Convertible Top23
- Topping Up/extracting Fluid, Checking Fluid Level2
- Removing And Installing/replacing Hydraulic Unit For Convertible Top Drive23
- Removing And Installing/replacing Hydraulic Cylinder For Convertible Top23
- Removing And Installing/replacing Hydraulic Lines To Convertible Top23
- Adjusting EH Convertible Top2
- Removing And Installing Complete Convertible Top2345
- Replacing Convertible Top Fabric2345
- Replacing Convertible Top Fabric2345
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
61 General Electrical System169 pages
0 Troubleshooting25 pages
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Removing And Installing Or Replacing Headlining In Convertible Top23
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
13 Plug Connection, Terminal, Fuse Box49 pages
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
20 Battery15 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
31 Switch26 pages
- Removing And Installing/replacing Turn Indicator/dimmer Stalk
- Removing And Installing/replacing Cruise Control Switch
- Removing And Installing Steering Lock/ignition Starter Switch
- Removing And Installing/replacing Light Switch
- Removing And Installing/replacing Stalk For Steering Column Adjustment
- Removing And Installing/replacing Stalk For Windshield Wipers
- Removing And Installing/replacing Dimmer Switch For Instrument Panel Lighting
- Removing And Installing/replacing Switch For Rear Fog Light
- Removing And Installing/replacing Switch For Hazard Warning Lights
- Removing And Installing/replacing Switch For Tire Pressure Warning
- Removing And Installing / Replacing Switch For Left Or Right Seat Heating
- Replacing Rocker Switch For Power Window Operation
- Replacing Switch Combination For Seat Adjustment
- Removing And Installing/replacing Switch For Automatic/dynamic Stability Control
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror
- Replacing Switch For Outside Mirror
- Removing And Installing/replacing Driving Dynamics Switch
- Replacing Clutch Switch For Starter Interlock
- Replacing Clutch Switch For Cruise Control System
- Replacing Brake-light Switch2
- Removing And Installing/replacing Temperature Switch For Heated Windshield Spray
- Removing And Installing/replacing Switch For Convertible Top Operation
- Removing And Installing / Replacing Switch For Central Locking System
- Carrying Out Steering Angle Sensor Adjustment
36 Relays2 pages
61 Windscreen Wipers13 pages
- Adjusting Left Or Right Windscreen Wiper23
- Checking/adjusting Approach Angle Of Windshield Wiper Arms On Front Windscreen2
- Replacing Left Or Right Windshield Wiper Arm
- Removing And Installing/replacing Both Windshield Wiper Arms2
- Replacing Windshield Wiper Motor2
- Removing And Installing Complete Mounting Bracket For Windshield Wiper System (w2
- Replacing Bracket For Windshield Washer System
- 66 Windscreen Washer System › Removing And Installing/replacing A Jet Nozzle In Windshield Washer System
- 67 Headlight Washer System › Removing And Installing/replacing Spray Nozzles For Left Or Right Headlight Clea
62 Instruments17 pages
11 Instrument Cluster7 pages
- Removing And Installing/replacing Remote Thermometer (temperature Gauge)
- Removing And Installing/replacing Speedometer
- Removing And Installing/replacing Revcounter/clock
- Removing And Installing/replacing Fuel Gauge
- Removing And Installing/replacing Indicator Lamp (in Instrument Cluster, Left)
- Removing And Installing/replacing Indicator Lamp (in Instrument Cluster, Right)
- Removing And Installing/replacing Indicator Lamp (in Instrument Cluster, Middle)
21 Instrument Carrier10 pages
- Replacing Instrument Cluster Trim Panel
- Removing And Installing/replacing Dimmer Switch For Instrument Panel Lighting
- Removing And Installing/replacing Remote Thermometer (temperature Gauge)
- Removing And Installing/replacing Speedometer
- Removing And Installing/replacing Revcounter/clock
- Removing And Installing/replacing Fuel Gauge
- Removing And Installing/replacing Indicator Lamp (in Instrument Cluster, Left)
- Removing And Installing/replacing Indicator Lamp (in Instrument Cluster, Right)
- Removing And Installing/replacing Indicator Lamp (in Instrument Cluster, Middle)
- Removing And Installing Entire Instrument Cluster
63 Lights43 pages
14 Clearance And Side Marker Lamps7 pages
- Removing And Installing/replacing Light Module For Left Additional Turn Signal L
- Removing And Installing/replacing Light Module For Right Additional Turn Signal
- Replacing Reflector With Bulb For Left Auxiliary Turn Indicator Light
