Privacy Policy
Donate and help keep workshop manuals freely available.
Other Vauxhall Workshop Service and Repair Manuals
Other Makes
Astra F Workshop Manual
General Vehicle Information
A Maintenance, Body and Chassis Sheet Metal Parts, Frame
B Paint
C Body Equipment
D Heating, Ventilation, Air Conditioning (HVAC)
E Front Wheel Suspension, Wheels and Tyres
F Rear Axle and Rear Wheel Suspension
H Brakes
J Engine and Engine Aggregates
Repair Instructions
Description and Operation
Diagnostic Information and Procedures
Other Information
Technical Service Bulletins
Technical Information
OHC Petrol Engine
DOHC Petrol Engine
Diesel Engine
Repair Instructions
Description and Operation
Diagnostic Information and Procedures
Technical Service Bulletins
General
Repair Instructions
OHC, turbo, diesel engine, engine number Engine Number
Idle Speed, Check and Adjust
Upper Idle Speed, Check and Adjust
Cold Start Acceleration, Check and Adjust
Start of Supply, Check and Adjust
Fuel Consumption, Measure
Compression, Check
Pressure Loss, Check
Oil Temperature, Measure
Oil Pressure, Check
Oil Consumption, Measure
Charge Pressure, Check
Timing, Check and Adjust
Valve Clearance, Check and Adjust
Cooling System Cooling System, Top up and Bleed
Cooling System, Check for Leaks
Coolant Temperature, Measure with Closed Cooling System
Engine without Transmission, Remove and Install (Version without Pot Flywheel)
Engine with Transmission, Remove/Install (Version with Pot Flywheel)
Engine, Repair Using Short-block
Immobiliser with transponder control unit, immobiliser, remove and install Install
Accelerator Pedal, Remove and Install
OHC Diesel Engine No. (17D, 17DR and X17 DTL)
Checking and Adjusting Operations - Alternator V-belt Tension, Check
Alternator V-belt Tension, Adjust
Idle Speed, Check and Adjust (Bosch Fuel Injection Pump, 17 DR and X 17 DTL)
Upper Idle Speed, Check and Adjust (17 DR, X 17 DTL)
Feed Start, Check and Adjust
Fuel Consumption, Measure
Compression, Check
Pressure Loss, Check
Oil Temperature, Measure
Oil Pressure, Check
Oil Consumption, Measure
Charge Pressure, Check (X 17 DTL)
1st Cylinder TDC, Adjust
Timing, Check
Timing, Adjust
Toothed Belt Tension, Check (17 DR, X 17 DTL)
Toothed Belt Tension, Adjust (17 DR and X 17 DTL)
Air Cleaner Casing, Remove and Install, Air Cleaner Casing, Air Duct
Resonator, Remove and Install
Alternator V-belt, Remove and Install on Engine Timing Side
Toothed Belt Tension Roller, Remove and Install (17 DR and X 17 DTL)
Toothed Belt Guide Roller, Remove and Install
Rear Toothed Belt Cover, Remove and Install
Cooling System, Top Up and Bleed
Cooling System, Check for Leaks
Engine with Transmission, Remove and Install (Version X 17 DTL with Pot Flywheel)
Engine, Repair using Short Block
Mechanical Injection System - General Repair Instructions
Idle Speed Increase Pressure Unit, Remove and Install (Bosch Fuel Injection Pump 17 DR and X 17 DTL)
Injection Pump, Remove and Install
Charge Air Pipe for Turbocharging System (X17DTL), Remove and Install
Intercooler, Remove and Install
Turbocharger, Remove and Install
Immobiliser with Immobiliser Control Unit Transponder, Remove and Install
Solenoid Valve Control Unit, Remove and Install
Accelerator Pedal, Remove and Install
Conversion for Vehicles with X17DTL Engines in Conjunction with Trailer Hitch
Description and Operation
Component Locator
Specifications
Special Tools and Equipment
Warnings, Disclaimers, Safety
Diagnostic Information and Procedures
Other Information
Technical Service Bulletins
Technical Information
Seals and Seal Rings
Ribbed V-Belt
Fuel Pump
Engine Damping Block
Oil Circulating
Timing Gear Case
Cylinder Block
Cylinder Head
Vacuum Pump
Auxiliary aggregate drive
Fuel Injection Systems
Engine Electrics
Cooling System
Turbo-Charging
K Clutch and Transmission
L Fuel and Exhaust System
M Steering
N Electrical Equipment and Instruments
R Accessories