- Astra F Workshop Manual
- General Vehicle Information
- A Maintenance, Body and Chassis Sheet Metal Parts, Frame
- B Paint
- C Body Equipment
- D Heating, Ventilation, Air Conditioning (HVAC)
- E Front Wheel Suspension, Wheels and Tyres
- F Rear Axle and Rear Wheel Suspension
- H Brakes
- J Engine and Engine Aggregates
- Repair Instructions
- Description and Operation
- Diagnostic Information and Procedures
- Other Information
- Technical Service Bulletins
- Technical Information
- OHC Petrol Engine
- DOHC Petrol Engine
- Diesel Engine
- Repair Instructions
- Description and Operation
- Diagnostic Information and Procedures
- Technical Service Bulletins
- General
- Repair Instructions
- OHC, turbo, diesel engine, engine number Engine Number
- Idle Speed, Check and Adjust
- Upper Idle Speed, Check and Adjust
- Cold Start Acceleration, Check and Adjust
- Start of Supply, Check and Adjust
- Fuel Consumption, Measure
- Compression, Check
- Pressure Loss, Check
- Oil Temperature, Measure
- Oil Pressure, Check
- Oil Consumption, Measure
- Charge Pressure, Check
- Timing, Check and Adjust
- Valve Clearance, Check and Adjust
- Cooling System Cooling System, Top up and Bleed
- Cooling System, Check for Leaks
- Coolant Temperature, Measure with Closed Cooling System
- Engine without Transmission, Remove and Install (Version without Pot Flywheel)
- Engine with Transmission, Remove/Install (Version with Pot Flywheel)
- Engine, Repair Using Short-block
- Immobiliser with transponder control unit, immobiliser, remove and install Install
- Accelerator Pedal, Remove and Install
- OHC Diesel Engine No. (17D, 17DR and X17 DTL)
- Checking and Adjusting Operations - Alternator V-belt Tension, Check
- Alternator V-belt Tension, Adjust
- Idle Speed, Check and Adjust (Bosch Fuel Injection Pump, 17 DR and X 17 DTL)
- Upper Idle Speed, Check and Adjust (17 DR, X 17 DTL)
- Feed Start, Check and Adjust
- Fuel Consumption, Measure
- Compression, Check
- Pressure Loss, Check
- Oil Temperature, Measure
- Oil Pressure, Check
- Oil Consumption, Measure
- Charge Pressure, Check (X 17 DTL)
- 1st Cylinder TDC, Adjust
- Timing, Check
- Timing, Adjust
- Toothed Belt Tension, Check (17 DR, X 17 DTL)
- Toothed Belt Tension, Adjust (17 DR and X 17 DTL)
- Air Cleaner Casing, Remove and Install, Air Cleaner Casing, Air Duct
- Resonator, Remove and Install
- Alternator V-belt, Remove and Install on Engine Timing Side
- Toothed Belt Tension Roller, Remove and Install (17 DR and X 17 DTL)
- Toothed Belt Guide Roller, Remove and Install
- Rear Toothed Belt Cover, Remove and Install
- Cooling System, Top Up and Bleed
- Cooling System, Check for Leaks
- Engine with Transmission, Remove and Install (Version X 17 DTL with Pot Flywheel)
- Engine, Repair using Short Block
- Mechanical Injection System - General Repair Instructions
- Idle Speed Increase Pressure Unit, Remove and Install (Bosch Fuel Injection Pump 17 DR and X 17 DTL)
- Injection Pump, Remove and Install
- Charge Air Pipe for Turbocharging System (X17DTL), Remove and Install
- Intercooler, Remove and Install
- Turbocharger, Remove and Install
- Immobiliser with Immobiliser Control Unit Transponder, Remove and Install
- Solenoid Valve Control Unit, Remove and Install
- Accelerator Pedal, Remove and Install
- Conversion for Vehicles with X17DTL Engines in Conjunction with Trailer Hitch
- Description and Operation
- Component Locator
- Specifications
- Special Tools and Equipment
- Warnings, Disclaimers, Safety
- Diagnostic Information and Procedures
- Other Information
- Technical Service Bulletins
- Technical Information
- Seals and Seal Rings
- Ribbed V-Belt
- Fuel Pump
- Engine Damping Block
- Oil Circulating
- Timing Gear Case
- Cylinder Block
- Cylinder Head
- Vacuum Pump
- Auxiliary aggregate drive
- Fuel Injection Systems
- Engine Electrics
- Cooling System
- Turbo-Charging
- K Clutch and Transmission
- L Fuel and Exhaust System
- M Steering
- N Electrical Equipment and Instruments
- R Accessories