Astra F: Electrical Equipment and Instruments
Also for this vehicle: Astra, Astra G, Astra H, Astra J.
General
Maintenance
Body & interior
Heating & A/C
Steering & suspension
Brakes
Engine
Transmission
Electrical
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Warnings, Disclaimers, Safety2 pages
- Labour Time Allowances › Alteration of TIC13 "Time Allowances, New Technical Features Model Year 1995"
- Diagnostic Information and Procedures › Diagnostic Procedures › Excerpt from Circuit Diagram Astra- F
Other Information2 pages
Technical Service Bulletins5 pages
- Technical Information › 1994 › Alteration of TIC13 "Time Allowances, New Technical Features Model Year 1995"
Battery12 pages
Diagnostic Information and Procedures › Diagnostic Procedures4 pages
Technical Service Bulletins8 pages
- Inoperative - Totally, Partially › Alternator - Defect
Poor Operation, Incorrect Operation2 pages
- Loose, Missing, Broken › Voltage loss in vehicle electrical system due to inadequate contact with battery terminals
- Warning Lights, Telltale › Battery telltale is on and/or starting problems
- Leaks › Battery - Battery leaky
Anti-Theft Warning System-M132 pages
Description and Operation10 pages
- Anti-theft Warning System (ATWS)
- Illustration - Location in Vehicle
- Circuit Diagram
- Anti-theft Warning System (Corsa-B/Tigra, Astra-F)
- Glass Breakage Monitor, Deactivate
- Open Tailgate with Activated ATWS
- Rear Scren Monitor
- Block Diagram
- Integrated Immobiliser (Vehicles With Immobiliser with Transponder)
- Actuator Test
- Circuit Diagram
Component Locator2 pages
- Labour Time Allowances
Diagnostic Information and Procedures105 pages
Diagnostic Procedures104 pages
- Introduction (Anti-theft Warning System - Astra-F, Corsa-B, Tigra)
- The Opel/Vauxhall Checking System
- General Instructions
- Safety Measures
- Checking Equipment
- Location of Components in Astra-F (Estate as Example)
- Block Diagram
- System Description
- System Versions
- Operation
- Features Specific to this System
- Checking with Diagnostic Switch KM-640
- Types of Fault
- Diagnosis with TECH 1
- TECH 1, Connect to Vehicle
- Abbreviations, Definitions
- F0:DATA LIST - Test step 01 BATTERY VOLTAGE
- F0:DATA LIST - Test step 02 IGNITION STATUS
- F0:DATA LIST - Test step 03 DOORS SWITCH (Astra-F)
- F0:DATA LIST - Test step 04 ENGINE HOOD SW.
- F0:DATA LIST - Test step 05 TRUNK SWITCH (Astra-F)
- F0:DATA LIST - Test step 06 TRUNK SIGNAL SW. (Astra-F)
- F0:DATA LIST - Test step 07 RADIO STATUS
- F0:DATA LIST - Test step 08 RADIO GROUND
- F0:DATA LIST - Test step 09 PANE BREAK. ST. (Astra-F, except Estate)
- F0:DATA LIST - Test step 09 PANE BREAK. ST. (Astra-F, Caravan)
- F0:DATA LIST - Test step 10 PANE BREAK. SIG.
- F0:DATA LIST - Test step 12 U/S ALARM
- F0:DATA LIST - Test step 13 U/S ALARM SIG.
- F0:DATA LIST - Test step 14 DISARM SIGNAL (Astra-F)
- F0:DATA LIST - Test step 15 ARM SIGNAL (Astra-F)
- F0:DATA LIST - Test step 16 THEFT STATUS
- F0:DATA LIST - Test step 17 ALARM SIG. INPUT
- F0:DATA LIST - Test step 18 CHECK LIGHT
- F0:DATA LIST - Test step 19 FUEL/CRANK SW.
- F0:DATA LIST - Test step 20 TURN SIG. RELAY
- F0:DATA LIST - Test step 21 HORN
- Explanation of Tables
- Table 1, Diagnostic Plug X13 and Voltage Supply K94, Check
- Table 2, F2:TROUBLE CODE
- F2:TROUBLE CODE - Trouble code nr. 18 DISARM WIRE OPEN CIRCUIT
- F2:TROUBLE CODE - Trouble code nr. 24 PANE BREAKAGESIGNAL VOLTAGE HIGH
- F2:TROUBLE CODE - Trouble code nr. 25 HORN CIRCUIT
- F2:TROUBLE CODE - Trouble code nr. 32 TRUNK SWITCH ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 33 ENGINE HOOD SW. ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 34 DOOR SWITCH ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 35 IGNITION ON ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 37 RADIO RECEIVER ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 39 DISARM SIGNAL ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 40 2 ALARMS OCCURRED AT THE SAME TIME
- F2:TROUBLE CODE - Trouble code nr. 45 ULTRASOUND ALARM ACTIVATED
- F2:TROUBLE CODE - Trouble code nr. 46 PANE BREAKAGE SENSOR ALARM ACTIV.
- F2:TROUBLE CODE - Trouble code nr. 50 REPLACE ECU
- F2:TROUBLE CODE - Trouble code nr. 55 REPLACE ECU
- Table 3, Coding Tables
- Table 5, F5:ACTUATOR TEST NR. 01 CHECK LIGHT
- Table 5, F5:ACTUATOR TEST NR. 02 HORN (Astra-F (FANFARE))
- Table 5, F5:ACTUATOR TEST NR. 03 TURN SIG. RELAY
- Table 5, F5:ACTUATOR TEST NR. 04 FUEL/CRANK SW.
