Astra J: Suspension
Also for this vehicle: Astra, Astra F, Astra G, Astra H.
General
Body & interior
Brakes
Diagnostics
Transmission
Engine
Heating & A/C
Steering & suspension
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Front Suspension19 pages
Repair Instructions10 pages
- Steering Knuckle Replacement
- Lower Control Arm Replacement
- Shock Absorber Disposal
- Wheel Stud Replacement
- Stabilizer Shaft Link Replacement
- Front Wheel Bearing and Hub Replacement
- Stabiliser Shaft Replacement
- Strut, Strut Component, or Spring Replacement
- Front Lower Control Arm Bush Replacement
- Wheel Stud Replacement
- Strut Assembly Removal and Installation
- Description and Operation › Front Suspension Description and Operation
- Component Locator › Front Suspension Components
- Specifications › Fastener Tightening Specifications
- Special Tools and Equipment
Technical Service Bulletins6 pages
Inoperative - Totally, Partially2 pages
- Poor Operation, Incorrect Operation › Diesel Engines - Prevention of vacuum pump damage while unloading vehicle from car carrier
- Warning Lights, Telltale › ABS/ESP Telltale Illuminates - Several Trouble Codes are set
- Chip, Crack › Diesel Engines - Prevention of vacuum pump damage while unloading vehicle from car carrier
- Corrosion, Rust, Dirt › Ball joint transverse link - Stud difficult to remove
Rear Suspension18 pages
Repair Instructions14 pages
- Equalizer Beam Link Replacement - Left Side
- Equalizer Beam Link Replacement - Right Side
- Equalizer Beam Centre Link Replacement
- Rear Axle Replacement - Watt Linkage
- Shock Absorber Disposal
- Wheel Stud Replacement
- Rear Spring Replacement
- Rear Spring Insulator Replacement
- Equalizer Beam Center Link Heat Shield Replacement
- Rear Wheel Bearing and Hub Replacement - Disc Brakes
- Equalizer Beam Support Replacement
- Shock Absorber Replacement
- Rear Axle Bracket Replacement
- Rear Axle Bushing Replacement - Watt Linkage
- Description and Operation › Rear Suspension Description and Operation - Watt Linkage
- Component Locator › Rear Suspension Components - Watt Linkage
- Specifications › Fastener Tightening Specifications
- Special Tools and Equipment
- Technical Service Bulletins › Leaks › Rear shock absorber - leakage
Electronic Suspension Control22 pages
Repair Instructions7 pages
- Electronic Suspension Control Module Replacement
- Electronic Suspension Front Vertical Accelerometer Replacement - Upper
- Electronic Suspension Control Module Bracket Replacement
- Electronic Suspension Rear Position Sensor Replacement
- Electronic Suspension Front Vertical Accelerometer Replacement - Lower
- Sport Set-Up Mode Switch Replacement
- Tour Set-Up Mode Switch Replacement
- Description and Operation › Electronic Suspension Control Description and Operation
- Specifications › Fastener Tightening Specifications
Diagnostic Information and Procedures › Miscellaneous6 pages
- Schematic and Routing Diagrams › Electronic Suspension Control Schematics
Suspension General Diagnosis21 pages
- Special Tools and Equipment
Diagnostic Information and Procedures › Miscellaneous10 pages
Other Information10 pages
- Technical Service Bulletins › Leaks › Rear shock absorber - leakage
Tire Pressure Monitoring15 pages
Repair Instructions2 pages
- Description and Operation › Tire Pressure Monitor Description and Operation
- Specifications › Fastener Tightening Specifications
- Special Tools and Equipment
Diagnostic Information and Procedures › Miscellaneous5 pages
- Schematic and Routing Diagrams › Tire Pressure Monitoring System Schematics
Tires and Wheels31 pages
Repair Instructions2 pages
- Description and Operation › P-Metric Sized Tires Description
- Diagnostic Information and Procedures › Miscellaneous › Radial Tire Lead/Pull Correction
Other Information17 pages
- Radial Tire Lead/Pull Correction
- Contents - Wheels and Tyres as of Model Year 2011
- Introduction
- Identification of Rims and Tyres
- Changing the tyres and wheel trims
- Fitting winter tyres
- Retrofitting wheel/tyre combinations
- Compulsory make of tyre
- Different tyre types
- RunFlat tyres
- Procedure for fitting spare wheel in event of puncture
- Tyre with specified direction of running
- Balancing weights which contain no heavy metals
- Structural Wheels
- Tyre filling system
- Tyre pressure monitoring system
- Condition of tyres
Technical Service Bulletins5 pages
- Abrasion, Wear › Wheel bolts - Damages
- Inoperative - Totally, Partially › Diesel Engines - Prevention of vacuum pump damage while unloading vehicle from car carrier
- Poor Operation, Incorrect Operation › Diesel Engines - Prevention of vacuum pump damage while unloading vehicle from car carrier
- Loose, Missing, Broken › Wheel bolts - Damages
- Chip, Crack › Diesel Engines - Prevention of vacuum pump damage while unloading vehicle from car carrier
Wheel Alignment9 pages
Description and Operation2 pages