6 Series E64 635d Convertible (M57T2): 2 Repair Instructions
Also for this vehicle: 6 Series E64 630i (N52) CONVER, 6 Series E64 630i (N52K) CONVER, 6 Series E64 630i (N53) CONVER, 6 Series E64 645Ci (N62) CONVER, 6 Series E64 650i (N62TU) CONVER, 6 Series E64 M6 (S85) CONVER.
Maintenance
General
Diagnostics
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
0 Maintenance And General Data68 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Notes On SMG Transmission Service Functions
- Pre-delivery Check2345
- Lifting Vehicle With A Lifting Platform
- Notes On Using Repair Instructions, Technical Data, Tightening Torques
- Raising Vehicle With Trolley Jack
- Symbols Used And Information In Repair Instructions2
- Battery: Checking Display. If Necessary, Recharge Battery
- Body And Underbody: Checking For Corrosion And Damage
- Body: Check For Corrosion (except Cavities)
- Brake Lines And Connections: Visual Inspection For Leaks, Damage And Correct Pos
- Check Windscreen Wash/wipe System
- Checking Coolant Level And Concentration, Correcting If Necessary
- Checking Horn, Headlight Flashers And Hazard Warning System
- Checking Instrument And Indication Field Lighting, Heater Blower
- Checking Lighting System
- Checking Roadworthiness (test Drive)
- Diagnostic Brief Test
- Information/warning Labels23
- Microencapsulated Screws
- Raising BMW Multi-trailer23
- Seat Belts: Checking Condition Of Belt Strap, Function Of Inertia Reel Mechanism
- Steering Components: Checking For Zero Clearance, Leaks, Damage And Wear2
- Steering Fluid Reservoir: Check Oil Level2
- Triggering Rollover Protection System (Convertible) Via Diagnosis Interface (Imp
- Triggering Rollover Protection System (Convertible) Via Diagnosis Interface (Imp
- Tyres: Checking Inflation Pressure, Correcting If Necessary (incl
- Underbody Incl
- Upkeep Measures For Stored Vehicles (new And Used Cars) And Vehicles To Be Laid23
- Windscreen Washer System: Checking Fluid Level, Topping Up If Necessary
- Interrogating Fault Memories In Diagnosis System
- Standard Scope Of Service
- Interrogating Fault Memories In Diagnosis System
- Service - Intake Muffler
- Particulate Filter Service
- Engine Oil Service (M57T2)2
- Service - Engine Oil (diesel Vehicles)
- Service - Front Brakes
- Service - Rear Brakes
- Service - Microfilter
- Service - Brake Fluid
- Service - Vehicle Check
- Checking/topping Up Oil Level In Rear Differential
- Checking/topping Up Fluid Level In Automatic Transmission (GA6HP19Z)2
- Oil Change In Rear Differential Incl2
- Removing And Installing/replacing Acoustic Cover (N52/N52K)
- Removing And Installing/replacing Rear Acoustic Cover (M57T2)
- Notes On Handling Wiring Harnesses And Cables
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
11 Engine (M57T2)154 pages
0 Engine, General19 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Engine Oil Service (M57T2)2
- Removing And Installing/replacing Acoustic Cover (N52/N52K)
- Removing And Installing/replacing Rear Acoustic Cover (M57T2)
- Checking Compression Of All Cylinders (M57T2)2
- Checking Compression Of All Cylinders (M57TU)2
- Securing Engine In Installation Position (M57T2)2
- Engine Identification2345
- Mounting Engine On Assembly Stand (M57T2)
12 Cylinder Head With Cover17 pages
- Removing And Installing / Sealing Cylinder Head Cover (M57T2)2
- Removing And Installing, Sealing/replacing Cylinder Head Cover (M57TU)2
- Removing And Installing Cylinder Head (M57T2)2345
- Replacing Cylinder Head Gasket (M57T2)2
- Disassembling And Assembling Cylinder Head (M57T2)2
- Checking A Valve Guide For Wear (M57T2)
- Checking One Valve Guide For Wear (M57TU)
- Check Cylinder Head For Watertightness (M57T2)2
21 Crankshaft With Bearing8 pages
- 22 Flywheel › Removing And Installing / Replacing Flywheel (automatic M57T2)
- 23 Vibration Damper › Removing And Installing/replacing Vibration Damper (M57T2)
- 24 Connecting Rod With Bearing › Replacing All Conrod Bearings (M57T2)23
25 Piston With Rings And Pin8 pages
28 V-ribbed Belt W.tens.-deflect.elemt7 pages
31 Camshaft26 pages
- Removing And Installing, Sealing/replacing Front Timing Case Cover (M57T2)2
- Replacing Camshafts (M57T2)23456
- Checking Camshaft Timing (M57T2)2
- Removing And Installing / Replacing Exhaust Camshaft (M57T2)234
- Removing And Installing / Replacing Inlet Camshaft (M57T2)23456
- Replacing Both Timing Chains (M57T2)2
- Removing And Installing / Replacing Hydraulic Chain Tensioner (M57T2)
- Adjusting Valve Timing (M57T2)23
34 Valves With Springs5 pages
- 40 Oil Supply › Checking Engine Oil Pressure (M57T2)2
- 41 Oil Pump With Filter And Drive › Removing And Installing Or Replacing Oil Pump (M57T2)
- 44 Oil Cooler › Removing And Installing, Sealing Or Replacing Oil / Water Heat Exchanger (M57T2)2
- 52 Fan › Removing And Installing/replacing Fan Clutch (M57T2)2
- 53 Thermostat And Connections › Removing And Installing / Replacing Coolant Thermostat (M57T2)2
61 Intake Manifold9 pages
- Removing And Installing Air Intake Manifold (M57T2)
- Removing And Installing / Replacing Left Pressure Pipe (charge Air Hose) (M57T2)2
- Removing And Installing/replacing Left Pressure Pipe (charge Air Hose) (M57TU)2
- Removing And Installing / Replacing Right Pressure Pipe (charge Air Hose) (M57T22
- Removing And Installing/replacing Right Pressure Pipe (charge Air Hose)2
- 71 Exhaust Gas Recirculation › Removing And Installing Or Replacing EGR Cooler (N47)2
74 El.valve For Exh. Gas Recirculation4 pages
78 Emission Control, Oxygen Sensor6 pages
12 Engine Electrical System (M57T2)54 pages
- 21 Preheating Relay › Removing And Installing/replacing Relay For Glow Elements (M57TU, M57T2)
31 Alternator With Drive And Mounting11 pages
- 32 Regulator › Replacing Voltage Regulator23
41 Starter With Mounting2 pages
61 Oil Pressure-oil Temperature-oil Gauge2 pages
- 62 Coolant Temperature › Removing And Installing/replacing Pressure Sensor For Exhaust System (M57TU TOP)
90 Control Unit Box4 pages
13 Fuel System (M57T2)59 pages
51 Inj.pump, Regulator, Mixt.regulator8 pages
53 Injection Nozzle And Lines18 pages
- Cleaning Injector Ducts (M67 / M57 / M57TU / M47TU)23
- Layout Of Common Rail System (M57TU, M57T2)
- Removing And Installing/replacing Pressure Accumulator Of Fuel Injection System2
- Replacing All Pressure Lines (M57T2)2
- Replacing Pressure Line (between High-pressure Pump And Pressure Accumulator) (M2
- Removing And Installing/replacing All Injectors Of Fuel Injection System (M57T2)2
- Replacing All Leakage Oil Lines (M57T2)2
- Removing And Installing/replacing Pressure Sensor On Pressure Accumulator Of Fue2
- Replacing Pressure Regulator On Pressure Accumulator Of Fuel Injection System (M2
- 61 Electronic Control Unit › Replacing Control Unit (DDE) M57TU, M57T22
62 Sensor For Control Unit15 pages
- Replacing Intake Air Temperature Sensor (N47, N47s, M57T2)2
- Replacing Coolant Temperature Sensor (M57TU, M57T2)
- Replacing Primary Catalytic Converter Temperature Sensor (M57T2)2
- Replacing Diesel Particulate Filter Temperature Sensor (M57T2)2
- Replacing Charge-air Pressure Sensor (M57TU, M57T2)
- Removing And Installing/replacing Air-mass Flow Sensor (M47T2, M57T2)
- Removing And Installing/replacing Air-mass Sensor (M57TU TOP)
- Removing And Installing/replacing Pressure Sensor For Exhaust System (M57TU TOP)
- Replacing Crankshaft Pulse Generator (M47TU / M57TU / M47T2 / M57T2)
- Replacing Camshaft Pulse Generator (M57, M57TU, M57T2)
- Replacing Control Sensor (M57T2)2
16 Fuel Supply System (M57T2)33 pages
0 Fuel Pick-up, Cleaning System8 pages
11 Fuel Tank With Mounting5 pages
12 Fuel Transfer, Sensor For Gauge14 pages
- Checking Repumping Function Of Suction-jet Pump With BMW Diagnosis System
- Removing And Installing/replacing Fuel Gauge Sensor (complete Right Sensor Unit)23