- Table 7, F7:PROGRAMMING Nr. 01 PROGRAMMING COUNTRY CODE
- Diagnostic Plug
- Terminal Assignment,Wiring Harness Plug, Anti-theft Warning System Control Unit
- Terminal Assignment of Radio
- Circuit Diagram, Astra-F
- Trouble-shooting Chart
- Part Locations (Astra-F)
- Time Allowance
- ATWS - Introduction
- ATWS - Diagnosis
- ATWS - Read Trouble Code
- ATWS - Check Data List Parameters
- ATWS - Carry out Actuator Tests
- ATWS - Carry out Control Tests
- ATWS - Snapshot Mode
- ATWS - Final System Test
- ATWS - General Safety Measures and Repair Instructions
- Survey of Vehicle
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 18 DISARM WIRE OPEN CIRCUIT
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 24 PANE BREAKAGE SIGNAL VOLTAGE HIGH
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 25 HORN CIRCUIT
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 32 TRUNK SWITCH ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 33 ENGINE HOOD SW. ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 34 DOOR SWITCH ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 35 IGNITION ON ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 37 RADIO RECEIVER ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 39 DISARM SIGNAL ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 40 2 ALARMS OCCURED AT THE SAME TIME
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 45 ULTRASOUND ALARM ACTIVATED
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 46 PANE BREAKAGE SENSOR ALARM ACTIV.
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 50 REPLACE ECU
- F2:TROUBLE/ALARM CODE TABLE - Trouble Code 55 REPLACE ECU
- F0:DATA LIST - Test Step 01 BATTERY VOLTAGE
- F0:DATA LIST - Test Step 02 IGNITION STATUS
- F0:DATA LIST - Test Step 03 DOORS SWITCH
- F0:DATA LIST - Test Step 04 ENGINE HOOD SW.
- F0:DATA LIST - Test Step 05 TRUNK SWITCH
- F0:DATA LIST - Test Step 06 TRUNK SIGNAL SW.
- F0:DATA LIST - Test Step 07 RADIO STATUS
- F0:DATA LIST - Test Step 08 RADIO GROUND
- F0:DATA LIST - Test Step 09 PANE BREAK. ST.
- F0:DATA LIST - Test Step 10 PANE BREAK. SIG.
- F0:DATA LIST - Test Step 11 U/S SWITCH
- F0:DATA LIST - Test Step 12 U/S ALARM
- F0:DATA LIST - Test Step 13 U/S ALARM SIG.
- F0:DATA LIST - Test Step 14 DISARM SIGNAL
- F0:DATA LIST - Test Step 15 ARM SIGNAL
- F0:DATA LIST - Test Step 16 THEFT STATUS
- F0:DATA LIST - Test Step 17 ALARM SIG. INPUT
- F0:DATA LIST - Test Step 18 CHECK LIGHT
- F0:DATA LIST - Test Step 19 FUEL/CRANK SW.
- F0:DATA LIST - Test Step 20 TURN SIG. RELAY
- F0:DATA LIST - Test Step 21 HORN
- F5:ACTUATOR TEST CHECK LIGHT
- F5:ACTUATOR TEST HORN
- F5:ACTUATOR TEST TURN SIG. RELAY
- F5:ACTUATOR TEST FUEL/CRANK SW.
- F7:PROGRAMMING PROGRAMMING COUNTRY CODES
- Opel/Vauxhall Inspection System as of Model Year 94.5
- Miscellaneous › F0:DATA LIST - Test step 11 U/S SWITCH (Astra-F)
- Other Information › Opel/Vauxhall Inspection System as of Model Year 94.5
- Technical Information › 1994 › Opel/Vauxhall Inspection System as of Model Year 94.5
- Horn › Repair Instructions › Anti-theft warning system signalling horn, remove and install
Control Unit6 pages
Sensors › Description and Operation2 pages
DID (Dual Info Display)44 pages
- Repair Instructions › Display systems, operating telltale, remove and install
- Component Locator › Checking Equipment
- Warnings, Disclaimers, Safety › General Instructions / Safety Measures
- Labour Time Allowances
Diagnostic Information and Procedures › Miscellaneous27 pages
- Introduction
- The OPEL/VAUXHALL Checking System
- General Instructions / Safety Measures
- Checking Equipment
- Survey of System - Block Diagram, DID
- Self-test
- Diagnosis
- Abbreviations/Definitions
- Checking Programme - Trouble Code 81
- Checking Programme - Trouble Code 82
- Checking Programme - Trouble Code 83
- Checking Programme - Trouble Code 84
- Checking Programme - Trouble Code 85
- Checking Programme - Trouble Code 86
- Checking Programme - Trouble Code 87
- Checking Programme - Trouble Code 88
- Checking Programme - Trouble Code 89
- Checking Programme - Trouble Code 91
- Checking Programme - Trouble Code 92
- Checking Programme - Trouble Code 93
- Checking Programme - Trouble Code 94
- Checking Programme - Trouble Code 95
- Checking Programme - Trouble Code 96
- Terminal Assignment, 12-pin Connection Plug
- Terminal Assignment, Radio Connection Plug
- Excerpt from Circuit Diagram, ASTRA-F
- Time Allowance
- Schematic and Routing Diagrams › Survey of System - Block Diagram, DID
MID (Multi Info Display)117 pages
Repair Instructions2 pages
- Specifications › New Program Memory Codes, Model Year 1995
- Warnings, Disclaimers, Safety › General Instructions / Safety Measures
- Labour Time Allowances
Diagnostic Information and Procedures › Diagnostic Procedures85 pages
- Introduction
- The Checking System
- General Instructions / Safety Measures
- Checking Equipment
- Block Diagram, Multi-Info-Display
- Features Specific to this System
- Types of Fault
- Checking with Diagnostic Switch KM-640
- Diagnostic Switch KM-640, Connect
- Trouble Code, Read out with Diagnostic Switch KM-640
- Trouble Code, Delete Using Diagnostic Switch KM-640
- Program Memory Code, Version Number and Odometer Pulse Quantity, Check
- Checking with TECH 1
- TECH 1, Connect to Vehicle
- Abbreviations, Definitions
- F0:DATA LIST - Test Step 01 - BATTERY VOLTAGE
- F0:DATA LIST - Test Step 02 - DIMMER VOLTAGE
- F0: DATA LIST - Test Step 03 - START KEY
- F0: DATA LIST - Test Step 04 - FUNCTION KEY
- F0: DATA LIST - Test Step 05 - CLOCK KEY
- F0: DATA LIST - Test Step 06 - SET KEY
- F0: DATA LIST - Test Step 07 - WASHER LEVEL SW.
