Privacy Policy
Donate and help keep workshop manuals freely available.
Other Vauxhall Workshop Service and Repair Manuals
Other Makes
Astra J Workshop Manual
Preface
General Information
Body Hardware and Trim
Body Repair
Body Systems
General Vehicle Information
Brakes
Diagnostic Navigation
Driveline/Axle
Driver Information and Entertainment
Engine
HVAC
Power and Signal Distribution
Roof
Safety and Security
Seats
Steering
Suspension
Transmission/Transaxle
Technical Service Bulletins
Clutch
Shift Lock Control
Manual Transmission - M32-6
Manual Transmission - F40-6
Automatic Transmission - AF40-6
Manual Transmission - F17-5
Repair Instructions
Reverse Lamp Switch Replacement
Front Wheel Drive Shaft Seal Replacement - Left Side
Front Wheel Drive Shaft Seal Replacement - Right Side
Transmission Control Lever Knob Replacement
Manual Gearbox Gear Lever and Selector Lever Cable Adjustment
Manual Transmission Shift Lever and Selector Lever Cable Replacement
Transmission Front Mount Replacement
Transmission Rear Mount Replacement
Transmission Mount Bracket Replacement - Rear
Transmission Control Replacement
Transmission Fluid Level Inspection
Reverse Lamp Switch Removal
Selector and Shift Lever Cable Bracket Removal
Clutch Actuator Cylinder Removal
Selector Control Housing Removal
Transmission Cover Removal
5th Selector Fork Removal
5th Driven Gear Removal
5th Selector Blocking Lever Removal
Transmission Magnet Removal
Clutch and Differential Housing Cover Removal
Clutch and Differential Housing Cover Installation
Transmission Magnet Installation
Selector Shaft Detent Installation
5th Driven Gear Installation
5th Selector Fork Installation
Transmission Cover Installation
Selector Control Housing Installation
Selector and Shift Lever Cable Bracket Installation
Reverse Lamp Switch Installation
Transmission Case Removal
Holding Fixture Installation
Shift Shaft Detent Removal
5th Gear Synchroniser Removal
Selector Shaft and Fork Assemblies Removal
Input Shaft and Main Shaft Removal
Front Differential Assembly Removal
5th Selector Blocking Lever Installation
5th Gear Installation
5th Gear Synchroniser Installation
Holding Fixture Removal
Transmission Case Installation
Selector Shaft and Fork Assemblies Installation
Front Differential Assembly Installation
Main Shaft Assemble
Input Shaft and Main Shaft Installation
Main Shaft Disassemble - F 17
Clutch Actuator Cylinder Installation
Clutch Actuator Cylinder Pipe Installation
Clutch Actuator Cylinder Pipe Removal
5th Gear Removal
Front Differential Assembly Disassemble
Front Differential Assembly Assemble
Description and Operation
Component Locator
Specifications
Special Tools and Equipment
Diagnostic Information and Procedures
Other Information
Schematic and Routing Diagrams
Repair Instructions - On Vehicle
Repair Instructions - Off Vehicle
Automatic Transmission- 6T30 / 6T40 / 6T45