- Removing And Installing/replacing Fuel Gauge Sensor (complete Left Sensor Unit)234
- Removing And Installing/replacing Carbon Canister
- Removing And Installing/replacing Carbon Canister With DM-TL
- Removing And Installing/replacing Fuel Filter With Fuel Level Sensor234
- 13 Fuel Ventilation › Removing And Installing/replacing Tank Leak Diagnosis Module
17 Cooling System (M57T2)30 pages
- 10 Radiator, Expansion Tank, Pipes › Checking Cooling System For Water Leaks (M57TU, M47T2, M57T2, N47)2
11 Engine Radiator With Attachment7 pages
- Removing And Installing Radiator (M57TU)
- Replacing Fan Cowl With Electric Fan (M47T2, M57T2, N47, N46T)
- Replacing Fan Cowl With Electric Fan (M57TU)
- Removing And Installing / Replacing Module Carrier2
- Removing And Installing/replacing Coolant Expansion Tank (M57TU, M57T2, N47)
- Removing And Installing/replacing Cooling Loop For Power Steering
- 21 Oil Cooler › Flushing Oil Cooler With Lines (automatic Transmission)2345
- 51 Charge Air Cooler With Mount › Removing And Installing Or Replacing Intercooler (M47T2, M57T2, N47)
18 Exhaust System (M57T2)19 pages
0 Exhaust System, Complete6 pages
12 Mufflers, Petrol5 pages
- 31 Exhaust Pipe With Mounting › Removing And Installing/replacing Diesel Particulate Filter (M57T2)
- 40 Exhaust Manifold With Integrated Catalyt › Removing And Installing, Sealing Or Replacing Exhaust Manifold (M57T2top)
22 Engine And Gearbox Suspension10 pages
32 Transmission Suspension, Autom. Transmis3 pages
24 Automatic Transmission (AUT)42 pages
0 Transmission Assembly20 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Checking/topping Up Fluid Level In Automatic Transmission (GA6HP19Z)2
- Transmission Designations23
- Universal Transmission Bracket
- Universal Transmission Retaining Bridge
- Topping Up Fluid Additive In Event Of Friction Coefficient Fluctuations During G23
- Removing And Installing Automatic Transmission (6HP26Z) M57T22345
- Installing Replacement Transmission (GA6HP26Z/6HP32Z)2
- 11 Transmission Case, Oil Sump › Removing And Installing/sealing Or Replacing Transmission Sump (GA6HP26Z/6HP32Z)23
- 12 Torque Converter Bearing, Seal › Replacing Torque Converter Shaft Seal (GA6HP26Z/6HP32Z)2
- 13 Extension Housing, Bearings, Seal › Replacing Output Flange Shaft Seal (GA6HP26Z/6HP32Z)23
- 14 Mechanical Attachments › Replacing Selector Shaft Seal (GA6HP26Z/6HP32Z)23
- 31 Oil Pump › Replacing Torque Converter Shaft Seal (GA6HP26Z/6HP32Z)2
- 32 Regulator › Manual Emergency Release Of Transmission Lock2
34 Shift Valves, Parking Lock4 pages
- 40 Torque Converter › Removing And Installing/replacing Torque Converter (GA6HP26Z/6HP32Z)2
- 50 Shift Function › Replacing Emergency Actuator
25 Gear Shift Mechanism (AUT) › 16 Centre Shift, Automatic Transmission5 pages
26 Propeller Shaft12 pages
27 Transfer Box › 0 Transfer Case, General3 pages
31 Front Axle53 pages
0 General12 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle Overview
- Layout Of Spring Strut Shock Absorber
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Instructions (damage To Suspension)
- Notes On Repairing Threads2
10 Front Axle Suspension7 pages
- Removing And Installing Complete Front Axle (with Spring Strut Shock Absorber)23
- Removing And Installing/replacing Reinforcement Plate
- Removing And Installing / Replacing Front Underbody Protection
- Removing And Installing/replacing Rear Underbody Protection
- Removing And Installing/replacing Front Left Or Right Structural Tension Strut
11 Front Sub-frame5 pages
21 Wheel Bearings And Stub Axle3 pages
31 Spring Strut11 pages
35 Stabiliser Bar4 pages
90 Troubleshooting3 pages
32 Steering And Wheel Alignment132 pages
0 Electronic Chassis Alignment36 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Front Axle - Steering: Wheel/chassis Alignment Check Must Be Carried Out After T
- Instructions (damage To Suspension)
- Overview Of Steering
- Overview Of Steering Wheel / Casing Components / Lock Cylinder
- Chassis/wheel Alignment Check Procedure
- General Chassis And Suspension Definitions
- General Information And Definitions2
- Identification Of Suspension Without Label
- Identifying Suspension From Label On Front Axle
- Information On Replacing Steering Gear After Accident Damage2
- Moving Vehicle Into Design Position
- Moving Vehicle Into Normal Position
- Performing Rim Runout Compensation
- Test Conditions For Chassis/wheel Alignment Check
- Troubleshooting After Wheel/chassis Alignment Check On Front Axle2
- Troubleshooting After Wheel/chassis Alignment Check On Rear Axle
- KDS Chassis/wheel Alignment Check With Load Up To Design Position23
- KDS Chassis/wheel Alignment Check With Ride-height Measurement Without Load23
- Adjusting Toe-in And Camber On Front Axle23
- Adjusting Rear Axle
- Adjustment For Active Front Steering
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Carrying Out Steering Angle Sensor Adjustment
13 Steering Gear With Servo Unit11 pages
- Information On Replacing Steering Gear After Accident Damage2
- Bleeding Power Steering (version With Dynamic Drive)2
- Bleeding Power Steering Unit2
- Removing And Installing/replacing Power Steering Gear23
- Removing And Installing/replacing Active Front Steering Power Steering Gear
- Removing And Installing/replacing EH Converter For Servotronic
21 Steering Arms, Tie Rods, Steer. Damper6 pages
31 Steering Column11 pages
- Removing And Installing / Replacing Upper Section Of Steering Column Trim2
- Removing And Installing/replacing Front Section Of Steering Column Cover
- Removing And Installing / Replacing Lower Section Of Steering Column Trim
- Removing And Installing / Replacing Lower Section Of Steering Spindle2
- Removing And Installing/replacing Steering Angle Sensor
- Removing And Installing/replacing Steering Column Lock
- Removing And Installing/replacing Steering Column2
- Replacing Steering Spindle Sleeve
34 Steering Wheel For Airbag11 pages
- Removing And Installing / Replacing Airbag Unit2
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Notes On Scrapping BMW Vehicles With Gas Generators (vehicles With Gateway Modul2
- Safety Regulations For Handling Components With Gas Generators2
- Procedure After Airbag Triggering As Result Of An Accident23
41 Pump And Oil Supply40 pages
- Bleeding Power Steering (version With Dynamic Drive)2
- Bleeding Power Steering Unit2
- Instructions For Removing And Installing Ear Clips2
- Instructions For Using Special Tool 32 4 0002
- Notes On Hydraulic Line With Quick-connect Coupling2
- Replacing Level Switch For Dynamic Drive Fluid Reservoir
- Servotronic Troubleshooting
- Checking Function Of Power Steering Vane Pump23
- Removing And Installing (replacing) Power Steering Pump For Power Steering Gear
- Removing And Installing Power Steering Pump For Power Steering Gear With Dynamic23
- Removing And Installing (replacing) Vane Pump For Power Steering (M57T2)2
- Replacing Power Steering Vane Pump2
- Removing And Installing/replacing Belt Pulley On Vane Pump For Power Steering
- Removing And Installing/replacing Fluid Reservoir For Power Steering2
- Removing And Installing / Replacing Fluid Reservoir For Power Steering With Dyna2
- Replacing Suction Line For Power Steering (M57T2)2
- Replacing Pressure Line For Power Steering (M57T2)2
- Replacing Pressure Line For Power Steering (N52, N53)2
- Replacing Cooler Return Line For Power Steering2
- Replacing Return Line For Power Steering (M57T2)2
- Replacing Return Line For Power Steering (N52, N53)2
- 90 Troubleshooting › Troubleshooting On Steering
33 Rear Axle91 pages
0 General18 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Rear Axle Layout
- Information On Replacing Shock Absorbers
- Instructions (chassis Components Made Of Aluminium)
- Notes On Repairing Threads
- Rear Axle: Wheel/chassis Alignment Check Must Be Carried Out After The Following