- F0: DATA LIST - Test Step 08 - WASHER LEVEL ST.
- F0: DATA LIST - Test Step 09 - COOLANT LEVEL SW.
- F0: DATA LIST - Test Step 10 - COOLANT LEVEL STATUS
- F0: DATA LIST - Test Step 11 - OIL LEVEL SWITCH
- F0: DATA LIST - Test Step 12 - OIL LEVEL STATUS
- F0: DATA LIST - Test Step 13 - BRAKE PADS SW.
- F0: DATA LIST - Test Step 14 - BRAKE PADS ST.
- F0: DATA LIST - Test Step 15 - BRAKE LIGHT FUSE
- F0: DATA LIST - Test Step 16 - BRAKE LIGHT SW.
- F0: DATA LIST - Test Step 17 - BRAK LIGHT
- F0: DATA LIST - Test Step 18 - BRAKE LIGHT ST.
- F0: DATA LIST - Test Step 19 - HEAD/TAIL LIGHT
- F0: DATA LIST - Test Step 20 - HEAD/T. LIGHT ST.
- F0: DATA LIST - Test Step 21 VEHICLE SPEED
- F0: DATA LIST - Test Step 22 - DEC. FUEL CUTOFF
- F0: DATA LIST - Test Step 23 - OUTS. SENSOR TEMP
- F0: DATA LIST - Test Step 24 - OUTSIDE TEMP.
- F0: DATA LIST - Test Step 25 - FUEL PUMP RELAY
- F0: DATA LIST - Test Step 26 - TANK SENSOR
- F0: DATA LIST - Test Step 27 - TANK CONT. GAUGE
- F0: DATA LIST - Test Step 28 - INST. TANK CONT.
- F0: DATA LIST - Test Step 29 - INST. CONSUMPT.
- F0: DATA LIST - Test Step 30 - RANGE CONSUMPT.
- F0: DATA LIST - Test Step 31 - DISTANCE RANGE
- F0: DATA LIST - Test Step 32 - RANGE CORRECTION
- F0: DATA LIST - Test Step 33 - AUTOM. ANTENNA
- F0: DATA LIST - Test Step 34 - RADIO TER. SCL
- F0: DATA LIST - Test Step 35 - RADIO TER. MRQ
- F0: DATA LIST - Test Step 36 - RADIO TER. SDA
- F0: DATA LIST - Test Step 37 - DISTANCE WARNING
- F0: DATA LIST - Test Step 38 - ICE WARNING
- F0: DATA LIST - Test Step 39 - MID LANGUAGE
- F0: DATA LIST - Test Step 40 - SELECTED FUNCT.
- F0: DATA LIST - Test Step 41 - DIAG. REQUEST
- F0: DATA LIST - Test Step 42 - SELECTED UNIT
- Explanation of Tables
- Table 1, ALDL Diagnostic Plug and Voltage Supply, Check
- Table 2, Trouble Code Table - Code 51 - REPLACE ECU
- Table 2, Trouble Code Table - Code 52 - RE-PROGRAM PROGRAM MEMORY
- Table 2, Trouble Code Table - Code 55 - REPLACE ECU
- Table 2, Trouble Code Table - Code 121 - RADIO BUS COMMUNICATION
- Table 2, Trouble Code Table - Code 122 - BRAKE LIGHT FUSE VOLTAGE LOW
- Table 2, Trouble Code Table - Code 167 - TANK GAUGE VOLTAGE LOW
- Table 2, Trouble Code Table - Code 168 - TANK GAUGE VOLTAGE HIGH
- Table 2, Trouble Code Table - Code 169 - OUTSIDE TEMP. SENSOR VOLTAGE LOW
- Table 2, Trouble Code Table - Code 171 - OUTSIDE TEMP. SENSOR VOLTAGE HIGH
- Table 2, Trouble Code Table - Code 173 - FUEL CONSUMPTION SIGNAL VOLTAGE LOW
- Table 3, Coding Table
- Delivery Range of Multi-Info-Display Language Versions
- Program Memory Codes
- Table 5, F5:ACTUATOR TEST No. 01 - SELECT ACTUATOR RADIO BUS TEST
- F5:ACTUATOR TEST FAULT DISPLAY
- Table 6, F6:ADJUSTMENTS - Range Calibration
- Table 6, F6:ADJUSTMENTS - Range Correction
- Table 6, F6:ADJUSTMENTS - Setting Clock
- Table 6, F6:ADJUSTMENTS - Multi-Info-Display, Program
- Table 7, F7:PROGRAMMING
- Terminal Assignment of 12-pin Plug, Multi-Info-Display
- Terminal Assignment of 26-pin Plug, Multi-Info-Display
- Circuit Diagram, Multi-Info-Display, ASTRA-F
- Trouble-shooting Table
- Parts Allocation
- Time Allowance
Other Information19 pages
- Introduction
- The Checking System
- General Instructions / Safety Measures
- Checking Equipment
- Block Diagram, Multi-Info-Display
- Features Specific to this System
- Types of Fault
- Checking with Diagnostic Switch KM-640
- Diagnostic Switch KM-640, Connect
- Trouble Code, Read out with Diagnostic Switch KM-640
- Trouble Code, Delete Using Diagnostic Switch KM-640
- Program Memory Code, Version Number and Odometer Pulse Quantity, Check
- Checking with TECH 1
- TECH 1, Connect to Vehicle
- Abbreviations, Definitions
- Explanation of Tables
- Delivery Range of Multi-Info-Display Language Versions
- Parts Allocation
- New Program Memory Codes, Model Year 1995
- Schematic and Routing Diagrams › Trouble-shooting Table
- Technical Information › 1994 › New Program Memory Codes, Model Year 1995
TID (Triple Info Display)7 pages
Electrical Window Winders42 pages
- Repair Instructions › Electronic Window Winders
- Labour Time Allowances › Electronic Window Winders
Diagnostic Information and Procedures › Miscellaneous20 pages
- Introduction
- Function Check
- Function Standby
- Automatic Operation
- Pinch Guard
- Child Safety Catch
- Actuation from Outside (Actuation via Door Lock)
- Programming of Window Winder Electronics
- Test Connection
- Instructions for Test Programs
- Survey of System
- Trouble-shooting Chart
- Test Step 1 - Voltage Supply for Actuation of ECWW (F 7)
- Test Step 2 - Voltage Supply for ECWW (F 10)
- Test Step 13 - Control Lead Between Driver's/Co-driver's Door for ECWW Co-driver's Door
- Test Step 16 - Ground Connection in Wiring Harness
- Survey of System
- Circuit Diagrams - Astra-F
- Part Locations - Astra-F
- Circuit Diagram Electric Window Winders Astra-F Convertible
- Time Allowance - Astra-F
- Other Information › Electronic Window Winders
- Technical Information › 1994 › Electronic Window Winders
Motor › Diagnostic Information and Procedures › Miscellaneous9 pages
- Test Step 3 - Voltage Supply for ECWW Motor M 47 (Driver's Door)
- Test Step 4 - Voltage Supply for ECWW Motor M 48 (Co-driver's Door)