- Replacing Reflector With Bulb For Right Auxiliary Turn Indicator Light
- Removing And Installing/replacing Reflecting Tail Light On Rear Bumper23
- 25 Brake Lights › Removing And Installing/replacing Additional Stop Light
- 26 Licence Plate Lights › Removing And Installing/replacing Both License Plate Lights
31 Interior Lights6 pages
- Removing And Installing/replacing Lighting Plate (above Inside Rearview Mirror)
- Removing And Installing/replacing Left Or Right Interior Light
- Removing And Installing/replacing Footwell Light
- Removing And Installing Or Replacing Door Warning Light
- Removing And Installing/replacing Complete Engine Compartment Light
- Removing And Installing/replacing Luggage Compartment Light
99 Light Bulbs11 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For Left Or Right High-beam Headlight
- Replacing Bulb For Left Xenon Headlight2
- Replacing Bulb For Right Xenon Headlight
- Replacing Bulb For Side Marker Lamp, Front Left
- Replacing Bulb For Side Marker Lamp, Front Right
- Replacing Bulb For Left Or Right License-plate Light
- Replacing Light Bulb For Left Or Right Interior Light
- Replacing Bulb For Engine Compartment Light
64 Heating And Air Conditioning62 pages
11 Heater With Operation21 pages
- Installing Servodrive
- Removing And Installing/replacing Heater (A/C Control)23456
- Removing And Installing/replacing Blower For Heater/air Conditioner2
- Removing And Installing/replacing Resistor For Heater Blower2
- Removing And Installing / Replacing Auxiliary Water Pump
- Replacing Water Valve For Heater
- Replacing Heating Controls
- Removing And Installing Heater Control
- Replacing Servodrive Of Fresh Air Flap
- Replacing Servodrive Of Recirculated Air Flaps
- Replacing Servodrive Of Ventilation Flaps
- Replacing Servodrive Of Stratification Flap
- Replacing Servodrive Of Footwell Flap
- Replacing Servodrive Of Defrosting Flaps
- 31 Microfilter › Replacing Microfilter For Interior Ventilation
50 Air Conditioning System17 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Removing And Installing/replacing Pressure Fan For Condenser
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
51 AC Housing-evaporator, Switching Elemts4 pages
53 Condenser And Dryer With Lines9 pages
- Removing And Installing Cassette (condenser For Air Conditioner)23
- Removing And Installing/replacing Pressure Fan For Condenser
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
- Notes On Replacing Drier Bottle Or Drier Insert
- Removing And Installing / Replacing Drier Flask For Air Conditioner
- Removing And Installing Or Replacing Condenser For Air Conditioner
65 Audio, Navigation And Information System24 pages
12 Stereo Radio, Amplifier4 pages
- Removing And Installing/replacing Bass Speaker (under Left Or Right Front Door)
- Removing And Installing/replacing Mid-range Speaker (behind Left Or Right Front
- Removing And Installing/replacing Tweeter/mid-range Speaker (left Or Right Front
- Removing And Installing/replacing Amplifier (under Left Front Seat)
- 20 Aerial-antenna › Removing And Installing/replacing Antenna (radio)2
24 Rear Window Aerial-antenna3 pages
75 Anti-theft Alarm System2 pages
77 Airbag Trigger Device, Diagnosis Unit4 pages
- 81 On-board Computer › Removing And Installing/replacing External Temperature Sensor
67 Electrical Drives6 pages
72 Parts - Accessories (Body)40 pages
12 Airbag Generator-airbag Unit For Pass25 pages
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Airbag System Components2
- Safety Regulations For Handling Components With Gas Generators2
- Airbag System
- Deactivation Of Airbags234
- Procedure After Airbag Triggering As Result Of An Accident23
- Safety Regulations For Handling Airbag Modules, Airbag Components And Pyrotechni
- Scrapping Vehicles With Passenger Airbag And Pyrotechnic Belt Tensioners
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing/replacing Airbag Module On Passenger Side2
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door2
84 Communication Systems8 pages
11 Transceiver, Handset-support, Card Reade5 pages
- Removing And Installing/replacing Eject Box
- Removing And Installing/replacing Interface For D-Network Car Phone
- Removing And Installing/replacing Hands-free Microphone
- Removing And Installing/replacing Line Compensator (cellular Phone)
- Removing And Installing/replacing Control Unit For Hands-free Facility
- 50 Antenna › Removing And Installing/replacing Telephone Antenna
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages