Water Pump Replacement - 1.3L Diesel LSF (Engine Cooling)

Make

Vauxhall

Model

Astra J

Section

Engine Cooling › Repair Instructions › Water Pump Replacement - 1.3L Diesel LSF

EngineWater Pump Replacement - 1.3L Diesel LSF

Water Pump Replacement (1.3L Diesel LSF) Removal Procedure Warning: With a pressurized cooling system, the coolant temperature in the radiator can be considerably higher than the boiling point of the solution at atmospheric pressure. Removal of the surge tank cap, while the cooling system is hot and under high pressure, causes the solution to boil instantaneously with explosive force. This will cause the solution to spew out over the engine, the fenders, and the person removing the cap. Serious bodily injury may result. 1. Open the hood. 2. Raise the vehicle by its full height. Refer to Lifting and Jacking the Vehicle . 3. Drain the cooling system. Refer to Cooling System Draining and Filling . 4. Remove the drive belt. Refer to Generator and Air Conditioning Compressor Belt Replacement .            5. Remove 4 water pump nuts (3). 6. Remove water pump (1). 7. Remove water pump seal (2). Installation Procedure            1. Install NEW water pump seal (2) to water pump (1). 2. Install water pump (1). Caution: Refer to Fastener Caution . 3. Install 4 water pump nuts (3) and tighten to 9 N·m (80 lb in) . 4. Install the drive belt. Refer to Generator and Air Conditioning Compressor Belt Replacement . 5. Fill the cooling system. Refer to Cooling System Draining and Filling . 6. Close the hood.

11 Engine