- Test Step 5 - Ground Connection for ECWW Motor M 47 (Driver's Door)
- Test Step 6 - Ground Connection for ECWW Motor M 48 (Co-driver's Door)
- Test Step 14 - Control Inputs ECWW Motor M 47 (Driver's Door)
- Test Step 15 - Control Inputs ECWW Motor M 48 (Co-driver's Door)
- Test Step 17 - Short Circuit to Ground ECWW Motor M 47 (Driver's Door)
- Test Step 18 - Short Circuit to Ground ECWW Motor M 48 (Co-driver's Door)
- 6-pin Wiring Harn.Plug,ECWW Motor Driver and Co-driver's Door, Position: A3H, F3H
Switch › Diagnostic Information and Procedures › Miscellaneous6 pages
- Test Step 7 - Conn. in Driver's Door to ECWW Switch, Driver's Door S37.1 (in Driver's Door)
- Test Step 8 - Conn. in Driver's Door to ECWW Switch, Co-driver's Door S37.2 (in Driver's Door)
- Test Step 9 - Conn. in Co-Driver's Door to ECWW Switch, Co-driver's Door S 78
- Test Step 10 - ECWW Switch S 37.1 (in Driver's Door)
- Test Step 11 - ECWW Switch, Co-driver's Door S 37.2 (in Driver's Door)
- Test Step 12 - ECWW Switch, Co-driver's Door S 78 (in Co-driver's Door)
Instruments, Telltales14 pages
Technical Service Bulletins6 pages
- Inoperative - Totally, Partially › Various Problems with the Carphone (Cellway).
- Poor Operation, Incorrect Operation › Various Problems with the Carphone (Cellway).
- Blows Fuse › Temperature Gauge in Red Area or Radiator Fan Fuse Blows
- No Start › Battery telltale is on and/or starting problems
Warning Lights, Telltale2 pages
- Tachometer › Repair Instructions › Speedometer, remove and install
- Temperature Gauge › Repair Instructions › Remote thermometer, fuel level indicator, remove and install
Instrument Lighting › Repair Instructions2 pages
- Fuel Gauge › Repair Instructions › Remote thermometer, fuel level indicator, remove and install
- Printed Circuit › Repair Instructions › Circuit board, remove and install
- Voltage Stabilizer › Repair Instructions › Voltage stabiliser, remove and install
- Speedometer › Repair Instructions › Speedometer, remove and install
Wiring Harnesses41 pages
Repair Instructions17 pages
- Wiring harness, fuse box summary installation points relay and control units
- Installation point I - engine compartment relay box front panel (MY '95 and '96)
- Installation point H - engine compartment relay box wheel housing - X16XEL, X 20 XEV, X 18 XE, X 14 XE
- Installation point H-engine compartment relay box wheel housing - 17D and X17DTL (MY '95 and '96)
- Installation point G - engine compartment hydraulic modulator, control unit-ABS
- Installation point E- rear panelling- footwell, right relay holder (MY '95)
- Installation point F quarter panel rear right relay holder
- Wiring harness body sectional representation interior
- Wiring harness front and rear door
- Wiring harness front door remove and install
- Wiring harness Body sectional representation rear area - 53,54,58,59
- Wiring harness tailgate, remove and install, Models 53, 54, 58, 59
- Wiring harness tailgate, remove and install, Models 51, 52, 55
- Wiring harness luggage compartment cover, remove and install, Models 56, 57, 53-B
- Complete wiring harness for body, remove and install
- Wiring harness instrument panel, remove and install
- Wiring harness hydraulic pump electr. folding hood, replace
- Description and Operation › Body Wiring Harness
Component Locator18 pages
- Wiring harness, fuse box summary installation points relay and control units
- Installation point I - engine compartment relay box front panel (MY '95 and '96)
- Installation point H - engine compartment relay box wheel housing - X16XEL, X 20 XEV, X 18 XE, X 14 XE
- Installation point H-engine compartment relay box wheel housing - 17D and X17DTL (MY '95 and '96)
- Installation point G - engine compartment hydraulic modulator, control unit-ABS
- Installation point E- rear panelling- footwell, right relay holder (MY '95)
- Wiring harness body sectional representation interior
- Wiring harness front and rear door
- Wiring harness rear door remove and install
- Wiring harness tailgate, Models 53, 54, 58, 59
- Wiring harness tailgate, Models 51, 52, 55
- Wiring harness body - sectional representation rear area - Mod. 56, 57
- Wiring harness luggage compartment cover, Models 56, 57
- Wiring harness body - sectional representation front area
- Separable cable harness plug for body, instrument panel (MY'95)
- Wiring harness instrument panel
- Wiring harness engine
- Wiring harness secondary air injection, engine X 16 XEL, X 20 XEV
- Diagnostic Information and Procedures › Diagnostic Procedures › Wiring Harness Routing, Astra-F - AF 13/14/20
- Other Information › Wiring harness Body sectional representation rear area - 53,54,58,59
Fuse Box32 pages
Repair Instructions15 pages
- Wiring harness, fuse box summary installation points relay and control units
- Installation point K and L - fuse box fuse box with 30 fuses
- Installation point K and L - fuse box with 28 fuses (up to MY '95) deviation, Model 53-B (Cabrio)
- Installation point K - fuse box rear side (MY'95) except for Mod. 53-B (Cabrio)
- Installation point L - fuse box front side (MY'95)
- Protected circuits summary, fuses, fuse box with 30 fuses
- Protected circuits summary, fuses, fuse box with 28 fuses (up to MY '95)