- Overview Of Rear Differential/output Shafts
- Overview Of Rear Axle Carrier With Rubber Mounts
- Overview Of Steering Links
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
11 Final Drive With Cover12 pages
- Replacing Rear Cover Gasket On Rear Differential (188L / 188LW)
- Replacing Rear Cover Gasket On Rear Differential (215K)
- Replacing Rear Cover Gasket On Rear Differential (215L / 215LW)
- Replacing Shaft Seal For Input Flange On Rear Differential234
- Replacing Drive Flange On Left Or Right Of Rear Differential2
- Replacing Shaft Seal For Drive Flange Left Or Right2
- Replacing Rear Cover Gasket On Rear Differential
32 Control Arms And Struts14 pages
- Removing And Installing/replacing Left Or Right Push Rod/integral Link2
- Removing And Installing/replacing Left Or Right Swinging Arm2
- Replacing One Upper Control Arm2
- Replacing A Guide Arm2
- Replacing A Ball Joint In Lower Steering Knuckle / Wheel Carrier2
- Removing And Installing / Replacing A Steering Knuckle / Wheel Carrier2
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
- Removing And Installing/replacing Cross Strut/rear End
53 Springs With Suspension2 pages
90 Troubleshooting2 pages
34 Brakes73 pages
0 Brake Testing And Bleeding12 pages
- General Information2
- General Information On Braking In New Brake Discs / Brake Pads
- Checking Brakes On Test Stand
- Checking Thickness Of Brake Pad
- Parking Brake Function Check
- Checking Brake Booster (low-pressure Test)
- Replacing Fluid In ABS/ASC-T Brake System2
- Bleeding Brake System With DSC2
- Checking Service Brake: High- And Low-pressure Tests
11 Front Brakes13 pages
- Overview Of Front Brake
- Removing And Installing/replacing Brake Linings On Both Front Disc Brakes234
- Removing And Installing/replacing Both Front Brake Discs2
- Removing And Installing / Replacing A Brake Carrier / Brake Guard Plate At Front
- Removing And Installing/replacing Left Or Right Front Brake Caliper
- Overhauling Left Or Right Front Brake Caliper (brake Caliper Removed)23
- Precision-turning Both Front Brake Discs On Both Sides
21 Rear Brakes14 pages
- Overview Of Rear Brake
- Removing And Installing / Replacing A Brake Carrier / Brake Guard At Rear
- Removing And Installing Or Replacing Brake Linings On Both Rear Disc Brakes234
- Removing And Installing Or Replacing Both Rear Brake Discs2
- Removing And Installing Or Replacing Left Or Right Rear Brake Caliper2
- Overhauling Left Or Right Rear Brake Caliper (brake Caliper Removed)23
- Precision-turning Both Rear Brake Discs On Both Sides
- 35 Electrical Components - Wear Indicator › Replacing A Brake Pad Sensor
41 Parking Brake14 pages
- General Information On Braking In New Brake Discs / Brake Pads
- Adjusting Handbrake234
- Overview Of Parking Brake
- Removing And Installing / Replacing Handbrake Lever2
- Removing And Installing / Replacing Both Handbrake Bowden Cables2
- Removing And Installing/replacing All Handbrake Shoes2
- Removing And Installing/replacing Expander Lock For Handbrake Shoes2
52 Electronic Components9 pages
- Replacing A Brake Pad Sensor
- Overview Of Electronic Components
- Removing And Installing / Replacing DSC Control Unit2
- Replacing One Front Pulse Generator
- Replacing A Rear Pulse Generator
- Removing And Installing / Replacing DSC Sensor
- Removing And Installing/replacing Front Pressure Sensor For ACC
- Removing And Installing / Replacing Rear Pressure Sensor For ACC
36 Wheels With Tyres23 pages
37 Integrated Suspension Systems32 pages
0 General9 pages
- Danger Of Poisoning If Oil Is Ingested/absorbed Through The Skin
- Risk Of Injury If Oil Comes Into Contact With Eyes And Skin
- Safety Instructions For Handling Oil
- Raising Vehicle With Trolley Jack
- Overview Of Integrated Suspension Systems (front Axle)
- Overview Of Integrated Suspension Systems (rear Axle)
- Initial Operation With Test Run Of Dynamic Drive23
11 Front Control And Suspension Elements3 pages
- 12 Rear Control And Suspension Elements › Removing And Installing/replacing Rear Active Stabilizer23
22 Pump Assembly With Container3 pages
- 90 Troubleshooting › Troubleshooting On Dynamic Drive (ARS)23
41 Body (CONVER)163 pages
0 Body76 pages
- Contents Of Body, General2
- Bonding Aluminium Parts23
- Bonding Plastic Parts
- Bonding Steel Parts2
- Corrosion Protection2
- EMC Screws
- Frame Alignment Control Dimensions, Body23
- Gap Dimensions, Body23
- General Cementing Instructions
- Grinding Aluminum Parts
- Grinding Steel Parts
- Handling Airbags And Restraint Systems
- Handling Electrical And Electronic Equipment
- Information / Warning Labels
- Information On Hazards
- Information On Vehicle Protection
- Installation Of A Cavity Seal With Cavity Foam2
- Installing A Cavity Bulkhead (expanded)
- Installing A Cavity Bulkhead (not Expanded)
- Materials Science23
- Notes On Repairing Threads
- Opening Adhesive Bonds
- Opening Weld Joints
- Overview Of Front End Repair Elements234
- Position Of Shaped Parts For Cavity Bulkhead
- Quality Standard
- Riveting Aluminium Parts2
- Riveting Steel Parts
- Safety At Work2
- Sectional Repair Of Extruded Aluminium Sections With Repair Elements2
- Spot-weld Bonding Steel Parts
- Stamping Vehicle Identification Number2
- Straightening Aluminium Parts2
- Straightening Steel Parts2
- Use Of Materials In Outer Shell2
- Vehicle Identification Number, General
- Welding And Soldering Steel Parts23
- Welding In Reinforcement Plate (steel Plate)2
- Workshop Equipment2
- Installation Solution For Straight Shank/hexagon Rivet Nut23
- Repair Solution For Straight Shank/hexagon Rivet Nut23
- Notes On Cavity Foam2
- Service Position Of Convertible Top Compartment Lid2
- General Instructions On Painting
11 Support Members29 pages
- Replacing Front Section Of Engine Support To Left Wheel Arch23456
- Replacing Left Engine Carrier (partial Replacement Before Front Axle)2
- Replacing Front Section Of Left Engine Support2345
- Replacing Cover For Left Or Right Frame Side Member (partial Replacement Between2
- Replacing Cover For Left Frame Side Member (door Pillar And Rear Side Panel Remo23
- Replacing Left Support Carrier234
- Partial Replacement, Bulkhead, Left (engine Carrier Front Section Removed)2
- Partial Replacement, Bulkhead, Right (engine Carrier Front Section Removed)2
- Replacing Left Equipment Carrier Partition Wall (wheel Arch Removed)
- Replacing Rear Left Side Panel2
- 12 Luggage Compartment Floor › Replacing Complete Rear Luggage Compartment Floor (tail Panel Removed)23
14 Wheel Wells18 pages
- Overview Of Front End Repair Elements234
- Stamping Vehicle Identification Number2
- Vehicle Identification Number, General
- Partial Replacement, Bulkhead, Left (engine Carrier Front Section Removed)2
- Partial Replacement, Bulkhead, Right (engine Carrier Front Section Removed)2
- Replacing Left Equipment Carrier Partition Wall (wheel Arch Removed)
- Replacing Front Left Wheel Arch234
- Replacing Rear Left Outer Wheel Arch Section (rear Left Side Panel Removed)2
- 32 Dash Cowl › Replacing Front Left Door Pillar (front Side Panel Removed)23
- 33 Front Trim Panel › Replacing Front Wall2
51 Front Side Doors4 pages
61 Front Lid3 pages
51 Body Equipment (CONVER)294 pages
0 General17 pages
- Overview Of Front Door
- Instructions On Sticking Film2
- Notes On Bonding/attaching Components With Double-sided Adhesive Tape
- Notes On Fitting Window Guide Seals2
- Safety Instructions For Working On Cars With Airbag Systems
- Service Position Of Convertible Top Compartment Lid2
- Service Position Of Engine Hood/bonnet2
- Overview Of Front Bumper
- Survey Of Rear Bumper
- Overview Of Storage Compartment (centre Console)
- Overview Of Convertible Top Compartment Lid
- Overview Of Front Door Locks
- Overview Of Instrument Panel
11 Front Bumper15 pages
- Overview Of Front Bumper
