Octavia Mk1: Heating, Air conditioning
Also for this vehicle: Octavia Mk2.
Steering & suspension
Electrical
Body & interior
Heating & A/C
Engine
Transmission
General
Choose Sections to see everything in a chapter, or a chapter title to start at its first page.
Heating, Air conditioning80 pages
Heating23 pages
Repairing heating system21 pages
- Dash panel vent and air guides
- Removing and installing the right dash panel vent
- Removing and installing the centre and left dash panel vent
- Check ventilation frame
- Remove and install air guide duct to defroster vents
- Heating, heater control and air guides
- Removing and installing heater control
- Remove and install Bowden cables from the heater control
- Connection diagram for the Bowden cables on the heater control
- Connection diagram for the Bowden cables on the heating
- Remove Bowden cables on the heater, install and adjust
- Replace bulb for heater control
- Removing and installing fresh air blower V2
- Removing and installing series resistor for fresh air blower N24
- Removing and installing control motor of fresh air flap and re-circulating air flap V154
- Check the function of the fresh air flap and re-circulating air flap control motor V154 and the switch E159
- Remove and install footwell vent
- Removing and installing dust pollen filter
- Remove and install coolant shut-off valve of heating system
- 2 way valve for coolant shut-off valve N147
Air conditioner57 pages
- Safety measures when working on vehicles with air conditioning and when using refrigerant R 134a
Description and components of the air conditioning system, checks as well as repair work, filling contents8 pages
Summary of components for air conditioning and heating - engine compartment (manual control)14 pages
- Air conditioner pressure switch F129
- High pressure sensor for air conditioning system G65
- Removing and installing extractor and filler valves
- Remove and install the heat-protection insulation for the expansion valve
- Removing and installing the refrigerant lines on the expansion valve
- Removing and installing the expansion valve
- Check condensation water drain, remove and install valve
- Inspecting the pressure relief valve on the compressor
- Removing and installing the compressor from/on the holder
- Removing and installing the refrigerant lines of the compressor
- Removing and installing the compressor
- Removing and installing fluid reservoir
- Removing and installing the condenser
- Repair magnetic coupling N25 (manual control and climatronic)
- Repair air conditioning system and heating - passenger compartment (manual control)
Removing and installing the air conditioning unit (manual control)2 pages
- Disassembling and assembling the air conditioning unit (manual control)
- Disassembling and assembling the evaporator housing (manual control)
Climatronic (Air conditioner with automatic regulation) - Self-diagnosis14 pages
- Operation
- Technical data of self-diagnosis
- Test preconditions for self-diagnosis
- Connect vehicle system tester V.A.G 1552 and select climatronic control unit
- Overview of selectable functions
- Interrogating fault memory
- Fault table
- Actuator diagnosis
- Initiating basic setting
- Erasing fault memory
- Ending output
- Code climatronic control unit
- Reading measured value block
Climatronic - Air conditioner with automatic regulation)14 pages
- Function of the Control and display unit for air conditioner, Climatronic E87
- Climatronic - Passenger compartment
- Removing and installing Control and display unit for air conditioner, Climatronic E87 with Climatronic control unit J255
Replacing the air conditioning control motors5 pages
- Removing and installing air conditioning unit
- Middle vent temperature sender G191
- Evaporator vent temperature sender G263
- Disassembling and assembling the evaporator housing
- Climatronic - engine compartment