- Protected circuits summary, fuses, fuse box with 28 fuses (MY '95)
- Protected circuits summary, fuses, fuse box with 28 fuses
- Protected circuits summary, fuses, fuse box with 30 fuses
- Relay or fuse, replace relay box wheel housing or front panel
- Relay, replace, relay holder above glove compartment
- Relay, replace, fuse box
- Relay, replace, fuse box rear side
- Relay, replace, relay holder electrical folding hood
- Relay, replace, steering column holder
- Description and Operation › Relay Location
Component Locator9 pages
- Wiring harness, fuse box summary installation points relay and control units
- Installation point K and L - fuse box fuse box with 30 fuses
- Installation point K and L - fuse box with 28 fuses (up to MY '95) deviation, Model 53-B (Cabrio)
- Installation point K - fuse box rear side (MY'95) except for Mod. 53-B (Cabrio)
- Installation point L - fuse box front side (MY'95)
- Protected circuits summary, fuses, fuse box with 30 fuses
- Protected circuits summary, fuses, fuse box with 28 fuses (up to MY '95)
- Protected circuits summary, fuses, fuse box with 28 fuses (MY '95)
- Protected circuits summary, fuses, fuse box with 28 fuses
- Protected circuits summary, fuses, fuse box with 30 fuses
Specifications4 pages
- Protected circuits summary, fuses, fuse box with 30 fuses
- Protected circuits summary, fuses, fuse box with 28 fuses (up to MY '95)
- Protected circuits summary, fuses, fuse box with 28 fuses (MY '95)
- Protected circuits summary, fuses, fuse box with 28 fuses
- Protected circuits summary, fuses, fuse box with 30 fuses
Radio Interference Suppression5 pages
- Repair Instructions › Installation point C - steering column relay holder, control unit
Technical Service Bulletins4 pages
Inoperative - Totally, Partially2 pages
Poor Operation, Incorrect Operation2 pages
Switches, Control Unit, Relays, Ignition Lock37 pages
Repair Instructions5 pages
- Wiring harness, fuse box summary installation points relay and control units
- Installation point G - engine compartment hydraulic modulator, control unit-ABS
- Installation point B - Sill left control unit TC
- Light and interior light switch, remove and install
- Immobiliser with Immobiliser Control Unit Transponder, Remove and Install
Technical Service Bulletins4 pages
- Flasher Unit › Technical Service Bulletins › Inoperative - Totally, Partially › Signal Lever Does not Re-engage Autom. in Zero Position. Switch is OK
Steering and Ignition Lock8 pages
Repair Instructions7 pages
- Steering and ignition lock, contact element for steering and ignition lock, replace (up to MY '95)
- Contact element for steering and ignition lock, replace - from MY '95 vehicles with airbag
- Lock cylinder for steering and ignition lock, replace
- Lock cylinder without crescent, remove and install or replace
- Lock cylinder with crescent, replace by lock cylinder without crescent
- Lock cylinder without crescent, replace by lock cylinder with crescent
- Contact Part, Steering and Ignition Lock
- Technical Information › 1995 › Contact Part, Steering and Ignition Lock
Switches, RON Coding Plug › Repair Instructions8 pages
- Parking brake telltale switch, replace
- TC button, remove and install
- Switch for handbrake telltale, remove and install
- Brake light switch, remove and install
- Rear fog light/fog light switch, remove and install
- Switch for seat heating, remove and install
- Switch for headlamp range adjustment, remove and install
- Switch for folding hood actuation, remove and install
Signal Switch › Repair Instructions3 pages
- Hazard Warning Switch › Repair Instructions › Hazard warning system switch, remove and install
Headlamps, Lamps and Horn50 pages
- Description and Operation › Turn Signal Lamps
Turn Signal Lamps › Repair Instructions4 pages
- Interior Lamp in Door › Technical Service Bulletins › Inoperative - Totally, Partially › Daytime Driving Lamps Remain Illuminated after Engine is Switched off
Luggage Compartment Lamp › Repair Instructions3 pages
Bulbs › Repair Instructions15 pages
- Bulb/socket for illumination, remove and install
- Bulbs in interior light with Ultrasound interior monitoring system, change
- Indicator lamp bulb front, replace
- Side indicator lamp, remove and install
- Side indicator lamp bulb, replace
- Rear lamp bulb, replace (Mod. 51, 52, 55)
- Rear lamp bulb, replace (Models 56, 57, 53-B)
- Rear lamp bulb, replace (Mod. 53, 54, 58, 59)
- License-plate lamp bulb, replace (Mod. 51, 52, 55)
- License-plate lamp bulb, replace (Mod. 53, 56, 57, 58, 59)
- License-plate lamp bulb, replace (Mod. 54, 53-B)
- License-plate lamp bulb, replace MY '95 (except for Mod. 51, 52, 55)
- Bulb for luggage compartment/loading area lighting, replace
- Interior light bulb, replace
- Rear reading light bulb, replace
Rear Lamp7 pages
Repair Instructions6 pages
- Description and Operation › Rear Lamps
Licence Plate Lamp9 pages
Repair Instructions8 pages
- License-plate lamp, remove and install (Mod. 51, 52, 55)
- License-plate lamp bulb, replace (Mod. 51, 52, 55)
- License-plate lamp, remove and install (Mod. 53, 56, 57, 58, 59)
- License-plate lamp bulb, replace (Mod. 53, 56, 57, 58, 59)
- License-plate lamp, remove and install (Mod. 54, 53-B)