- Installing/replacing License Plate (without Base)
- Removing And Installing/replacing Carrier For Front Bumper Trim2
- Removing And Installing Front Bumper Trim23
- Removing And Installing Front Bumper Trim23
- Replacing Front Bumper Trim
- Replacing Baseplate For Number/license Plate2
- Removing And Installing/replacing Trim Grill In Bumper Trim
- Replacing Left Or Right Bracket For Front Bumper
12 Rear Bumper10 pages
- Survey Of Rear Bumper
- Removing And Installing / Replacing Carrier For Rear Bumper Trim
- Removing And Installing Rear Bumper Trim2
- Replacing Rear Bumper Trim
- Removing And Installing/replacing Baseplate For Number/license Plate (US)
- Replacing Bracket For Rear Bumper At Left Or Right
- Removing And Installing / Replacing Deformation Element On Bumper Carrier On Lef
- Removing And Installing/replacing Guide For Rear Bumper
- Removing And Installing / Replacing Guide For Bottom Rear Bumper
13 Trim, Covers, Handle Trim10 pages
- Replacing Front Radiator Grill, Middle Left Or Right2
- Removing And Installing/replacing Front Radiator Grille, Middle Left Or Right
- Removing And Installing/replacing Trim On Front Left Or Right Side Panel
- Removing And Installing/replacing Cowl Panel Cover
- Removing And Installing/replacing Trim Strip On Roof Gutter At Left Or Right
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Cowl Panel Seal
16 Mirrors-covers-ashtrays-shelves-trays39 pages
- Overview Of Storage Compartment (centre Console)
- Cementing Of Mirror Base2
- Removing And Installing/replacing Centre Armrest Carrier2
- Removing And Installing/replacing Mounting For Cup Holder At Front
- Removing And Installing/replacing Mirror On Left Or Right Front Door
- Replacing Mirror Glass2
- Removing And Installing/replacing Housing On Left Or Right Door Mirror
- Removing And Installing/replacing Retaining Ring On Left Or Right Door Mirror
- Removing And Installing/replacing Interior Rearview Mirror (overview)2
- Removing And Installing/replacing Interior Rearview Mirror (with Autobeam)23
- Removing And Installing/replacing Interior Rearview Mirror (with Japanese Toll M23
- Removing And Installing/replacing Interior Rearview Mirror (with Rain Sensor)23
- Removing And Installing Or Replacing Sun Visor And Left Or Right Counter-support
- Removing And Installing/replacing (both) Covers For Centre Armrest
- Removing And Installing Storage Compartment2
- Replacing Storage Compartment
- Removing And Installing/replacing Rear Cup Holder
- Removing And Installing/replacing Sport Switch Trim (SPORT Button)
- Removing And Installing/replacing Trim For Preselector Lever (gearshift Lever)2
- Removing And Installing Trim For Center Console
- Removing And Installing/replacing Lock Cylinder For Storage Box
- Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
- Removing And Installing Right Glovebox With Housing (without Active Knee Protect
- Removing And Installing Right Glovebox With Housing (with Active Knee Protection
- Replacing Trim For Front Roofliner
- Overview Of Instrument Panel
17 Lids20 pages
- Replacing Cover Bowl2
- Overview Of Convertible Top Compartment Lid
- Replacing Front Seal On Convertible Top Compartment Lid2
- Removing And Installing/replacing Trim On Convertible Top Compartment Lid234
- Removing And Installing/replacing Middle Seal On Convertible Top Compartment Lid2
- Removing And Installing/replacing Left Or Right Seal On Convertible Top Compartm
- Removing And Installing/replacing Bump Stop With Ejector For Filler Flap
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
- Adjusting Rear Lid Lock (lower Section Of Rear Lid Lock)2
- Removing And Installing/replacing Rear Lid Lock (upper Section)
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
- 20 Lock Cylinders, Assembly › Removing And Installing/replacing Lock Cylinder For Passenger Airbag Deactivatio2
21 Front Door Locks, Handles, Fittings30 pages
- Overview Of Front Door
- Removing Window Cavity Cover Strip With Special Tool 00 9 324 At Front Or Rear2
- Overview Of Front Door Locks
- Replacing Door Detent (lock Striker), Front Left Or Right
- Adjusting Front Left Or Right Door Detent (lock Wedge)
- Removing And Installing/replacing Door Lock In Left Or Right Front Door23
- Removing And Installing/replacing Carrier For Left Or Right Outside Door Handle2
- Removing And Installing/replacing Carrier For Left Or Right Outside Door Handle
- Removing And Installing/replacing Complete Lock Cylinder In Left Or Right Front
- Blocking, If Necessary Initializing, Car Key In Immobilizer Control Module
- Removing And Installing Or Replacing Outside Handle From Left Or Right Front Doo23
- Removing And Installing/replacing Cover On Outside Handle2
- Removing And Installing Or Replacing Inside Door Opener In Left Or Right Front D2
- Removing And Installing/replacing Bowden Cable For Outside Door Handle On Left O
- Removing And Installing/replacing Bowden Cable For Inside Door Opener On Left Or
- Removing And Installing Or Replacing Door Retainer On Left Or Right Front Door2
- Removing And Installing Or Replacing Window Cavity Cover Strip On Outside Of Lef2
- Removing And Installing/replacing Window Cavity Cover Strip On Inner Front Door2
- Removing And Installing/replacing Cover (seal) On Front Door At Bottom Left Or R
23 Hood Latch, Locks10 pages
- Adjusting/replacing Bump Stops2
- Adjusting Hood/bonnet Lock
- Removing And Installing/replacing Right Engine Hood Lock
- Removing And Installing/replacing Left Hood/bonnet Lock
- Adjusting Left Or Right Striker On Engine Hood
- Removing And Installing/replacing Arrester Hook On Engine Hood
- Removing And Installing/replacing Cable For Front Engine Hood Locks (to Passenge
- Removing And Installing/replacing Cable For Hood/bonnet Locks (to Locks)
- Removing And Installing/replacing Left Or Right Gas Strut For Engine Bonnet/hood
24 Trunk Latch, Locks8 pages
- Adjusting Rear Lid Lock (lower Section Of Rear Lid Lock)2
- Removing And Installing/replacing Rear Lid Lock (upper Section)
- Removing And Installing/replacing Striker For Rear Lid Lock
- Removing And Installing/replacing Button For Rear Lid Actuation2
- Removing And Installing/replacing Side Left Or Right Buffer Stops On Rear Lid
- Removing And Installing Or Replacing Left Or Right Gas Strut For Rear Lid
31 Front And Rear Window17 pages
- 33 Front Electrically Operated Windows › Removing And Installing (replacing) Power Window Unit In Left Or Right Front Doo23
37 Electrical Power Windows, Body13 pages
- Removing And Installing Complete Rear Left Or Right Power Window Unit2
- Replacing Rear Left Or Right Power Window Unit
- Adjusting Rear Left Or Right Side Windows234
- Replacing Rear Left Or Right Side Window2
- Removing And Installing/replacing Outer Window Cavity Cover Strip For Door Windo2
- Removing And Installing/replacing Window Cavity Cover Strip For Door Window, Rea2
41 Front Door Trim Panel With Arm Rest11 pages
- Overview Of Front Door
- Removing And Installing Left Or Right Front Door Trim Panel234
- Replacing Front Left Or Right Door Trim Panel
- Removing And Installing/replacing Upper Section On Front Armrest
- Removing And Installing/replacing Trim On Armrest On Left Or Right Rear Door
- Removing And Installing/replacing Sound Insulation In Front Door, Left Or Right23
43 Side Covering With Armrests13 pages
- Removing And Installing/replacing Trim On Armrest Of Left Or Right Side Trim Pan
- Removing And Installing Rear Left Or Right Side Trim Panel
- Replacing Rear Left Or Right Side Trim Panel
- Removing And Installing Rear Left Or Right Side Trim Panel Upper Section
- Replacing Rear Left Or Right Side Trim Panel Upper Section
- Removing And Installing/replacing Rear Left Or Right Lower Side Trim Section
- Removing And Installing/replacing Cover For Frame Aperture On Left Or Right