- License-plate lamp bulb, replace (Mod. 54, 53-B)
- License-plate lamp, remove and install MY '95 except for Models 51, 52, 55
- License-plate lamp bulb, replace MY '95 (except for Mod. 51, 52, 55)
- Description and Operation › License Plate Lamp
- Fog Lamp › Description and Operation › Front Fog Lamps
Servo Motor Headlamp Range Control › Repair Instructions5 pages
- Headlamp with headlight range adjustment, remove and install
- Headlamp range adjustment, servo motor headlamp range adjustment, replace - headlamp Carello
- Servo motor headlamp range adjustment, replace Bosch headlamp
- Servo motor headlamp range adjustment, replace Valeo headlamp
- Switch for headlamp range adjustment, remove and install
Windscreen Wash/Wipe System, Heated Screen16 pages
- Technical Service Bulletins › Inoperative - Totally, Partially › Washer system, pump - Without function
Rear Screen Wash/Wipe System10 pages
Repair Instructions5 pages
Technical Service Bulletins5 pages
Central Door Locking System56 pages
Diagnostic Information and Procedures15 pages
- Diagnostic Procedures › Opel/Vauxhall Inspection System as of Model Year 94.5
Miscellaneous14 pages
- Introduction
- Function Check
- Central Door Locking System with Anti-theft Device
- Central Locking and Unlocking
- Anti-theft Device
- Test Connection
- Instructions for Test Programs
- Central Door Locking System with Anti- theft Device - Survey of System
- Central Door Locking System with Anti- theft Device - Trouble-shooting Chart
- Test Step 14 - CDLS Wiring Harness
- Circuit Diagrams - Astra-F
- Part Locations - Astra-F
- 3-pin Wiring Harness Plug for ATD Switch Driver's Door, Position: A4H
- Time Allowance - Astra-F
- Other Information › Opel/Vauxhall Inspection System as of Model Year 94.5
- Technical Information › 1994 › Opel/Vauxhall Inspection System as of Model Year 94.5
Switch3 pages
- Repair Instructions › Switch (driver s door), remove and install
Diagnostic Information and Procedures › Miscellaneous2 pages
Servo26 pages
Repair Instructions8 pages
- Central door locking servo motor driver s door, adjust
- Servo motor passenger s door, adjust
- Servo motor rear doors, adjust
- Servo motor (front door), remove and install
- Servo motor (rear door), remove and install
- Servo motor (fuel filler flap), remove and install
- Servo motor (luggage compartment cover), remove and install
- Servo motor (tailgate), remove and install
Diagnostic Information and Procedures › Miscellaneous18 pages
- Overheating Cutout
- Servo Motors, Adjust
- Test Step 1 - Voltage Supply for Control Unit K 37 and Servo Motors
- Test Step 4 - Output for Servo Motors in Control Unit K 37
- Test Step 8 - CDLS Servo Motor M 18, Wiring Harness X31 - M18 (Driver's Door)
- Test Step 9 - CDLS Servo Motor M 32, Wiring Harness X34-M32(Co-driver's Door)
- Test Step 10 - CDLS Servo Motor M 19, Wiring Harness X33-M19 (Rear Left Door)
- Test Step 11 - CDLS Servo Motor M 20, Wiring Harness X36-M20(Right Rear Door)
- Test Step 12 NB - CDLS Servo Motor M 60 Wiring Harness X44-M60 (Luggage Comp. Lid) Notchback
- Test Step 12 KW - CDLS Servo Motor M 60, Wiring Harness X58-M60 (Tailgate) Estate
- Test Step 12 HB - CDLS Servo Motor M60, Wiring Harness X60-M60 (Tailgate) HB
- Test Step 13 - CDLS Wiring Harness M41, Servo Motor M 41 (Tank Flap)
- Test Step 15 - Switch in CDLS Servo Motor M 18 (Driver's Door)
- Test Step 16-Switch in CDLS Servo Motor M 32/CDLS Switch S 42 (Co-driver's Door)
- 6-pin Wiring Harness Plug for CDLS Servo Motor Driver's Door, Position: A4H
- 6-pin Wiring Harness Plug for CDLS Servo Motor Co-driver's Door, Position: F4H
- 6-pin Wiring Harness Plug for CDLS Servo Motor Rear Doors, Position: A5H, F5H
- 6-pin Wiring Harn. Plug,CDLS Servo Motor Luggage Comp. Lid/Tailgate: Pos.: C7J
Control Unit with Crash Sensor10 pages
- Repair Instructions › Control unit central door locking, remove and install
Diagnostic Information and Procedures › Miscellaneous9 pages
- Crash Sensor, Delay Switch
- Test Step 1 - Voltage Supply for Control Unit K 37 and Servo Motors
- Test Step 2 - Voltage Supply for Crash Sensor in Control Unit K 37
- Test Step 3 - Ground Connection to Control Unit K 37
- Test Step 4 - Output for Servo Motors in Control Unit K 37
- Test Step 5 - Input and Output Leads in Control Unit K 37
- Test Step 6 - Input Signal "Lock" at Control Unit K 37
- Test Step 7 - Input Signal "Unlock" at Control Unit K 37
- 12-pin Wiring Harness Plug for CDLS Control Unit Position: F 3 H
Immobiliser181 pages
Description and Operation13 pages
- Immobiliser with Transponder
- Illustration - Location in Vehicle
- Function
- Function - Car Pass
- Block Diagram
- Transponder Key
- Engine Control Unit, Replace
- "Immobiliser" Function in Engine Control Unit, Activate
- Data, Engine Control Units and Diagnosis Info.in Conj. with Immobiliser Functions
- Petrol Engines
- Circuit Diagram
- Integrated Immobiliser (only Vehicles Without Immobiliser with Transponder)
- Integrated Immobiliser (Vehicles With Immobiliser with Transponder)
- Warnings, Disclaimers, Safety › General Instructions/Safety Measures
- Labour Time Allowances › Modification to Control Unit Housing Immobiliser with 90 degree ignition lock.