- Removing And Installing/replacing Side Trim Panel, Footwell, On A-pillar, Left
- Removing And Installing / Replacing Side Trim Panel, Footwell, On A-pillar, Righ
- Removing And Installing/replacing Panel For Roof Pillar At Front (A-pillar), Lef
- Removing And Installing/replacing Trim On Air Outlet Grille
- Removing And Installing/replacing Front Air Outlet Trim Grill2
44 Roof Trim Panel3 pages
45 Instrument Cluster Trim Panel14 pages
- Overview Of Instrument Panel
- Removing And Installing Instrument Panel Trim2
- Replacing Instrument Panel Trim2
- Removing And Installing Speaker Frame On Panel For Instrument Panel At Top
- Removing And Installing/replacing Panel For Active Knee Protector On Left
- Removing And Installing/replacing Bottom Right Trim For Instrument Panel
- Removing And Installing/replacing Panel For Pedals
- Removing And Installing (replacing) Center Trim For Instrument Panel
- Replacing Center Trim For Instrument Panel (fresh-air Grill)
- Removing And Installing Decorative Strip On Left Instrument Panel
- Removing And Installing (replacing) Right Decorative Strip On Instrument Panel2
46 Parcel Shelf Trim Pan.-roller Sun Blind4 pages
47 Floor-lugg.comp.-eng.comp.tr.panels20 pages
- Removing And Installing/replacing Trim On Air Outlet Grille
- Removing And Installing/replacing Front Air Outlet Trim Grill2
- Removing And Installing/replacing Front Left Or Right Lip
- Removing And Installing/replacing Left Or Right Underbody Panelling
- Removing And Installing/replacing Rear Left Or Right Ram-air Lip
- Removing And Installing/replacing Front (inside) Left Or Right Entrance Cover St
- Removing And Installing / Replacing Finishing Strip At Front Left Or Right Entra
- Removing And Installing/replacing Illuminated Finishing Strip On Front Left Or R2
- Removing And Installing/replacing Luggage Compartment Floor Trim Panel
- Removing And Installing/replacing Panel For Luggage Compartment Partition
- Removing And Installing / Replacing Left Luggage Compartment Wheel Arch Trim
- Removing And Installing/replacing Right Luggage Compartment Wheel Arch Trim
- Removing And Installing/replacing Upper Luggage Compartment Trim Panel
- Removing And Installing/replacing Stowage Net In Front Footwell
- Removing And Installing / Replacing Front Carpet For Passenger Compartment
- Removing And Installing/replacing Rear Carpet On Seat Pan
- Removing And Installing / Replacing Front Underbody Protection
- Removing And Installing/replacing Rear Underbody Protection
48 Front Lid Insulation Lining4 pages
- 49 Rear Lid Trim Panel › Removing And Installing Or Replacing Trim For Rear Lid
71 Gaskets-seals, Loose Body Components16 pages
- Removing And Installing/replacing Cowl Panel Cover
- Replacing Front Left Or Right Rubber Guide For Left Or Right Door Window
- Removing And Installing/replacing Front (bottom) Right Wheel Arch Trim
- Removing And Installing/replacing Front Left Or Right Wheel Arch Cover2
- Removing And Installing/replacing Rear Left Or Right Wheel Arch Cover
- Removing And Installing/replacing Cowl Panel Seal
- Removing And Installing/replacing Tension Strut On Spring Strut Dome2
- Removing And Installing/replacing Front Left Or Right Structural Tension Strut
- Removing And Installing/replacing Rear Middle Water Gutter Trim (rear Lid)
- Removing And Installing/replacing Rear Water Gutter Trim (rear Lid) On Left Or R
- Removing And Installing Or Replacing Panel For Cover On Left Or Right Side Membe2
- Removing And Installing/replacing Left Or Right Tension Strut (on Rear Axle)
- Removing And Installing/replacing Cross Strut/rear End
52 Seats96 pages
14 Front Seat, Normal, Electric38 pages
- Removing And Installing/replacing Belt Guide Trim On Left Or Right Front Seat (n2
- Removing And Installing/replacing Seat Pan And Flex Mat On Left Or Right Front S23
- Removing And Installing/replacing Trim For Release Handle On Left Or Right Front
- Removing And Installing Left Or Right Front Seat (normal / Electric)2
- Replacing Backrest Release Cable For Front Left Or Right Seat234
- Removing And Installing/replacing Backrest Frame On Front Left Or Right Seat (no23
- Removing And Installing/replacing Release Handle On Left Or Right Front Seat (no
- Replacing Lumbar Cushion On Front Left Or Right Seat2
- Removing And Installing/replacing Valve Housing For Front Left Or Right Lumbar S
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Replacing Gas Cartridge (pyroactivator) For Crash-active Head Restraint On Front234
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (normal
- Removing And Installing/replacing Front Left Or Right Crash-active Head Restrain2
- Replacing Seat Cover For Left Or Right Front Seat (normal/electric)
- Replacing Backrest Cover For Front Left Or Right Seat (normal/electric)23
- Replacing Support For Left Or Right Front Seat (normal/electric)
- Replacing Padding For Left Or Right Front Seat Backrest (normal/electric)
- Removing And Installing/replacing Carrier For Outer Cover On Left Or Right Front
- Removing And Installing/replacing Outer Covers On Left Or Right Front Seat (spor23
- Removing And Installing/replacing Inner Cover On Front Left Or Right Seat (sport
16 Front Seat, Sports, Electric49 pages
- Removing And Installing/replacing Seat Pan And Flex Mat On Left Or Right Front S23
- Removing And Installing/replacing Trim For Release Handle On Left Or Right Front
- Removing And Installing Left Or Right Front Seat (normal / Electric)2
- Replacing Backrest Release Cable For Front Left Or Right Seat234
- Removing And Installing/replacing Backrest Frame On Front Left Or Right Seat (no23
- Removing And Installing/replacing Release Handle On Left Or Right Front Seat (no
- Replacing Lumbar Cushion On Front Left Or Right Seat2
- Removing And Installing/replacing Valve Housing For Front Left Or Right Lumbar S
- Removing And Installing/replacing Rear Panel On Left Or Right Front Seat Backres
- Replacing Gas Cartridge (pyroactivator) For Crash-active Head Restraint On Front234
- Removing And Installing Or Replacing Front Left Or Right Head Restraints (normal
- Removing And Installing/replacing Front Left Or Right Crash-active Head Restrain2
- Replacing Backrest Cover For Front Left Or Right Seat (normal/electric)23
- Replacing Padding For Left Or Right Front Seat Backrest (normal/electric)
- Removing And Installing/replacing Carrier For Outer Cover On Left Or Right Front
- Removing And Installing/replacing Outer Covers On Left Or Right Front Seat (spor23
- Removing And Installing/replacing Inner Cover On Front Left Or Right Seat (sport
- Removing And Installing/replacing Thigh Support Holder On Front Left Or Right Se23
- Replacing Seat Cover For Left Or Right Front Seat (sports/electric)234567891011
- Replacing Support For Left Or Right Front Seat (sport/electric)
24 Rear Seat, Normal9 pages
- Removing And Installing / Replacing Ski Bag With Casing
- Removing And Installing Or Replacing Rear Seat
- Removing And Installing / Replacing Backrest
- Removing And Installing Complete Armrest For Rear Seat Backrest
- Removing And Installing / Replacing Rear Head Restraints
- Replacing Seat Cover For Rear Seat2
- Replacing Backrest Cover For Left Or Right Rear Seat2
54 Slide-tilt Sunroof And Convertible Top (CONVER)77 pages
- 10 Sunroof › Repair Instructions For Bonded Seals23
- 25 Soft-top Flap › Service Position Of Convertible Top Compartment Lid2
- 31 Convertible Top Linkage-operation › Notes On Convertible Top2
34 Motor-operated Convertible Top65 pages
- Adjusting Both Bowden Cables For Convertible Top Compartment Lid Lock
- Bleeding Hydraulic System
- Mounting Of Hydraulic Components2
- Opening/closing Convertible Top In Event Of A Technical Fault2
- Repair Instructions For Hydraulic System Of Convertible Top And Convertible Top23
- Topping Up/extracting Fluid, Checking Fluid Level2
- Checking Function Of EH Convertible Top
- Removing And Installing/replacing Hydraulic Unit For Convertible Top Drive2
- Removing And Installing/replacing Left Hydraulic Cylinder For Convertible Top Co2
- Removing And Installing/replacing Right Hydraulic Cylinder For Convertible Top C
- Removing And Installing/replacing Hydraulic Cylinder For Left Clamping Bar2
- Removing And Installing/replacing Hydraulic Cylinder For Right Clamping Bar
- Removing And Installing/replacing Left Or Right Hydraulic Cylinder For Convertib2
- Removing And Installing/replacing Convertible Top Compartment
- Removing And Installing/replacing Complete Hydraulic System For Convertible Top
- Removing And Installing/replacing Bowden Cables For Convertible Top Compartment
- Adjusting Left Or Right Convertible Top Compartment Lid Lock
- Removing And Installing Left Or Right Control Element
- Adjusting (tensioning) Control Element
- Adjusting Convertible Top2
- Removing And Installing Complete EH Convertible Top234
- Replacing Convertible Top Fabric2345
- Removing And Installing/replacing Cowl Panel Trim (convertible Top Fastener)
- Removing And Installing Or Replacing Headlining In Convertible Top234
- Replacing All Rubber Window Seals On Convertible Top Frame23
- Removing And Installing/replacing Left Or Right Base Plate
- Removing And Installing Left Convertible Top Fastener
- Removing And Installing Right Convertible Top Fastener
- Removing And Installing/replacing All Hydraulic Lines On Convertible Top2
- Removing And Installing Left Or Right Tensioning Belt
- Removing And Installing/replacing Rear Window Module23
- Removing And Installing/replacing Rear Window2
- Removing And Installing/replacing Left Or Right Window Guide For Rear Window
- Removing And Installing/replacing Seal For Rear Window
- Removing And Installing/replacing Power Window Unit (rear Window)
- Removing And Installing Kinematics Box23
- Troubleshooting, Automatic Convertible Top
- 90 Troubleshooting › Troubleshooting, Automatic Convertible Top
61 General Electrical System227 pages
0 Troubleshooting21 pages
- Instructions On Starting Aid
- Version With AFS: Setting Steering Angle (after Reconnecting Vehicle Battery)
- Battery
- Diagnosis For Condition Based Service234
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- General Information On Intelligent Battery Sensor (IBS)
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Treating Cables And Fibre-optic Cables
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
- 11 Wiring Harness › Notes On Handling Wiring Harnesses And Cables
12 Auxiliary Cable15 pages
- General Information On Intelligent Battery Sensor (IBS)
- Replacing Battery Positive Lead (from Battery To Luggage Compartment Connector)2
- Replacing Battery Negative Lead
- Replacing Wiring Harness For Front Bumper2
- Replacing Wiring Harness For Rear Bumper
- Replacing Wiring Harness In Left Or Right Front Door2
- Unlocking And Disconnecting Different Plug Connections23
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
13 Plug Connection, Terminal, Fuse Box57 pages
- Notes On Handling Optical Fibers
- Notes On Handling Wiring Harnesses And Cables
- Repairing Airbag Cables2
- Butt Connector For Repairing A Plug Connection234
- Crimping Stop Parts234
- DME Master Relay Connector
- Installing Fan Connector For Retrofitting/repairs2345
- Special Tools For Wiring Harness Repairs23
- Unlocking And Disconnecting Different Plug Connections23
- Base Of Tab Connector Housings
- Crimping Micro Power Quadlock Contacts (MPQ)
- Crimping Micro Quadlock System Contacts (MQS)2
- Crimping Annular Contacts
- Crimping Optical Fibres2
- Cutting Off, Stripping Insulation And Cutting Optical Fibres To Length23
- Cutting To Length And Stripping Insulation From Cables
- In-line Plugs, 30-pin, Hybrid System MQS/MPQ2
- Opening Plug Housings And Removing Contacts Of Different Plug Systems23
- Plug Housing, LCC Contact (load Current Contact)2
- Relay Carrier
- Removing And Installing/replacing OBD-II Socket
- Removing And Installing/replacing Fibre-optic Cable Connector2
- Repairing Ribbon Cables
- Retaining Bracket
- Socket Housing (radio Plug), Hybrid System MQS/MPQ23
- Treating Cables And Fibre-optic Cables
- Replacing Distribution Box (passenger Compartment)2
- Replacing Distribution Box (luggage Compartment)2
- Removing And Installing/replacing USB/audio Interface Connecting Socket
14 Distribution Box, Power Support Points4 pages
20 Battery22 pages
- Instructions For Disconnecting And Connecting Battery23
- Instructions On Starting Aid
- Version With AFS: Setting Steering Angle (after Reconnecting Vehicle Battery)
- Battery
- Repairing Airbag Cables2
- Safety Instructions For Handling Vehicle Battery
- General Information On Intelligent Battery Sensor (IBS)
- Threshold Values For Battery Inspection Of All Battery (telephone Except For Tel
- AGM Battery234
- Battery Charging
- Battery Open-circuit Current Test
- Disconnecting And Connecting Battery Negative Lead2
- Performing Battery /power Reset: (for Programming/coding Control Unit(s))
- Removing And Installing Or Replacing Battery2
21 Battery-vapour Separator3 pages
- 30 Switches, Horn, Small Devices › Removing And Installing/replacing Actuating Unit For Left Or Right Front Seat
31 Switch46 pages
- Replacing Level Switch For Dynamic Drive Fluid Reservoir
- Overview Of Switches In Steering Wheel Area
- Removing And Installing/replacing Fixture For Steering Column Stalk (from 09/2002
- Removing And Installing/replacing Fixture For Steering Column Stalk (up To 09/202
- Removing And Installing/replacing Volute Spring Cassette (from 09/2005)2
- Removing And Installing/replacing Volute Spring Cassette (up To 09/2005)
- Removing And Installing/replacing Turn Indicator/headlight Dipping Switch
- Removing And Installing/replacing Cruise Control Switch
- Removing And Installing/replacing Ignition Starter Switch
- Removing And Installing/replacing Start/Stop Switch
- Removing And Installing/replacing Switch For Steering Column Adjustment
- Removing And Installing/replacing Lighting Control Unit
- Removing And Installing (replacing) Switch For Passenger Airbag Deactivation
- Removing And Installing/replacing Switch For Windscreen Wipers
- Removing And Installing/replacing Centre Console Switch Cluster
- Removing And Installing/replacing Button For Steering Wheel Heating
- Removing And Installing/replacing Indicator For Front Passenger Airbag Deactivat
- Removing And Installing/replacing Switch For Hazard Warning Flashers/central Loc
- Removing And Installing/replacing Switch For Unlocking Rear Lid
- Removing And Installing/replacing Left Or Right Shift Paddle For SMG Transmissio
- Removing And Installing/replacing Left Or Right Shift Paddle For Automatic Trans
- Replacing Rocker Switch For Side-window Operation
- Removing And Installing/replacing USB/audio Interface Connecting Socket
- Removing And Installing/replacing Emergency Call Button
- Replacing Knob For Controller
- Removing And Installing/replacing Button Unit (for On-board Monitor)
- Removing And Installing (replacing) Front Controller
- Removing And Installing/replacing Switch For Front Lumbar Support
- Removing And Installing/replacing Multifunction Steering Wheel Switches (sport S
- Removing And Installing/replacing Multifunction Steering Wheel Switches (sport S
- Removing And Installing/replacing Steering Wheel Electronics Control Unit2
- Removing And Installing/replacing Lane Departure Warning Motor Electrics (sport
- Removing And Installing/replacing Engine Hood Contact Switch
- Replacing Switch For Door Mirror
- Removing And Installing/replacing Dynamic Driving Switch (Sport Button)
- Replacing Brake Light Switch
- Removing Switch For Glovebox Light
- Removing And Installing/replacing Gear Selector Switch
- Replacing Level Switch For Coolant