Diagnostic Information and Procedures › Diagnostic Procedures122 pages
- F0:Data List Test Step 03 IMMOBILISER
- F0:Data List Test Step 04 IMMOBILISER SIG.
- F2:Trouble Codes - Trouble Code No. 83 IMMOBILISER NO OR WRONG CODING
- F2:Trouble Codes - Trouble Code No. 84 IMMOBILISER NO SIGNAL
- F2:Trouble Codes - Trouble Code No. 85 IMMOBILISER WRONG SIGNAL
- Quick Check F5:Actuator Test IMMO.SIG. TEST
- F7:Programming IMMOBILISER
- F2: TROUBLE CODE TABLE - Trouble Code 83 IMMOBILISER NO OR WRONG CODING
- Immobiliser Function for all Electronic Engine Systems
- Simtec - F2: TROUBLE CODE TABLE - TC 59 IMMOBILISER NO OR WRONG CODING
- Simtec - F2: TROUBLE CODE TABLE - TC 93 IMMOBILISER NO SIGNAL
- Simtec - F0:DATA LIST - Test Step 01 IMMOBILISER
- Simtec - F7:PROGRAMMING IMMOBILISER
- Multec - F2:TROUBLE CODES - TC 83 IMMOBILISER NO OR WRONG CODING
- Multec - F0: DATA LIST - Test Step 01 IMMOBILISER SIG.
- Multec - F0: DATA LIST - Test Step 02 IMMOBILISER
- Multec - F7: PROGRAMMING IMMOBILISER
- Motronic - F2:TROUBLE CODE TABLE - TC143 IMMOBILISER NO OR WRONG CODING
- Motronic - F2:TROUBLE CODE TABLE - TC144 IMMOBILISER NO SIGNAL
- Motronic - F2:TROUBLE CODE TABLE - TC145 IMMOBILISER WRONG SIGNAL
- Motronic - F0: DATA LIST-Test Step 01 IMMOBILISER
- Immobiliser - Introduction
- Immobiliser - Diagnosis
- Immobiliser - Read Trouble Code
- Immobiliser - Check Data List Parameters
- Immobiliser - Carry out Actuator Tests
- Immobiliser - Carry out Control Tests
- Immobiliser - Snapshot Mode
- Immobiliser - Final System Test
- Immobiliser - General Safety Measures and Repair Instructions
- Survey of Vehicle
- F2:TROUBLE CODE TABLE - Trouble Code 11 TRANSPONDER KEY PROBLEM
- F2:TROUBLE CODE TABLE - Trouble Code 12 WRONG TRANSPONDER KEY
- F2:TROUBLE CODE TABLE - Trouble Code 13 IMMOBILISER NOT PROGRAMMED
- F2:TROUBLE CODE TABLE - Trouble Code 14 NO TRANSP. KEY PROGRAMMED
- F2:TROUBLE CODE TABLE - Trouble Code 17 NO ENGINE REQUEST RECEIVED
- F0:DATA LIST - Test Step 01 IGNITION STATUS
- F0:DATA LIST - Test Step 06 VEH. SPEED OUTPUT
- F0:DATA LIST - Test Step 08 TRANSP. KEY ST.
- F0:DATA LIST - Test Step 09 TRANSP. KEY 1 ST.
- F0:DATA LIST - Test Step 10 TRANSP. KEY 2 ST.
- F0:DATA LIST - Test Step 11 TRANSP. KEY 3 ST.
- F0:DATA LIST - Test Step 12 TRANSP. KEY 4 ST.
- F0:DATA LIST - Test Step 13 TRANSP. KEY 5 ST.
- F0:DATA LIST - Test Step 14 IMMOBILISER SIG.
- F6:MISCELLANEOUS TESTS MECH. KEY-NO.
- F6:MISCELLANEOUS TESTS VEH. IDENT. NO.
- F7:PROGRAMMING NOTE
- F7:PROGRAMMING ENGINE TYPE
- F7:PROGRAMMING MECH. KEY-NO.
- Introduction
- The OPEL/VAUXHALL Checking System
- General Instructions/Safety Measures
- Checking Equipment
- Abbreviations, Definitions
- Features Specific to this System
- Block Diagram - Petrol Engines and 25DT Diesel Engine
- Block Diagram - Diesel Engines (except 25DT)
- Checking with TECH 1
- General Information on Checking
- TECH 1, Connect to Vehicle
- F0:DATA LIST - Petrol Engines and 25 DT Diesel Engine
- F0:DATA LIST - Test Step 01 IGNITION STATUS
- F0:DATA LIST - Test Step 02 DIESEL CUTOFF S.
- F0:DATA LIST - Test Step 03 ENG. CHECK LIGHT
- F0:DATA LIST - Test Step 04 ENGINE REQUEST
- F0:DATA LIST - Test Step 05 VEHICLE SPEED
- F0:DATA LIST - Test Step 06 VEH.SPEED OUTPUT
- F0:DATA LIST - Test Step 07 TRANSPONDER KEY
- F0:DATA LIST - Test Step 08 TRANSP. KEY ST.
- F0:DATA LIST - Test Step 09 TRANSP.KEY 1 ST.
- F0:DATA LIST - Test Step 10 TRANSP.KEY 2 ST.
- F0:DATA LIST - Test Step 11 TRANSP.KEY 3 ST.
- F0:DATA LIST - Test Step 12 TRANSP.KEY 4 ST.
- F0:DATA LIST - Test Step 13 TRANSP.KEY 5 ST.
- F0:DATA LIST - Test Step 14 IMMOBILISER SIG.
- F0:DATA LIST - Test Step 15 SECURITY WAIT T.
- F0:DATA LIST - Test Step 16 IMMO.CHECK LIGHT
- F0:DATA LIST - Test Step 17 IMMO. RELAY
- Explanation of Tables
- Table 1, Diagnostic Plugs X13, XD and Voltage Supply K117, Check
- Table 2, Trouble Code Table
- Table 2, Trouble Code Table, TC 11 TRANSPONDER KEY PROBLEM
- Table 2, Trouble Code Table, TC 12 WRONG TRANSPONDER KEY
- Table 2, Trouble Code Table, TC 13 IMMOBILISER NOT PROGRAMMED
- Table 2, Trouble Code Table, TC 14 NO TRANSP. KEY PROGRAMMED
- Table 2, Trouble Code Table, TC 15 VEHICLE SPEED SIGNAL VOLTAGE LOW
- Table 2, Trouble Code Table, TC 16 VEHICLE SPEED SIGNAL VOLTAGE HIGH
- Table 2, Trouble Code Table, TC 17 NO ENGINE REQUEST RECEIVED
- Table 2, Trouble Code Table, TC 18 ENGINE CHECK LIGHT CIRCUIT
- Table 2, Trouble Code Table, TC 19 IMMO.CHECK LIGHT VOLTAGE LOW
- Table 2, Trouble Code Table, TC 20 IMMO.CHECK LIGHT VOLTAGE HIGH
- Table 2, Trouble Code Table, TC 21 IMMO. RELAY VOLTAGE LOW
- Table 2, Trouble Code Table, TC 22 IMMO. RELAY VOLTAGE HIGH
- Table 2, Trouble Code Table, TC 55 REPLACE ECU
- Table 3, Part and Catalogue Numbers
- Table 5, F5:ACTUATOR TEST IMMO. CHECK L. (Immo. Control Unit)
- Table 5, F5:ACTUATOR TEST IMMO. RELAY (Immo. Control Unit)
- Table 5, F5:ACTUATOR TEST IMMO.SIGNAL TEST (Engine Control Unit)
- Table 6, F6:MISC. TESTS
- Table 7, F7:PROGRAMMING Survey of Programming for Immobiliser
- Table 7, F7:PROGRAMMING Note
- Table 7, F7:PROGRAMMING Transponder Key, Program
- Table 7, F7:PROGRAMMING Transponder Key, Erase
- Table 7, F7:PROGRAMMING Immobiliser Control Unit, Program
- Table 7, F7:PROGRAMMING Engine Type, Program
- Table 7, F7:PROGRAMMING Mech. Key Number, Program
- Table 7, F7:PROGRAMMING Vehicle Ident. No., Program
- Table 7, F7:PROGRAMMING Fuel Cutoff Solenoid Valve, Program
- Table 7, F7:PROGRAMMING Engine Control Unit, Program
- Table, Engine Control Units with Immobiliser Function (Petrol Engines)
- Trouble Code Table, Engine Control Units
- Table, Fuel Cutoff Solenoid Valves for Immobiliser in Diesel Vehicles
- Terminal Assignment,Wiring Harness Plug, Immo. Control Unit K117, 9-pin
- Terminal Assignment, Diagnostic Plug XD, 16-pin
- Terminal Assignment, Diagnostic Plug X13, 10-pin
- Terminal Assignment, Multec-M Control Unit and Multec Control Units
- Terminal Assignment, Multec Control Units (C12NZ, C14NZ) (Excerpt)
- Terminal Assignment, Multec-S Control Unit (X14XE, X16XE, X16XEL) (Excerpt)
- Terminal Assignment, Simtec Control Unit (C18XE, C18XEL, X20XEV) (Excerpt)
- Terminal Assignment, Motronic Control Units
- Terminal Assignment, Wiring Harness Plug, DDE 2.1 Control Unit (25DT)
- Circuit Diagram (Excerpt from Overall Circuit Diagram)
- Time Allowance
- Opel/Vauxhall Inspection System as of Model Year 94.5
Other Information12 pages
- Introduction
- The OPEL/VAUXHALL Checking System
- General Instructions/Safety Measures
- Checking Equipment
- Abbreviations, Definitions
- Features Specific to this System
- Block Diagram - Petrol Engines and 25DT Diesel Engine
- Block Diagram - Diesel Engines (except 25DT)
- Checking with TECH 1
- General Information on Checking
- TECH 1, Connect to Vehicle
- Opel/Vauxhall Inspection System as of Model Year 94.5
- Technical Service Bulletins › Poor Start › TC 92/93. Engine only Starts after Repeated Attempts
Control Unit16 pages
Repair Instructions5 pages
- Immobiliser with transponder control unit, immobiliser, remove and install Install
- Control unit solenoid valve, remove and install
- Immobiliser with transponder, immobiliser control unit, remove and install
- Control unit immobiliser, remove and install
- Immobiliser with Immobiliser Control Unit Transponder, Remove and Install
Description and Operation11 pages
- Security Code
- Security Code, Program
- Security Code, Enter
- Loss of Transponder Key
- Transponder Code, Erase
- Transponder Code, Program
- Immobiliser Control Unit, Replace
- New Immobiliser Control Unit, Activate
- Terminal Assignment, Wiring Harness Plug for Immobiliser Control Unit, 9-pin
- Trouble Code Table; Immobiliser Control Unit
- Terminal Assignment, Wiring Harness Plug for Immobiliser Control Unit, 14-pin
- Diagnostic Information and Procedures
Relay11 pages
Repair Instructions5 pages
- Installation point I - engine compartment relay box front panel (MY '95 and '96)
- Installation point H - engine compartment relay box wheel housing - X16XEL, X 20 XEV, X 18 XE, X 14 XE
- Installation point H-engine compartment relay box wheel housing - 17D and X17DTL (MY '95 and '96)
- Installation point E- rear panelling- footwell, right relay holder (MY '95)
- Installation point C - steering column relay holder, control unit
Component Locator4 pages
- Installation point I - engine compartment relay box front panel (MY '95 and '96)
- Installation point H - engine compartment relay box wheel housing - X16XEL, X 20 XEV, X 18 XE, X 14 XE
- Installation point H-engine compartment relay box wheel housing - 17D and X17DTL (MY '95 and '96)
- Installation point E- rear panelling- footwell, right relay holder (MY '95)
Diagnostic Information and Procedures › Diagnostic Procedures2 pages