- Removing And Installing/replacing Relay/module
- Replacing (removing And Installing) Level Switch For Windscreen Washer Unit
- Carrying Out Steering Angle Sensor Adjustment
- 33 Horn › Removing And Installing/replacing Both Fanfare Horns
35 ECUs, Modules31 pages
- Removing And Installing/replacing Control Unit For Active Front Steering2
- Overview Of Control Units
- Notes On ESD Protection (Electro Static Discharge)23
- Removing And Installing (replacing) Control Unit For Car Access System2
- Removing And Installing (replacing) Power Module
- Removing And Installing/replacing Body Module
- Removing And Installing/replacing Convertible Top Module2
- Removing And Installing (replacing) Rain/light Sensor2
- Removing And Installing (replacing) Control Unit For Left Or Right Front Door
- Removing And Installing (replacing) Light Module2
- Initializing Rain/light Sensor
- Removing And Installing (replacing) Control Unit For Adaptive Headlight
- Removing And Installing/replacing Ring Antenna Of Electronic Immobilizer
- Removing And Installing (replacing) Control Unit For Comfort Access System
- Removing And Installing/replacing Interior Antenna For Comfort Access System (fr
- Removing And Installing/replacing Interior Antenna For Comfort Access System (re
- Removing And Installing/replacing Luggage Compartment Antenna For Comfort Access
- Removing And Installing/replacing Bumper Antenna For Comfort Access System
- Replacing Fogging Sensor2
- Removing And Installing (replacing) USB Hub
- Removing And Installing (replacing) Hands-free Charging Electronics (High)2
- Vehicle Programming And Coding
61 Windscreen Wipers11 pages
67 Headlight Washer System7 pages
- Overview Of Window Wiper Systems
- Removing And Installing/replacing Washer Pump Of Headlight Washer System
- Adjusting Spray Nozzles For Headlight Cleaning System
- Removing And Installing/replacing Spray Nozzles For Left Or Right Headlight Clea2
- Removing And Installing/replacing Spray Nozzle For Night Vision Camera2
62 Instruments9 pages
63 Lights66 pages
12 Headlights15 pages
- Removing And Installing Or Replacing Left Headlight (xenon Headlight)2
- Removing And Installing Right Headlight (xenon Headlight)
- Removing And Installing Left Headlight (adaptive Headlight)
- Replacing Left Headlight (adaptive Headlight)
- Removing And Installing/replacing Right Headlight (adaptive Headlight)
- Replacing Control Unit For Left Xenon Headlight2
- Replacing Control Unit For Right Xenon Headlight
- Replacing Ignition Unit For Left Xenon Headlight2
- Replacing Right Ignition Unit For Right Xenon Headlight
- Replacing Drive/electronics Box For Left Adaptive Headlight2
- Replacing Drive/electronics Box For Right Adaptive Headlight
13 Turn Signal Indicator Lights3 pages
- 17 Fog Lights, Auxiliary Lights › Removing And Installing (replacing) Left Or Right Front Fog Lamp2
21 Rear Light Cluster6 pages
- Replacing A Socket Housing For Left Or Right Rear Light (on Side Panel) (up To 0
- Replacing A Socket Housing For Left Or Right Rear Light (on Bumper Trim) (up To
- Replacing Sealing Frame For Left Or Right Rear Light (on Side Panel)
- Removing And Installing/replacing Left Or Right Rear Light (in Side Panel)
- Removing And Installing/replacing Left Or Right Rear Light (on Bumper Trim)2
- 26 Licence Plate Lights › Removing And Installing/replacing Left Or Right Number/license Plate Light
31 Interior Lights10 pages
- Overview Of Interior Lights
- Removing And Installing/replacing Complete Ceiling Light (front)2
- Removing And Installing/replacing Footwell Light
- Removing And Installing/replacing Mirror Light
- Removing And Installing/replacing Luggage Compartment Light
- Removing And Installing/replacing Glovebox Light
- Removing And Installing/replacing Door Mirror Light
- Replacing LED For Front Door Trim Panel Light
- Replacing LED For Front Inside Door Opener
99 Light Bulbs22 pages
- Instructions For Handling Light Bulbs (exterior Lights)
- Instructions For Replacing Light Bulbs (interior Lights)
- Replacing Halogen Bulb For Left (or Right) High-beam Headlight (up To 09/2007)2
- Replacing Bulb For Left (or Right) Xenon Headlight (from 09/2007)
- Replacing Bulb For Left (or Right) Xenon Headlight (up To 09/2007)
- Replacing Bulb For Front Left (or Right) Side Lights2
- Replacing Halogen Bulb For Left Or Right Front Fog Lamp2
- Replacing Bulb For Front Left (or Right) Direction Indicator (up To 09/2007)
- Replacing Bulb For Auxiliary Turn Signal Light, Front Left Or Right
- Replacing Bulb(s) For Left Or Right Rear Light (on Bumper Trim) (up To 09/2007)
- Replacing Bulb(s) For Left Or Right Rear Light (on Side Panel) (up To 09/2007)
- Replacing Bulb For Left Or Right License Plate Light
- Replacing Bulb For Front Ceiling Light
- Replacing Bulb For Footwell Light (underside Of Door)2
- Replacing Light Bulb For Footwell Light
- Replacing Bulb For Mirror Light
- Replacing Light Bulb For Luggage Compartment Lighting
- Replacing Bulb For Glovebox Light
64 Heating And Air Conditioning90 pages
11 Heater With Operation30 pages
- Installing Servodrive
- Removing And Installing Or Replacing Heater2345
- Replacing Heater Core
- Removing And Installing/replacing Heater - A/C Unit Fan2
- Replacing Controller For Heater/air Conditioner Fan
- Removing And Installing/replacing Auxiliary Water Pump2
- Replacing Water Valve For Heater
- Removing And Installing (replacing) Control Panel For Heater - A/C System
- Removing And Installing/replacing Servodrive For Left Fresh-air/reirculated-air
- Removing And Installing/replacing Servodrive For Right Fresh-air/recirculated-ai
- Replacing Servodrive For Left Ventilation Flap
- Replacing Servodrive For Right Ventilation Flap
- Replacing Servodrive For Left Footwell Flap
- Replacing Servodrive For Right Footwell Flap
- Replacing Servodrive Of Stratification Flap
- Removing And Installing/replacing Servodrive For Defrosting Flap
- Replacing Sensor Fan For Interior Temperature
- Removing And Installing/replacing Temperature Sensor For Heating Unit
- Replacing Temperature Sensor For Cold-air Distributor
- Replacing Evaporator Temperature Sensor
- Replacing Fogging Sensor2
- Removing And Installing/replacing Sensor For Automatic Recirculated Air Control
- Removing And Installing/replacing Solar Sensor
12 Auxil. Heater With Control Elements5 pages
50 Air Conditioning System16 pages
- Air Conditioner Test (R 134a)
- Instructions For Handling Refrigerant R 134a
- Instructions For Handling Refrigerant Oil (for Refrigerant R 134a)2
- Leak Testing With Ultraviolet Additives (UV Additives) (BMW Leak-testing Case)23
- Leak-testing With Leak Tester Device2
- Safety Instructions For Handling Refrigerant R134a
- Safety Instructions For Handling Refrigerant Oil2
- Drawing Off, Evacuating And Filling A/C System (R 134a)2
- Instructions For Opening And Replacing Parts In Refrigerant Circuit2
53 Condenser And Dryer With Lines12 pages
65 Audio, Navigation And Information System77 pages
11 Mono Radio12 pages
- Instructions On Setting The Installation Location On The CD Changer2
- Removing And Installing/replacing CD Changer Magazine2
- Removing And Installing/replacing CD Changer2
- Removing And Installing/replacing Satellite Radio (US Version Only)2
- Removing And Installing DAB Tuner2
- Removing And Installing Digital Radio (IBOS)2
12 Stereo Radio, Amplifier14 pages
- Overview Of Audio Components
- Removing And Installing/replacing Left Or Right Central Bass Speaker2
- Removing And Installing/replacing Amplifier
- Removing And Installing (replacing) Amplifier (Top Hi-fi System)2
- Removing And Installing (replacing) Audio System Controller2
- Removing And Installing/replacing Satellite Radio (US Version Only)2
- Removing And Installing DAB Tuner2
- Removing And Installing Digital Radio (IBOS)2
13 Speaker And Cover7 pages
- Removing And Installing/replacing Speaker (treble Speaker In Quarterlight Mirror2
- Removing And Installing/replacing Speaker (mid-range Speaker, In Instrument Pane
- Removing And Installing/replacing Speaker (mid-range Speaker, Door At Front)
- Removing And Installing/replacing Speaker (tweeter In Rear Side Trim Panel)
- Removing And Installing/replacing Speaker (mid-range Speaker In Rear Side Trim P
- Removing And Installing/replacing Left Or Right Frequency Gate
- 31 Interference Suppression › Removing And Installing/replacing Suppression Filter
- 50 Video And TV Equipment › Removing And Installing (replacing) Video Module For On-board Monitor2
77 Airbag Trigger Device, Diagnosis Unit15 pages
- Notes On Scrapping BMW Vehicles With Gas Generators (central Airbag Control Unit2
- Notes On Scrapping BMW Vehicles With Gas Generators (vehicles With Gateway Modul2
- Removing And Installing/replacing Airbag Control Unit (build Date From 09/2005)
- Removing And Installing/replacing Front Left Or Right Acceleration Sensor
- Replacing Sensor Mat For Passenger Seat Occupancy Detector
- Removing And Installing (replacing) Airbag Control Unit With Gateway Module2
- Removing And Installing (replacing) Left B-pillar Sensor2
- Removing And Installing (replacing) Vehicle Centre Sensor2
- Removing And Installing (replacing) Left Front Door Sensor
- Overview Of Airbag Modules, Seat Belts, Airbag Control Units And Rollover Protec
- 81 On-board Computer › Removing And Installing/replacing Outside Temperature Sensor
- 82 Central Display And Operating Unit › Removing And Installing (replacing) On-board Monitor2
83 Car Communication Computer (CCC)13 pages
- Removing And Installing/replacing Car Communication Computer2
- Removing And Installing/replacing Fan For Car Communication Computer
- Removing And Installing/replacing Front Trim For Car Communication Computer
- Removing And Installing/replacing CD Drive For Car Communication Computer2
- Removing And Installing/replacing DVD Drive For Car Communication Computer23
- Removing And Installing/replacing Gyro Sensor Drive For Car Communication Comput2
- Replacing HIP Module For Car Communication Computer2
- 90 Navigation Systems › Removing And Installing/replacing Control Unit For Night Vision System
66 Distance Systems, Cruise Control24 pages
31 Adaptive Cruise Control13 pages
54 Night Vision8 pages
67 Electrical Drives20 pages
- 13 Mirror Adjustment › Replacing Drive Unit For Electrically Operated Left Or Right Door Mirror
31 Drive, Seat Adjustment6 pages
- Removing And Installing/replacing Drive For Longitudinal Seat Adjustment (front
- Removing And Installing/replacing Drive For Seat Tilt Adjustment (front Seat Rem
- Removing And Installing/replacing Drive For Seat Height Adjustment (front Seat R
- Removing And Installing/replacing Drive For Backrest Angle Adjustment (front Sea2
- Removing And Installing/replacing Drive For Head Restraint Height Adjustment On
61 Drive, Slide-tilt Sunroof-conv. Top3 pages
- 64 Drive, Steering Column Adjustment › Removing And Installing/replacing Drive Unit For Electric Steering Column Adjust2
- 66 Drive, Seat Adjustment › Removing And Installing/replacing Lumbar Support Drive Mechanism On Front Seat,2
72 Parts - Accessories (Body)53 pages
11 Seat Belts25 pages
- Safety Precautions And General Information
- Checking Automatic Safety Belt23
- Inspection List For Automatic Seat Belt2
- Location Of Checkpoints For Front Seat With Seat-integrated Belt System (SGS)234
- Removing And Installing/replacing Front Seat Belt234567
- Removing And Installing/replacing Front Seat Belt (reel)
- Removing And Installing/replacing Front Left Or Right Lower Strap (belt Tensione2
- Removing And Installing/replacing Rear Left Or Right Seat Belt (roller)
- Removing And Installing/replacing Rear Left Or Right Lower Strap (belt Buckle)
- Removing And Installing/replacing Rear Left Or Right Seat Belt (complete)2
- Overview Of Airbag Modules, Seat Belts, Airbag Control Units And Rollover Protec
12 Airbag Generator-airbag Unit For Pass24 pages
- Replacing Gas Cartridge (pyroactivator) For Crash-active Head Restraint On Front234
- Repairing Airbag Cables2
- Safety Precautions And General Information
- Safety Regulations For Handling Components With Gas Generators2
- Deactivating Front Passenger Airbags With Key-operated Switch2
- Notes On Scrapping Vehicles With Gas Generators (airbag System)2
- Overview Of Airbag Modules, Seat Belts, Airbag Control Units And Rollover Protec
- Procedure After Airbag Triggering As Result Of An Accident23
- Unlocking/locking Airbag Plug Connections234
- Removing And Installing/replacing Airbag Module On Passenger Side2
- Removing And Installing/replacing Airbag Module On Left Or Right Front Door
84 Communication Systems13 pages
86 Trailers107 pages
10 Loading Platform71 pages
- Body And Underbody: Checking For Corrosion And Damage
- Raising BMW Multi-trailer23
- Adjusting Brake System23
- Adjusting Spring Force Accumulator
- Disassembly Of Camlock Retaining Cam
- Disassembly Of Base Plate
- Disassembly Of Bracket On Platform Base
- Disassembly Of Front Apron
- Disassembly Of Front Protection Bar
- Disassembly Of Jockey Wheel Or Jockey Wheel Mount
- Disassembly Of Left And Right Aprons
- Disassembly Of Left And Right Lamp Housings
- Disassembly Of Left And Right Wheel Boxes
- Disassembly Of Licence Plate Mounting Plate
- Disassembly Of Loading Ramp Frame/disassembly Of Rail, Left/right
- Disassembly Of Rear Apron
- Disconnecting Plug Connection, Wiring Harness, Front/rear
- Installation Position Of BMW Lettering
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Removing Camlock Retaining Cam On Loading Ramp
- Removing Camlock Screw Cap
- Removing And Installing Or Replacing Left Or Right Coil Spring2
- Removing Bolt On Loading Ramp
- Removing Brake Shoes2345
- Removing Entry Profile Section On Loading Ramp, Left, Right And Center
- Removing Left Or Right Shock Absorber
- Removing Loading Ramp Lock2
- Removing Mounting Bracket Sealing Cap
- Removing Mounting Bracket, Center, Left And Right
- Removing Outer Pull Rod Mount, Left And Right
- Removing Overrunning Equipment/maintaining Or Replacing Guide Bush/installing Ov2345
- Removing Plastic Bush/metal Bush
- Removing Rear Supports And Bracket
- Removing Reflecting Rear Light
- Removing Rest On Loading Ramp, Left, Right And Center
- Removing Shock Absorber From Overrunning Equipment
- Removing Trailing Arm, Removing And Installing Or Replacing Mounting23
- Removing Wheel Bearing2
- Removing Wooden Rest On Loading Ramp, Left, Right And Center
- Repair Work On GFP Components With Gelcoat Surface
- Replacing 12 Volt Socket2
- Replacing Bar
- Replacing Drawbar Members, Left And Right2
- Replacing Gaiter
- Replacing Holder For Chock
- Replacing Lashing Plate And Lashing Eye
- Replacing License Plate Light
- Replacing Position Light
- Replacing Rear Light
- Troubleshooting On Multi-trailer2
21 Hood36 pages
- Positioning Of Multitrailer Hood For Maintenance And Repair Work2
- Adjusting Hood Pretension - Camloc Fastener With Spacers23
- Adjusting Rear Lid To Fit2
- Adjusting Rotary Striker Lock
- Adjusting Side Lid To Fit2
- Attaching/replacing BMW Badge2
- Fitting BMW Logo
- Installing Hood Seal
- Installing Rubber Roof Strip
- Installing Seal For Rear Lid And Side Lid
- Installing Sponge Rubber Seal
- Removing Ball Pivot
- Removing Centering Pin From Mounting Bracket
- Removing Gas Spring
- Removing Gas Spring Retaining Bracket
- Removing Hinge Bracket On Rear Lid
- Removing Lid
- Removing Lock Barrel
- Removing Lock Striker Fixture On Rear Lid
- Removing Plug For Inside Light2
- Removing Roof Railing
- Removing Roof Railing Adapter2
- Removing Rotary Striker Lock2
- Removing Side Lid Hinge
- Replacing Inside Light
- Replacing Inside Light Power Cable2
99 Paintwork2 pages